Ford Expedition Complaints (2018)

383 consumer complaints on file.

#11462555April 28, 2022
ENGINE
Ford had a recall on this vehicle for Powertrain Control Module (PCM) Reprogram For Cam Phaser Rattle. I returned this vehicle to the dealer on 1/19/20 (37,830 miles on vehicle) the "VCT phasers" were replaced when the parts came in (2/2020). Earlier this month the same "rattle" started again. Returned to dealer on 4/11/22, they reprogramed (21B10) and said it was repaired. It was not and I returned the vehicle to the dealer on 4/19/22. Ford has identified the "rattle" as the same problem, however they are stating that they are NOT responsible because the vehicle is now "out of warranty" (96,229 miles). How does that happen that a vehicle recall that Ford fails to repair in the first place is now not their responsibility to repair?!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11459620April 4, 2022
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
The door opened while driving due to the latch on the rear passenger door popped open. The door now will not stay latched closed. It just continues to stay open. My daughter could have fallen out of the car while we were driving because of this.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11458442March 26, 2022
WHEELS
The lug nuts swell and thus disable the lug wrench or any standard socket from removal. This has prevented me from changing tire or brakes because I can't remove the wheel.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11457756March 22, 2022
ENGINE
Ford has issued an extended warranty for an issue that is clearly a manufacturing issue within their 3.5 ecoboost engine, currently their program is for the replacement of the cam phasers, but they only replace them if the vehicle is under 70k miles on it, if it's pass that mileage the cost goes to the customer, which seems unfair practice as ford have stated that there is a fault with their cam phasers in the engine, but don't have to do a full recall because they give an "extended" warranty which if the vehicle is pass a certain mileage and of no fault of the customer they are allowed to pass the fault to the customers for a factory problem. This issue should be of concern as it can cause the vehicle to go off time and the engine to lock up and cause accidents, harm or even death.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11457793March 22, 2022
WHEELS
When trying to change a flat, the factory provided lug wrench would not go onto the factory lug nuts. I was able to get to the tire shop and was advised of an on going issue with the ford lug nuts “swelling “ which in turn would not allow me to remove them to change the tire. After further digging there seems to be many many complaints of this same issue. It was recommended to purchase new ones that were not a two piece design as the OEM Ford ones are. I was told that this could and most likely would continue to happen and could even cause the wheel to come off in worst case scenario. I had to pay 195 dollars for a new set cause I had no other choice being on the road and away from home or a dealership
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11456516March 13, 2022
UNKNOWN OR OTHER
The auto start stop function failed to restart the engine in an intersection on three occasions. We entered the intersections waiting to make a left turn and the auto stop start turned the car off. When we picked up our foot off the break to complete the left turn and clear the intersection the auto stop start failed to restart the car. An error code came up that said "Auto Start/Stop Shift to P, then restart engine". We shifted to park and restarted the car to clear the intersection to blaring horns. Thankfully there wasn't an immediate need to clear the intersection due to oncoming traffic or we would have been clobbered.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11451328February 10, 2022
UNKNOWN OR OTHER, LATCHES/LOCKS/LINKAGES:DOORS:LATCH, STRUCTURE:BODY:DOOR
Drivers door would not close. Took 10 months for the new door latch to get shipped to my local Ford dealer . They charged us $ 708.00 to do the repair .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11446214January 4, 2022
UNKNOWN OR OTHER
The contact owns a 2018 Ford Expedition. The contact stated that she noticed fluid leaking from the rear of the vehicle while parked. The contact took the vehicle to the dealer where she was informed that the passenger’s side shock needed to be replaced. The contact had also taken the vehicle to an independent mechanic who confirmed the failure and gave her an estimate for the repair. The manufacturer was notified of the failure and a claim was filed. The contact was referred to NHTSA for assistance. The contact stated that she only does city driving and that a failure of this magnitude should not have happened this soon on a newer vehicle. The vehicle had yet to be repaired. The failure mileage was approximately 44,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11442935December 6, 2021
SUSPENSION
Left front Strut was leaking at 7000, was replaced by ford. 12/6/2, the SUV has 27,800 miles and the same Strut is leaking again. The car is been only drive on city roads and freeway. I can see many people are complaining about the same issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11441677November 25, 2021
SUSPENSION
Vehicle has less that 40,000 miles on it. It has become almost uncontrollable if you hit any rough spots on the road. During the last oil change it was noted the rear shocks and struts were bad as well as the front struts. This is far to early for a vehicle to have these issues. It has never been off-road and only towed a small trailer one time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11440325November 13, 2021
WHEELS
The aluminum caps on the lug nuts swell making them impossible to remove with the standard lug wrench. Rather than equipping the vehicles with quality single piece lug nuts instead they are cheap lugs nuts with flimsy caps that are prone to early and premature failure. When I got a flat tire I was unable to remove the lug nuts with the standard lug wrench provided. What should have been a straightforward 1/2 hour tire change ended up being an over 4 hour ordeal on the side of the road. The only way to remove the lugs nuts was with a damaged lug extractor tool which I did not have at the time. The only way to get the tire changed was pay for a tow and then have all 24 lug nuts removed and replaced with better quality single piece nuts at a specialty shop at my expense.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11440292November 12, 2021
WHEELS:LUGS/NUTS/BOLTS/STUDS
Swollen lug nuts.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11439062November 2, 2021
UNKNOWN OR OTHER
The transmission would slip and not go into gear. Causing me to stall in the middle of intersections. This occurred multiple times and if I took my foot off the gas it woudl catch and I could go again. Dealership told me it could be PCM issue and was not able to see me until December of 2021. At the end of October it suddenly became almost undriveable and was limped to dealership. It was determined that the gear ratio for the 3rd gear was incorrect and at 67,318 miles and 4 years old it needs a new transmission.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11437391October 19, 2021
SUSPENSION
When I drove a little bit uneven highway overpass about 50mph with family, three teenagers and my wife, I saw the rear bounces back a lot, almost lost control of the vehicle. Next day, I took it to local Ford Service and they say the rear structs and shocks were completely worn out, and need to be replaced. It has only highway mileage of only just over 20,000miles. Actually they were talking about leaking of oil through the seals and technician showed all four struts were leaking, rears much worse. The vehicle just passed 3 year warranty period by two months, and technician suggested the leakage had been there long before the factory warranty expired. So disappointed with Ford. This was my first Ford and will be the last.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11434781September 28, 2021
SUSPENSION
We have put roughly 20,000 miles on this vehicle and were putting new tires on, when the technician showed me that all four struts were leaking. This vehicle is not driven excessively, it is primarily for short trips around the city and is not used in heavy traffic. A quick search identifies that this is a known issue, with multiple people identifying there concern. There are multiple several complaints on the NHTSA website. So after paying out of pocket, I called Ford to see if they would offer reimbursement. I received a call back from an extremely rude individual informing me that Ford will not reimburse me because there are no active recalls. After I explained that there are multiple complaints about this same issue she stated that Ford does not issue recalls and only the NHTSA will do that. Therefore, I am requesting the NHTSA look into this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11431051August 30, 2021
VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR, EQUIPMENT
The contact owns a 2018 Ford Expedition. The contact stated that the retractable running board failed to open or close intermittently. The contact stated that while stepping on the running board to exit the driver's side door, the running board inadvertently started to close. The contact stated that his foot was caught, and he had to struggle to remove his foot. The contact stated that he sustained no injuries. The vehicle was not taken to an independent mechanic or dealer for diagnosis or repairs. The contact also stated that there were electrical issues with the side view mirrors automatically adjusting without warning. The manufacturer was notified of the mirror failure and advised the contact to call the local dealer. The manufacturer was not made aware of the running board failure. The failure mileage was approximately 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11425864July 21, 2021
POWER TRAIN
The vehicle "chatters" when starting first thing in the morning and sometimes after it sits for a few hours(when engine has had time to cool down). It started about two months ago. We recently took our Expedition to an independent mechanic to have it checked over prior to a road trip. Their diagnosis was a loose timing chain and their recommendation was to take it to a licensed Ford dealership. I contacted three local Ford dealerships and their estimated next available service dates were between 4 and 6 weeks. Plus they are having problems getting some parts. We bought vehicle used with 68,000 miles and did not buy extended service plan. We currently have 95,000 and local dealer advised this repair is not covered by Ford even though Ford Issued TSB 21-2119 acknowledging the problem and recommended fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11425507July 19, 2021
ELECTRICAL SYSTEM
Electrical fire under hood occurred spontaneously. Just before my vehicle shut off the dash board read something about to conserve battery shut engine off. Pulled over got out of car and it burned . Insurance agent is investigating. Sherriff and fireman said it was electrical fire under hood. Had I not decided to pull over at rest stop when I did we would have been on freeway when it ignited.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11422988June 30, 2021
FUEL/PROPULSION SYSTEM
The Fuel filler assembly on our 2018 Ford Expedition broke while filling the vehicle with fuel, causing the entire fuel filler assembly to pop out of the side of the vehicle. The parts appear to be made of weak plastic and/or may be caused by poor design execution. The concern is that this defect could cause fuel to leak out of the assembly and/or the broken parts may render the vehicle unable to be filled with fuel and leave the driver stranded. The vehicle was taken to the dealer who confirmed the issue and ordered replacement parts.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11417927May 20, 2021
ENGINE
The vehicle "chatters" when starting first thing in the morning and sometimes after it sits for a few hours(when engine has had time to cool down). It started about two months ago. We recently took our Expedition to an independent mechanic to have it checked over prior to a road trip. Their diagnosis was a loose timing chain and their recommendation was to take it to a licensed Ford dealership. I contacted three local Ford dealerships and their estimated next available service dates were between 4 and 6 weeks. Plus they are having problems getting some parts.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition