Ford E-150 Complaints (1999)

83 consumer complaints on file.

#11448477January 22, 2022
STEERING
While turning into a parking space the bolts to the steering box sheared off with complete loss of steering. Further inspection showed severe cracking and loss of metal in the steering box area. After doing some searches I found that this is common issue in the E series vans. I did do a recall search and a CSA search to see about having this problem resolved safely by a certified shop. Unfortunately I haven't found any recall information on what is obviously a serious safety issue. Apparently the bolts shear off at low speeds while turning. The real concern is should one bolt only crack and not let the steering box become useless the vehical may be at highway speed when the failure does occour causing complete loss of control of the vehicle. I've read hundreds of emails on this subject and none had a resolution provided by the Ford Motor Company. I would think that something this critical would have been addressed by now. Concidering the recalls for comparatively much lesser safety issues. Thank you for reviewing this matter.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10905028September 9, 2016
FUEL/PROPULSION SYSTEM
MY MARK III CONVERSION VAN HAS A FUEL LEAKING FROM THE MID-SHIP TANK. I NOTICED THAT THERE IS A RECALL FROM FORD, BUT WHEN I WENT TO MY LOCAL DEALER ENFIELD FORD IN ENFIELD CT THEY RAN THE VIN AND STATED MY VAN WAS EXCLUDED. THE ONLY TIME IT LEAKS IS WHEN I AM PUMPING GAS, IF I PUMP SLOWLY THERE IS LESS FUEL SPILLING ON THE GROUND
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10733578July 13, 2015
FUEL/PROPULSION SYSTEM, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
TL* THE CONTACT OWNS A 1999 FORD E-150. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE VIBRATED. THE CONTACT DISCOVERED THAT THE FUEL STRAP BENEATH THE FUEL TANK ON THE REAR AXLE WAS RUSTED AND FRACTURED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WELDING ON THE TAIL PIPE WAS ALSO RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 128,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10627975August 25, 2014
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1999 FORD E-150. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL DUE TO A HOLE IN THE FUEL TANK. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 01V114000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10627978August 25, 2014
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1999 FORD E-150. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL DUE TO A HOLE IN THE FUEL TANK. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 01V114000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10583980April 21, 2014
FUEL SYSTEM, GASOLINE
THE GAS IS LEAKING OUT OF THE FUEL TANK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10567400March 5, 2014
FUEL SYSTEM, GASOLINE
WHEN FILLING WITH FUEL, GASOLINE LEAKS ONTO GROUND. THIS APPEARS TO BE A COMMON PROBLEM FROM WHAT I SEE ON LINE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10563950February 12, 2014
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1999 FORD E-150 . THE CONTACT STATED THAT WHILE REFUELING, FUEL STARTED TO SPEW OUT OF THE TOP OF THE FUEL TANK. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 132,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10552861November 19, 2013
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1999 FORD E-150. THE CONTACT STATED THAT AFTER REFUELING, HE NOTICED FUEL LEAKING FROM THE TOP OF THE FUEL TANK AS A RESULT OF POSSIBLE RUST CORROSION. THE CONTACT PLANNED TO REMOVE THE FUEL TANK TO FURTHER INVESTIGATE THE DEFECT. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 120,300.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10399497May 9, 2011
FUEL SYSTEM, GASOLINE
I WOULD LIKE TO REPORT A FINDING ON MY 1997 F-150. AFTER READING ABOUT THE PROB INTO THE GAS TANK STRAPS IN THE DETROIT NEWS. I FOUND THAT ONE OF MY STRAPS HAS COMPLETELY RUSTED OFF AND I WOULD LIKE TO BE NOTIFIED AS SOON AS A RECALL IS MADE AS THIS IS A SERIOUS HAZARD , [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10397225April 23, 2011
STEERING
THE 3 MOUNTING BOLTS ATTACHING THE STEERING BOX TO THE FRAME BROKE/SHEARED OFF AS THE VEHICLE WAS BEING PARKED IN THE DRIVEWAY. 1999 FORD E150 VAN. A LOUD POPPING NOISE OR BANG WAS HEARD AND TOTAL LOSS OF STEERING WAS THE RESULT OF THE STEERING BOX DANGLING FROM THE FRAME. THE VEHICLE WAS BEING REPOSITIONED ON A FLAT DRIVEWAY, NO INCLINE AT ALL. NO INJURIES RESULTED , BUT IF THE FAILURE HAD OCCURRED DURING OPERATION, STEERING WOULD HAVE BEEN INOPERABLE LEADING TO AN ACCIDENT WHICH EASILY COULD HAVE LED TO SERIOUS INJURY TO THE DRIVER, PASSENGERS, AND OTHER VEHICLES AND THEIR OCCUPANTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10397123April 22, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 1999 FORD E-150. THE CONTACT STATED THAT WHILE REFUELING THE VEHICLE, HE NOTICED THAT FUEL WAS LEAKING FROM THE TOP OF THE FUEL TANK. THE VEHICLE WAS TAKEN TO AN AUTOMOTIVE SHOP WHERE THE CONTACT WAS ADVISED THAT THERE COULD HAVE BEEN A FRACTURE IN THE TANK WHICH CAUSED THE LEAKAGE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGE WAS 139,790.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10357355September 24, 2010
STRUCTURE, FUEL SYSTEM, GASOLINE
DRIVING DOWN THE I94 FREEWAY IN MICHIGAN WITH MY WIFE, 2 CHILDREN, 7 AND 5,GOING ABOUT 70 MPH AND HEARD A NOISE LIKE A MUFFLER DRAGGING OR SOMETHING. IMMEDIATELY PULLED OVER AND FOUND MY GAS TANK DRAGGING UNDER THE TRUCK. FRONT STRAP RUSTED AND BROKE OFF AND TANK WAS BEING PUSHED FORWARD, ALMOST GRINDING ALL THE WAY THROUGH! THE TANK WAS BEING HELD UP BY THE PLASTIC REAR STRAP HOLDER AND THE GAS FILLER TUBE. THE BACK STRAP WAS ALSO RUSTED THROUGH! HAD TO JACK UP THE TANK WITH BOTTLE JACK AND PIECES OF 2X4 FOUND ALONG THE FREEWAY. WAITED FOR FATHER IN LAW TO BRING RATCHET STRAPS TO LIFT UP VERY HEAVY FULL TANK WHILE LYING ON MY BACK ON THE FREEWAY. MY FAMILY WAS TERRIFIED! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10355700September 15, 2010
FUEL SYSTEM, GASOLINE, STRUCTURE
1999, FORD F-150 GAS STRAP FAILURE. TUESDAY SEPTEMBER 14, 2010 WHILE DRIVING ON INTERSTATE 94 I COULD HEAR A CLINKING NOISE BENEATH THE BODY OF THE TRUCK. WHEN I PULLED OVER AND LOOKED UNDER THE TRUCK, ONE OF THE SUPPORT STRAPS FOR THE GAS TANK WAS BROKEN AND HANGING BELOW THE VEHICLE. THIS STRAP FAILED WITHOUT ANY KNOWN EXTRAORDINARY CAUSE SUCH AS A COLLISION, OR ANY OTHER SUCH INCIDENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10352977August 31, 2010
SUSPENSION:REAR, SERVICE BRAKES, HYDRAULIC
WE WERE ON VACATION AND SMELLED RUBBER BURNING, PULLED OFF AND REAR PASSENGER TIRE WAS SMOKING...APPARENTLY AXLE HAD BROKEN AFFECTING BRAKE LINES WE ENDED UP REPLACING REAR AXLE AND BRAKES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10294101December 1, 2009
ENGINE AND ENGINE COOLING:ENGINE
THE SPARK PLUG BLEW OUT ON MY FORD E150. THIS IS A RIDICULOUSLY COMMON PROBLEM WITH FORD TRUCKS/VANS/ SUVS- WHY IS FORD ALLOWED TO GET AWAY WITH THIS? JUST GOOGLE "FORD SPAR" AND INSTANTLY "FORD SPARK PLUG BLOWOUT" POPS UP- THERE ARE HUNDREDS OF WEBPAGES ABOUT THIS, YET FORD CONTINUES TO ESCAPE LIABILITY FOR THEIR POOR DESIGN. CAN'T SOMEONE MAKE THESE PEOPLE @ FORD DO THE RIGHT THING AND FIX IT? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10294140December 1, 2009
ENGINE AND ENGINE COOLING
DRIVING DOWN ROAD WHEN # 8 SPARK PLUG BLEW OUT OF PLUG HOLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10288676October 16, 2009
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
TL*THE CONTACT OWNS A 1999 FORD E-150. HE NOTICED A PUDDLE OF GASOLINE OUTSIDE OF THE FUEL TANK. THE VEHICLE WAS TAKEN TO A FUEL SPECIALIST, AND THE TECHNICIAN CONCLUDED THAT THE FUEL TANK WAS CRACKED. HE NOTIFIED THE DEALER IN REFERENCE TO RECALL #01V114000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY) AND WAS ADVISED THAT ALTHOUGH HE EXPERIENCED AN IDENTICAL FAILURE, HE WAS INELIGIBLE FOR A FREE REMEDY SINCE HIS VEHICLE IDENTIFICATION NUMBER WAS EXCLUDED. THE FAILURE AND CURRENT MILEAGES WERE 120,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10277898July 22, 2009
FUEL SYSTEM, GASOLINE
I OWN A 1999 FORD E150 THAT APPEARS TO HAVE BEEN PREPARED FOR AN UPFITTER WHEN IT LEFT THE FORD PLANT. AN AMBULANCE PREP LABEL IS IN THE DRIVER'S SIDE DOOR JAM, HOW EVER IT WAS FINISHED BY EXPLORER VAN COMPANY, WARSAW INDIANA. WHEN REFUELING I NOTICED FUEL SPILL ON THE GROUND. I STOPPED DRIVING THE VEHICLE AND RESEARCHED THE PROBLEM. FORD SERVICE TELLS ME THAT IT FUEL FILLER NECK IS THE PROBLEM AND IT WILL COST ABOUT $600 TO MAKE THE REPAIR. MY VIN DOES NOT SHOW VALID FOR PROBLEM NHTSA RECALL 11V114000 WHEN REPORTED TO FORD BUT THE PROBLEM SEEMS VERY SIMILAR TO 11V114000. MY VIN IS [XXX] . SHOULDN'T THIS HAVE BEEN A COVERED RECALL? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10252518December 22, 2008
FUEL SYSTEM, GASOLINE
TL*THE CONTACT OWNS A 1999 FORD E-150 ECONOLINE. WHENEVER THE CONTACT FILLS THE FUEL TANK, GASOLINE WOULD SPILL OUT OF THE TANK AND ONTO THE GROUND. WHEN THE TANK WAS FULL AND THE FUEL NOZZLE STOPPED, GASOLINE STILL LEAKED EXCESSIVELY OUT OF THE TANK. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 59,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford E-150