Ford · Model Report
Showing safety data for the 2000 model year only.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
ON CERTAIN VANS EQUIPPED WITH SURE-LOK WHEELCHAIR SECUREMENT SYSTEMS, THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY IS OUT OF ALIGNMENT.
VEHICLE DESCRIPTION: BI-FUEL CNG PICKUP TRUCKS AND BI-FUEL CNG VANS, MODIFIED BY CFI CONTROL SYSTEMS, INC., FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 303, "FUEL SYSTEM INTEGRITY OF COMPRESSED NATURAL GAS VEHICLES." THE LABEL AFFIXED TO THE FUEL FILLER DOOR BY THE VEHICLE MODIFIER CONTAINS THE INSPECTION DATE AND EXPIRATION DATE OF THE CNG TANK. HOWEVER, IT DOES NOT CONTAIN THE STATEMENT "SEE INSTRUCTIONS ON THE FUEL CONTAINER FOR INSPECTION AND SERVICE LIFE."
TL* THE CONTACT OWNS A 2000 FORD E-250. THE CONTACT STATED THAT THE SPEED CONTROL SWITCH BECAME DETACHED FROM THE VEHICLE. THE CONTACT WAS UNABLE TO ACTIVATE THE CRUISE CONTROL AND STATED THAT THERE WAS CORROSION ON THE AREA THAT WAS EXPOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
No injuries · No fire · No crash
2000 FORD E250 VAN, PURCHASED NEW AUG 2000. PURCHASED EXTENDED WARRANTY, 5 YEARS. NOVEMBER 2005; HARMONIC BALANCER FELL OFF ENGINE. ~79K MILES (APPROX 3 MONTHS OUT OF WARRANTY) TOWED TO DEALER AND REPAIRED. JULY 2007; HARMONIC BALANCER FELL OFF ENGINE. ~101K MILES. TOWED TO DEALER AND REPAIRED. REPAIR PARTS ARE WARRANTED FOR 12 MONTHS. THIS IS 8 MONTHS OUT OF WARRANTY. PLEASE NOTE: HARMONIC BALANCERS DO NOT USUALLY FALL OFF OF ENGINES. THIS REPAIR HAS A 12 MONTH WARRANTY. *JB
No injuries · No fire · No crash
UNDER HOOD FIRE. *JB
DT*: THE CONTACT STATED WHILE SITTING IN THE DRIVEWAY FOR TWO DAYS, THE VEHICLE CAUGHT ON FIRE AND CAUSED DAMAGE TO THE CONTACT'S HOUSE, THE NEIGHBOR'S HOUSE AND ANOTHER VEHICLE OWNED BY THE CONTACT. BOTH VEHICLES WERE TOTALED. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRES. THE FIRE DEPARTMENT DETERMINED THE FIRE ORIGINATED IN THE WIRING OF THE VEHICLE IN BACK OF THE BATTERY. THERE WERE NO PROBLEMS WITH THE VEHICLE PRIOR TO THE INCIDENT. THE DEALERSHIP WAS NOTIFIED.
BROKEN VALVE SPRING, 2 BENT PISTON RODS, 1 BROKEN PISTON ROD, TWO DAMAGED PISTONS, 2 HEADS REPLACED, GASKETS REPLACED WATER HAS BEEN THE CAUSE BUT THE INTAKE MANIFOLD HAS ALWAYS TESTED OK AS WELL AS THE HEADS. *JB
No injuries · No fire · No crash