Dodge · Model Report
Showing safety data for the 2009 model year only.
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY PASSENGER VEHICLES MANUFACTURED FROM FEBRUARY 2007 THROUGH SEPTEMBER 2009. SOME OF THE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION.
While driving, the engine shuts off, leaving the driver with no power steering or power brakes. All power is off. There is no warning or error messages on the dash of any kind. No warning at all. The last time this happened, I was able to coast to the side of the road to a stop. Once stopped, i can put the transmission in Park, restart the vehicle and continue. This time, I drove directly to my service shop to have the computer checked for codes. There were none, like the event never happened. They could not reproduce the problem. This has happened 3 times since August 2025. The wireless ignition module was replaced in 2015 under the recall notice 14V373000. That recall was for exactly this situation. So far, I have been fortunate to avoid hitting another vehicle or other objects. This is not a safe situation, especially knowing it might happen tomorrow.
No injuries · No fire · No crash
In August 2024, the airbag system in a 2009 Dodge Grand Caravan (VIN: [XXX] ) deployed unexpectedly while the vehicle was parked and not in operation. There was no collision, impact, or known external trigger at the time of deployment. The malfunction involved the airbag restraint system and/or related electrical or control components. An unexpected airbag deployment creates a serious safety concern because it could injure vehicle occupants or bystanders and indicates a potential defect in the restraint system. The vehicle was immediately taken to Banister Chrysler Dodge Jeep Ram in Hampton, Virginia, where it has remained since the incident. To the best of our knowledge, the vehicle has remained in dealership/manufacturer custody and should be available for inspection. The manufacturer indicated they were reviewing the matter and determining the value of the vehicle; however, despite extended time passing, no repair, replacement, or written resolution has been provided. The issue has not been reproduced because the vehicle has remained out of service since the incident. It is UNKNOWN whether the precise cause has been formally confirmed by the manufacturer or dealership. No injuries occurred, but the incident placed the safety of the owners and others at risk because a critical safety restraint system deployed without warning while the vehicle was stationary. Documented NHTSA recalls affecting Dodge Grand Caravan airbag systems and related models demonstrate prior manufacturer awareness of airbag-related safety defects. Although this VIN currently shows no open recall, the spontaneous deployment raises concern regarding unresolved or inadequately corrected airbag system defects. No known warning lamps or dashboard messages were specifically recalled prior to the incident. Any additional warning indicators are UNKNOWN. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
Car will crank but not start. Can cannot be started intermittently which could be dangerous considering location of vehicle, adverse weather conditions, etc. There are no warning lamps or messages related to the problem. This is a known problem with other Chrysler models and model years. TIMP fuel pump relay has failed. Bypassing the fuel pump relay will allow car to start. See attached file of Vertical Vissions' bypass solutions to this problem.
No injuries · No fire · No crash
While driving on major (multi-lane) city street (40 mph) the vehicle began to slow, steering became difficult and a single amber caution for the traction control was illuminated. Tachometer indicated 0 RPM. After pulling over, the vehicle was restarted and driven without further issue. Recall on the ignition switch was addressed in 2009. Unexpected engine shutdown could have significantly reduced safety margins in heavy traffic. No third party inspected vehicle after incident. Owner notes that key fob does not have anything hanging of it that could aggravate unwanted movement of ignition switch
No injuries · No fire · No crash
I had a flat tire (drivers front). I Parked on a level parking lot. I put bricks behind other tires to prevent movement. Next I loosened lug nuts, I then removed the spare and original equipment jack. I began jacking the car up with the jack in the area indicated for jacking by the instructions. The tire was off the ground. I was beginning to spin off the lug nuts when the car dropped with a brrrrrt sound. The main screw in the scissors jack pulled through the threaded nut on the end. The jack was still upright but the screw threads failed. No one was hurt but the potential is high for the jack to fail suddenly and without warning. Note the van was not occupied or in any way loaded. The second picture attempts to show the screw threads deformed after pulling through the nut.
No injuries · No fire · No crash