Ford · Model Report
Showing safety data for the 1989 model year only.
THE DUAL FUEL TANK SELECTOR VALVE MAY MALFUNCTION AND CAUSE AN OVERFILL CONDITION IN ONE OF THE FUEL TANKS, RESULTING IN AN OVERFLOW OF FUEL PAST THE FILLER CAP.
UNDER CERTAIN CONDITIONS, THE SNAP RING THAT LOCATES THE PARK GEAR ON THE OUTPUT SHAFT OF THE TRANSMISSION MAY FRACTURE.
Ignition control module fails due to excessive heat buildup, due to where the control module is located. The ignition control module needs to be relocated to a cooler area under the hood, and mounted on a large heat sink, and this new location should be where cooling airflow from front of van flows over the ignition control module and its connected heat sink. The ignition control module will fail without any warnings, no warning lamps, or any other symptoms. This problem leaves your vehicle and your passengers stranded until it cools down which can take an hour or more! Then will happen again, and again when it heats up. it has failed when I had just pulled into an intersection, when I was traveling down a city street and on the expressway! and when stopped at a stop sign or traffic light! Ford knows this problem exists in this model van and Ford's pickup truck lines, and other model Ford cars. has only addressed the problem happening to mustang models!
No injuries · No fire · No crash
NHTSA CAMPAIGN ID# 91V146000 REFERS TO A SAFETY RECALL FOR A FAULTY DUAL FUEL TANK SELECTOR VALVE IN FORD ECONOLINE VANS EQUIPPED WITH DUAL FUEL TANKS BUILT BETWEEN 1989 AND 1991 AND OTHER SIMILAR MODELS . I HAVE CONTACTED FORD TO INVESTIGATE , BUT THERE ARE NO RECORDS THAT CONFIRM OR DISAFFIRM MY VEHICLE'S INCLUSION IN THIS RECALL. BASICALLY, I DON'T KNOW IF MY VAN WAS AFFECTED BY THIS RECALL AND IF ANY RECALL SERVICES WERE PERFORMED. I AM EXPERIENCING A FAULT IN THE DUAL FUEL TANK SYSTEM. IT SEEMS THAT THE FUEL SELECTOR VALVE WILL NOT SWITCH TO THE MAIN TANK, AND WHEN FILLED, THE MAIN TANK WILL FLOW PAST THE FILLER CAP AND CAUSES A FUEL LEAKAGE, WHICH CAN RESULT IN A FIRE WHEN EXPOSED TO A SOURCE OF IGNITION. I CONTACTED A LOCAL FORD DEALER WHO ADVISED ME THAT NO RECALL SERVICE CAN BE PERFORMED TO REMEDY THIS PROBLEM BECAUSE MY VIN# DOES NOT REGISTER IN THE FORD RECALL DATABASE. AGAIN, FORD CANNOT CONFIRM OR DISAFFIRM ANY RECALL SERVICES PERFORMED ON MY VEHICLE. I AM NOT THE ORIGINAL OWNER OF THIS VEHICLE SO I DO NOT HAVE ANY SERVICE RECORDS PRIOR TO 2005. IN AN ATTEMPT TO CORRECT THIS CONCERN, I HAVE ALREADY REPLACED THE SECONDARY FUEL PUMP, AS ADVISED BY MY LOCAL MECHANIC. I HAVE ALSO OVERHAULED BOTH FUEL TANKS TO CHECK FOR CLOGGING, OR ANY FOREIGN MATERIALS, AND I HAVE REPLACED SEVERAL SEALS AND MISC. HARDWARE IN THE FUEL SYSTEM. THIS CONCERN HAS BEEN A PROBLEM SINCE I PURCHASED THE VEHICLE IN 2005. I AM ONLY ABLE TO OPERATE MY VEHICLE ON THE AUXILLARY (REAR) FUEL TANK WITH A 13 GALLON CAPACITY. WHEN THE SELECTOR SWITCH IS ON THE FRONT TANK, THE VEHICLE WILL EVENTUALLY STALL AS IF IT IS OUT OF FUEL. WHEN THE FUEL SELECTOR SWITCH IS SET TO THE REAR TANK, I AM ABLE TO OPERATE THE VEHICLE NORMALLY WITH THE EXCEPTION OF THE LIMITED RANGE DUE TO THE SMALL AUXILLARY FUEL TANK. *TR
No injuries · No fire · No crash
VAN DIED,TOWED TO MECHANICS SHOP,WAS TOLD SWITCH VALVE BETWEEN TANKS WAS PROBLEM, LOOKED ON NHTSA WEBSITE ABOUT RECALLS. FORD VAN 89 E-150 WITH DUEL GAS TANKS. FORD SAFETY RECALL NUMBER IS 91S39 WENT TO FORD WEB SITE,CALLED THEM ON PHONE, CUSTOMER SERVICE AND LOCAL DEALERSHIP. BOTH SAID THERE WAS NO RECALL ON MY VAN. *TR
No injuries · No fire · No crash
WHILE DRIVING, THE TIRE EXPERIENCED TREAD SEPARATION AND DAMAGED THE FRONT FENDER. *AK THE VALVE STEM WAS ALSO REPLACED. *PH *JB
No injuries · No fire · No crash
IGNITION MODULE HAS BEEN GIVING US PROBLEMS SINCE PURCHASED-1993- ONE TIME THE MODULE FAILED AND ANOTHER TIME IT WAS REPLACED, STILL THE PROBLEM PERSISTS. *AK
No injuries · No fire · No crash