Ford Expedition Service Bulletins (2023)
164 manufacturer communications on file.
- March 1, 2024•Document ID: 10251934Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 52314
- Date Added:
- March 20, 2024
- Manufacturer:
- FORD
SummaryDuring service and repair requiring removal and replacement of a crankshaft bolt and/or crankshaft damper, achieving proper torque of the crankshaft pulley bolt is critical. Incorrect torque may allow the bolt to loosen resulting in the timing gear breaking and engine damage. Replacement of the bolt is critical to the repair and accurately following the installation procedure in the Workshop Manual (WSM) Section, 303-01 is extremely important. The bolt torque procedure can be found in the crankshaft front seal removal and installation procedure or in the engine assembly procedure.
Associated Products (232)2024 Ford Bronco2024 Ford Bronco Sport2024 Ford E-3502024 Ford E-4502024 Ford Edge2024 Ford Escape2024 Ford Expedition2024 Ford Explorer2024 Ford F-1502024 Ford F-2502024 Ford F-3502024 Ford F-4502024 Ford F-5502024 Ford F-6002024 Ford F-6502024 Ford F-7502024 Ford Maverick2024 Ford Mustang2024 Ford Transit2024 Lincoln Aviator+ 212 moreAssociated Documents - February 26, 2024•Document ID: 10250847Service Bulletin/Repair InstructionsPOWER TRAIN; ENGINE AND ENGINE COOLING
- Mfr Comm. #:
- SSM 52295
- Date Added:
- March 5, 2024
- Manufacturer:
- FORD
SummarySome 2021-2023 F-150 and 2023-2024 Expedition/Navigator vehicles equipped with a 3.5L EcoBoost engine may exhibit a rattle/scraping noise from the bellhousing area on start-up. This may be due to the torque converter studs contacting the engine-to-transmission spacer plate (separator plate). To correct this condition, remove the transmission and flexplate and inspect the engine-to-transmission spacer plate and torque converter studs for wear/damage. If wear/damage is found, replace engine-to-transmission spacer plate. Refer to Workshop Manual (WSM) Section 303-01 Engine - 3.5L EcoBoost (BM), Removal and Installation, Crankshaft Rear Seal. When reinstalling the starter motor, be sure the starter is flush with the engine-to-transmission spacer plate prior to tightening the studbolts. Failure to do so may result in damaging newly installed engine-to-transmission spacer plate.
Associated Products (7)Associated Documents - February 16, 2024•Document ID: 10250526Service Bulletin/Repair InstructionsEQUIPMENT; STRUCTURE:BODY:HATCHBACK/LIFTGATE
- Mfr Comm. #:
- SSM 52269
- Date Added:
- February 23, 2024
- Manufacturer:
- FORD
Summary2022-2024 Explorer/Aviator vehicles built on or after 28-May-2022, 2022-2024 Expedition/Navigator vehicles built on or after 08-Jun-2022, 2022-2024 Escape vehicles built on or after 01-Jun-2022 and 2022 Corsair vehicles built on or after 01-Jun-2022 are no longer equipped with a hands free liftgate system. The vehicle is not misbuilt. The addition of any parts is not a warrantable repair. Do not submit a claim for this condition.
Associated Products (16)2024 Ford Escape2024 Ford Expedition2024 Ford Explorer2024 Lincoln Aviator2024 Lincoln Navigator2023 Ford Escape2023 Ford Expedition2023 Ford Explorer2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Escape2022 Ford Expedition2022 Ford Explorer2022 Lincoln Aviator2022 Lincoln Corsair2022 Lincoln NavigatorAssociated Documents - February 12, 2024•Document ID: 10250309Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- SSM 52247
- Date Added:
- February 14, 2024
- Manufacturer:
- LINCOLN
SummarySome 2022-2024 Expedition/Navigator vehicles equipped with a 1 speed transfer case may exhibit a concern where the four-wheel drive (4WD) setting reverts to 2H (two-wheel drive) after a key cycle. This may be due to the transfer case control module (TCCM) software. To correct the condition, reprogram the TCCM using the latest version of the Ford Diagnosis and Repair System (FDRS). For claiming, use causal part 7E453 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (6)Associated Documents - February 7, 2024•Document ID: 10251478Service Bulletin/Repair InstructionsBACK OVER PREVENTION:SOFTWARE; ELECTRICAL SYSTEM
- Mfr Comm. #:
- OTAPU0630-PFMNFO
- Date Added:
- March 7, 2024
- Manufacturer:
- FORD
SummarySoftware Update 23-PU0630-PFM-NFO for 2023 MY EXPEDITION vehicles is now available. Quality Improvements include: - Robustness action to Improve the Master Door Switch Pack loss of functionality.
Associated Products (1)Associated Documents - February 7, 2024•Document ID: 10250303Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:INFOTAINMENT; EQUIPMENT
- Mfr Comm. #:
- SSM 52241
- Date Added:
- February 14, 2024
- Manufacturer:
- FORD
SummarySome 2022-2024 Expedition vehicles equipped with an analog camera and a 12 inch center display screen may exhibit a rear camera image that the customer describes as grainy, fuzzy, or pixelated. This may be due to the interaction between the analog camera and the high definition digital center display screen. To confirm a vehicle is built with an analog camera and a 12 inch center display screen, verify the minor feature codes J3KAR (REAR VIEW CAMERA - LEVEL 2) and HJGAX (MULTI FUNCTION DISPLAY - 12 inch) by reviewing the build information by double-clicking the vehicle identification number (VIN) in the upper left corner in the Professional Technician System (PTS). This is an operating characteristic of the vehicle. Do not attempt any repairs for this condition.
Associated Products (3)Associated Documents - February 1, 2024•Document ID: 10251463Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- TSB 24-2028
- Date Added:
- March 7, 2024
- Manufacturer:
- LINCOLN
SummarySome 2022-2024 Expedition/Navigator vehicles may exhibit a random BLIS warning with no vehicle or objects near the vehicle. This may be due to a mud/snow/ice build-up between the radar sensor and the rear bumper cover or damage or corrosion to the radar sensor, connector or harness
Associated Products (6)Associated Documents - February 1, 2024•Document ID: 10251242Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- 23B71
- Date Added:
- March 5, 2024
- Manufacturer:
- LINCOLN
SummaryCertain 2023 Model Year F150, Expedition, Navigators equipped with 8.8 inch Front Axles - Front Axle Assembly Replacement
Associated Products (3)Associated Documents - January 24, 2024•Document ID: 10249491Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 23B62 S1
- Date Added:
- February 1, 2024
- Manufacturer:
- FORD
SummaryCertain 2023 Model Year F-150, Expedition, and Navigator with 3.5L Engine - Engine Long Block Replacement Owner letters submitted 01/02/24
Associated Products (3)Associated Documents - January 8, 2024•Document ID: 10249751Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- TSB 23-2266
- Date Added:
- February 6, 2024
- Manufacturer:
- FORD
SummarySome 2022-2023 Expedition/Navigator vehicles may exhibit a random BLIS warning with no vehicle or objects near vehicle. This condition may be intermittent, more noticeable in wet conditions. This may be due to a mud/snow/ice build-up between the radar sensor and the rear bumper cover or damage or corrosion to the radar sensor, connector or harness.
Associated Products (4)Associated Documents - December 12, 2023•Document ID: 10247526Service Bulletin/Repair InstructionsBACK OVER PREVENTION
- Mfr Comm. #:
- SSM 52134
- Date Added:
- December 19, 2023
- Manufacturer:
- FORD
SummaryVarious 2021-2024 Ford and Lincoln vehicles equipped with the rear camera on demand feature may exhibit a Please Check Surroundings For Safety or Full View Not Available message when the rear camera button is pressed and the vehicle is not in reverse. Inform customers this condition is considered normal operation and does not affect vehicle durability because the full rear view camera image can only be shown when the vehicle is in reverse. No additional diagnosis or service is required for this condition.
Associated Products (40)2024 Ford Edge2024 Ford Escape2024 Ford F-2502024 Ford F-3502024 Ford F-4502024 Ford F-6502024 Ford F-7502023 Ford Edge2023 Ford Escape2023 Ford Expedition2023 Ford F-1502023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-5502023 Ford F-6002023 Ford F-6502023 Ford F-7502023 Ford Mustang Mach-E2023 Lincoln Corsair+ 20 moreAssociated Documents - December 12, 2023•Document ID: 10247525Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM); ELECTRICAL SYSTEM:SOFTWARE
- Mfr Comm. #:
- SSM 52133
- Date Added:
- December 19, 2023
- Manufacturer:
- LINCOLN
SummarySome 2022-2023 Expedition/Navigator vehicles equipped with a 1 speed transfer case may exhibit a concern where the 4x4 setting reverts to 2H after a key cycle. This may be due to the transfer case control module (TCCM) software. To correct the condition, reprogram the TCCM using the latest version of the Ford Diagnosis and Repair System (FDRS). For claiming, use causal part 7E453 and applicable labor operations in Section 10 of the Service Labor Time Standards (SLTS) Manual.
Associated Products (4)Associated Documents - December 8, 2023•Document ID: 10247159Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- SSM 52115
- Date Added:
- December 11, 2023
- Manufacturer:
- FORD
Summary2023 F-Super Duty, 2023-2024 Expedition and 2024 Nautilus vehicles will exhibit no light emitting diode (LED) confirmation from the key fob indicating that the vehicle has remote started (or not remote started). Factory key fobs with remote start no longer contain a LED feedback indicator. Do not replace the key fob for this condition. This is a normal operating characteristic and no service action is necessary.
Associated Products (10)Associated Documents - December 7, 2023•Document ID: 10248069Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 23B65
- Date Added:
- January 2, 2024
- Manufacturer:
- FORD
SummaryCertain 2023 Model Year F-150, Expedition, and Navigator Vehicles equipped with a 3.5L Engine - Right Hand Turbocharger Replacement
Associated Products (3)Associated Documents - December 6, 2023•Document ID: 10248279Service Bulletin/Repair InstructionsENGINE; UNKNOWN OR OTHER
- Mfr Comm. #:
- TSB 23-2364
- Date Added:
- January 4, 2024
- Manufacturer:
- FORD
SummarySome 2022-2023 F-150 vehicles equipped with a 3.5L EcoBoost engine built on or after 01-Oct-2022, 2023 F-150 vehicles equipped with a 3.5L PowerBoost engine on or after 01-Oct-2022, and 2023 Expedition/Navigator vehicles built on 01-Dec-2022 and through 30-Apr-2023 may exhibit reduced engine power on startup and an illuminated MIL and/or powertrain malfunction (wrench) indicator with diagnostic trouble code (DTC) P2101 stored in the powertrain control module (PCM). This may be due to the software level of the PCM. To correct this condition, perform the Service Procedure below to reprogram the PCM to the latest software level via the Ford Diagnosis and Repair System (FDRS).
Associated Products (4)Associated Documents - December 5, 2023•Document ID: 10248357Service Bulletin/Repair InstructionsSEATS
- Mfr Comm. #:
- TSB 23-2396
- Date Added:
- January 5, 2024
- Manufacturer:
- FORD
SummaryThis article supersedes TSB 23-2036 to add 2024 vehicle model years. Some 2018-2024 Navigator and Expedition vehicles may exhibit a concern where the second row seat back does not fold down or recline when the recline handle is pulled upward or the second row single seat easy entry seat fold switch is pressed. This concern may occur with vehicles equipped with two or three second row seats. This may be due to a broken recliner release lever. To correct this concern, replace the recliner release lever.
Associated Products (14)Associated Documents - December 5, 2023•Document ID: 10247151Service Bulletin/Repair InstructionsVISIBILITY:SUN/MOON ROOF ASSEMBLY
- Mfr Comm. #:
- SSM 52106
- Date Added:
- December 11, 2023
- Manufacturer:
- LINCOLN
SummarySome 2023-2024 Expedition/Navigator vehicles equipped with a roof opening panel built on or before 01-Nov-2023 may exhibit a water leak into the vehicle interior from the driver or passenger front corner area of the roof opening panel. This may be due to a kinked or misrouted roof opening panel drain hose. If this condition is present, refer to Workshop Manual, Section 501-17, Pinpoint Test B6 for Navigator or Pinpoint Test C6 for Expedition to check drain hose flow. Make sure the vehicle is parked on level ground. If drain hose flow is normal, continue diagnosis using Pinpoint Test B for Navigator or Pinpoint Test C for Expedition starting at the beginning.
Associated Products (4)Associated Documents - November 30, 2023•Document ID: 10246077Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 23B62
- Date Added:
- December 5, 2023
- Manufacturer:
- FORD
SummaryCertain 2023 Model Year F-150, Expedition, and Navigator with 3.5L Engine - Engine Long Block Replacement
Associated Products (3)Associated Documents - November 15, 2023•Document ID: 10246123Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 23-2351
- Date Added:
- December 5, 2023
- Manufacturer:
- FORD
SummarySome 2021-2023 F-150, 2022-2023 Expedition/Navigator, 2022-2023 Mustang, 2020-2023 Transit, 2020-2023 Explorer/Aviator vehicles equipped with a 10R80/10R80MHT transmission may exhibit a harsh/delayed engagement and/or harsh/delayed shift, an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes. stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to the software in the powertrain control module (PCM) or transmission control module (TCM), the transmission solenoid ID strategy, sticking valves in the main control valve body and/or axial movement of the CDF clutch cylinder (7H351) sleeve.
Associated Products (21)2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Mustang2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford Mustang2022 Ford Transit2022 Lincoln Aviator2022 Lincoln Navigator2021 Ford Explorer2021 Ford F-1502021 Ford Transit2021 Lincoln Aviator2020 Ford Explorer2020 Ford Transit+ 1 moreAssociated Documents - November 14, 2023•Document ID: 10246128Service Bulletin/Repair InstructionsPOWER TRAIN
- Mfr Comm. #:
- TSB 23-2353
- Date Added:
- December 5, 2023
- Manufacturer:
- FORD
SummarySome 2020-2023 Explorer vehicles equipped with a 2.3L EcoBoost engine, 2022-2023 F-150 vehicles equipped with a 3.5L EcoBoost engine, and 2023-2024 Expedition/Navigator vehicles may exhibit an illuminated malfunction indicator lamp (MIL) and/or powertrain malfunction (wrench) indicator with diagnostic trouble codes (DTCs) P25B3, P25B4, P25B5, P25B6, P2ABA, P2ABB, P2ABC, P2AB7, P2AB8, and/or P2AB9. This may be due to the software in the powertrain control module (PCM). To correct this condition, follow the Service Procedure to reprogram the PCM.
Associated Products (10)Associated Documents