Ford · Model Report
Showing safety data for the 2002 model year only.
Dorman Products, Inc. (Dorman) is recalling certain model Dorman Steering Shafts, part number 425-359, Solutions Steering Shafts, part number 7-0359, and OE Solutions Steering Shafts, part number 425-359, manufactured April 17, 2014, to September 28, 2015. These aftermarket replacement steering shafts are sold for use in 1995-2002 Ford Crown Victoria, Mercury Grand Marquis, and Lincoln Town Car vehicles. These steering shafts may separate during operation if the integral fastener is loose or missing and if the interfacing vehicle shaft is compressed in length.
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
ON CERTAIN NATURAL GAS VEHICLES, IF A FLAME FROM A VEHICLE INTERIOR FIRE BECOMES LOCALLY DIRECTED AT THE NATURAL GAS FUEL TANK LOCATED IMMEDIATELY BEHIND THE REAR SEAT, THE FLAME COULD DAMAGE THE FIBERGLASS WRAP ON THE TANK WEAKENING THE TANK.
IN ORDER TO ENHANCE POLICE OFFICE SAFETY, MODEL YEAR 1992-2003 CROWN VICTORIA POLICE INTERCEPTOR (CVPI) VEHICLES WILL BE EQUIPPED WITH SHIELDS DESIGNED TO HELP PROTECT THE FUEL TANK IN HIGH-SPEED REAR-IMPACT CRASHES. FORD ALSO WILL BE OFFERING AN OPTIONAL TRUNK PACKAGE DESIGNED TO IMPROVE THE SAFE TRANSPORT OF SHARP-EDGED, HEAVY EQUIPMENT IN THESE VEHICLES.
ON CERTAIN NATURAL GAS MODEL VEHICLES, A T-FITTING THAT CONNECTS FUEL TANKS #3 AND #4 CAN DEVELOP A LEAK WHEN THE SOLENOID VALVES ARE ENERGIZED, SUCH AS WHEN THE IGNITION SWITCH IS IN THE ON POSITION OR DURING REFUELING.
..
Driving down the roadway at 55 mph a spark plug in cylinder 2 blow out. The car started making a popping noise and started to lose power. After a while the car shut off. The car was able to restart and be driven home. Upon inspection by a mechanic they found the spark plug had came dislodged and shot out of the cylinder and caused damage to the cylinder head the ignition coil and fuel rail. A new Heli coil was installed. A year later while in Texas driving down the road around 35 mph car made a pop noise and shot a spark plug out of cylinder 5 cause the car to lose power and start smoking with a heavy smell of fuel. Car was stopped and inspected. Found a spark plug was blown out of cylinder 5 with damage to the ignition cylinder and fuel rail. repaired the heli coil and placed with new spark plug ignition coil and fuel rail. 2019 while driving down road at 75 mph vehicle makes a loud pop and starts to lose power. Upon inspection by mechanic find spark plug blown out of cylinder 1 with damaged ignition coil. Having mechanic is now replacing both cylinder heads on the engine.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING APPROXIMATELY 45 MPH AND ATTEMPTING TO MAKE A TURN, THE TURN SIGNALS AND HEADLIGHTS FAILED TO WORK, EXCEPT WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT ALSO NOTICED THAT THE TAIL LIGHTS DID NOT WORK AND THE DASHBOARD WAS BLACKED OUT. THE VEHICLE WAS TAKEN TO A LOCAL DEALER WHO WAS UNABLE TO SCHEDULE THE VEHICLE FOR A DIAGNOSTIC EVALUATION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 38,000. UPDATED 10/06/16*LJ ** UPDATED 10/19/16*LJ *TR
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. THE CONTACT STATED THAT THE HEADLAMPS DID NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE LIGHTING CONTROL MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 15V861000 (EXTERIOR LIGHTING); HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 197,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2002 FORD CROWN VICTORIA. WHILE DRIVING 35 MPH AND PROCEEDING TO STOP AT A RED LIGHT, THE ENGINE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART AFTER NUMEROUS ATTEMPTS. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE MANIFOLD WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 81,218.
No injuries · No fire · No crash