Dodge Grand Caravan Complaints (2006)

286 consumer complaints on file.

#10418265August 9, 2011
AIR BAGS:FRONTAL
TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIANS STATED THAT THE AIR BAG SENSOR WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 10V008000 (AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE) THAT COULD HAVE BEEN RELATED TO THE FAILURE BUT THE CONTACT WAS ADVISED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10413606July 19, 2011
AIR BAGS:FRONTAL
TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED AND THE FRONT AIR BAGS DEPLOYED UNEXPECTEDLY. AS A RESULT, THE CONTACT SUSTAINED MINOR INJURIES FROM THE KNEE TO THE LOWER LEG AREA. THE AIR BAG MALFUNCTION OCCURRED WITHOUT ANY IMPACT TO THE VEHICLE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE AN INDEPENDENT INSPECTOR EXAMINED THE VEHICLE. THE PRELIMINARY DIAGNOSTIC REPORT INDICATED THAT THE FAILURE WAS RELATED TO THE ELECTRONIC CONTROL MODULE AND WAS NOT DUE TO A MANUFACTURER'S DEFECT. ALSO, THE COMPUTER DETECTED THAT THE AIR BAG WARNING INDICATOR ILLUMINATED FOR OVER TWO HUNDRED AND FIFTY DRIVING HOURS. THE CONTACT STATED THAT THE WARNING LIGHT WAS ILLUMINATED FOR NO LONGER THAN FIVE MINUTES, AND THE INFORMATION IN THE PRELIMINARY REPORT WAS FALSE, IN REGARDS TO THE OPERATIONAL HOURS OF THE AIR BAG WARNING LIGHT. AFTER THREE WEEKS, THE VEHICLE WAS STILL IN THE POSSESSION OF THE DEALER. THE FAILURE MILEAGE WAS 55,000. UYPDATED 09/16/11 *BF UPDATED 2/10/12 *CN
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10411600July 9, 2011
AIR BAGS
AIR BAG WARNING LIGHT IS ON. HORN DOES NOT WORK. CRUISE WORKS SOMETIMES. DIAGNOSIS IS CLOCK SPRING. REVIEW OF ONLINE INFO SHOWS REPEATED CLOCK SPRING RECALLS FROM LATE 1990S TO EARLY 2000S. VEHICLE HAS LESS THAN 37,000 MILES ON IT. AIRBAG IS NON-FUNCTIONAL AT THIS TIME, AS IS HORN AND CRUISE CONTROL, HENCE A SAFETY ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410701July 6, 2011
EXTERIOR LIGHTING:TURN SIGNAL
TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE TURN SIGNALS WERE DEFECTIVE AND WOULD ONLY FUNCTION INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN FOR INSPECTION OR REPAIRS. THE FAILURE AND CURRENT MILEAGE WAS 105,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10409250June 28, 2011
EQUIPMENT, ENGINE AND ENGINE COOLING
I DON'T KNOW MUCH ABOUT CARS- BUT GRAND CARAVANS 05 AND 06 MODELS ARE ALL HAVING REAR EVAPORATOR'S THAT ARE BREAKING DOWN. IN FACT IF YOU PUT IN "REAR EVAPORATOR" INTO GOOGLE THE FIRST LINK IS ABOUT THE GRAND CARAVAN PROBLEM. THAT'S HOW BAD IT IS. IT'S AN EXPENSIVE PART AND THEY AREN'T DOING A RECALL DUE TO BAD CRAFTSMANSHIP. I DON'T THINK THIS CONSTITUTES A SAFETY RECALL BUT AMERICAN CONSUMERS ARE GETTING CHARGED FOR SOMETHING THAT IS A KNOWN DEFECT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10408938June 26, 2011
ENGINE AND ENGINE COOLING:ENGINE
WHILE DRIVING DOWN THE HIGHWAY IN HEAVY TRAFFIC THE ENGINE BLOWS OUT OF NO WHERE LEAVING THE VAN ALMOST INOPERABLE. I HAVE COME TO FIND OUT THAT THIS IS A VERY COMMON PROBLEM WITH THESE 3.8 LITER ENGINES. IT WAS DRIVING FINE AND THEN THERE WAS EXTREMELY LOUD KNOCKING AND A SUDDEN LOSS IN POWER. ONCE I WAS ABLE TO GET PULLED OVER I CHECKED THE OIL AND IT HAD "DISAPPEARED". TO CORRECT THE ISSUE A NEW ENGINE IS NEEDED AND THESE NEWER ENGINES FROM CHRYSLER HAVE A MODIFIED OIL PUMP WHICH TELLS ME THEY KNOW ABOUT THIS PROBLEM AND ARE CORRECTING IT BUT ONLY AFTER YOU SPEND THOUSANDS OF DOLLARS FOR THE NEW MOTOR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10408653June 23, 2011
EXTERIOR LIGHTING
TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE OPPOSITE TURN SIGNAL WOULD ILLUMINATE WHEN HE ATTEMPTED TO OPERATE THE TURN SIGNALS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CLOCK SPRING WAS REPLACED. THE CONTACT WAS ALSO STATED THAT THE FAILURE WAS A WIDESPREAD ISSUE AMONG HIS VEHICLE MAKE AND MODEL. THE FAILURE MILEAGE WAS 72,000 AND THE CURRENT MILEAGE WAS 77,000. UPDATED 08/31/11 *BF THE DEALER REPLACED THE CLOCKSPRING ASSEMBL. UPDATED 09/09/11
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10400959May 16, 2011
ELECTRICAL SYSTEM
WE OWN A 2006 DODGE GRAND CARAVAN , THE PROBLEMS STARTED WITH THE TURN INDICATOR NOT WORK CORRECTLY , IT FLASHES ON THE WRONG SIDE , IF YOU CLICK IT TO TURN RIGHT THE LIGHTS WORK FOR THE LEFT SIDE , SOME TIME IT WILL NOT WORK AT ALL. NOW THE KEY LESS ENTRY DOESN'T WORK THE FIRST TIME YOU PRESS IT UNLOCKS THE DRIVERS SIDE ONLY PRESS IT TWO TIMES RAPIDLY AND IT WILL UNLOCK THE REAR HATCH AND PASSENGERS SIDE. THIS MODEL VAN HAS MASSIVE ELECTRICAL PROBLEMS I KEEP SMELLING BURNING WIRES BUT I HAVE TO DRIVE IT BECAUSE ITS OUR ONLY VEHICLE AND I HAVE 4 CHILDREN SO IM ALWAYS WORRIED ABOUT THERE SAFETY IN THIS VAN. WE HAVE OWNED IT SINCE NEW SO THERE HAS BEEN NOTHING CHANGED BYE ANYONE BESIDES THE DODGE DEALER. BTW TOOK IT TO DODGE THEY NEVER HAVE FIGURED IT OUT AND THE WARRANTY IS EXPIRED NOW SO I AM STUCK WITH IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10398443May 1, 2011
ELECTRICAL SYSTEM, STRUCTURE:BODY:DOOR
2006 DODGE GRAND CARAVAN - DOOR DOES NOT FULLY CLOSE OR OPEN WITH AUTOMATIC BUTTON - WIRE IN DOOR TRACK WAS SEVERED FROM MULTIPLE OPENINGS AND CLOSINGS - HAVE SEEN ON THE INTERNET THAT IT HAS HAPPENED TO A LOT OF OTHER VANS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10395306April 8, 2011
STEERING
FAILURE OF STEERING GEAR BOX LEAKING POWERSTEERING FLUID. VAN IS ONLY 5 YRS OLD. INTERNET SITES SHOW THIS IS A VERY COMMON PROBLEM WITH THESE VANS. ONE SITE STATES THE PARTS ARE ON BACK ORDER, 9000 PARTS NEEDED. TALKED TO THE DEALER AND WANT TO CHARGE TO FIX IT. THIS IS A PREMATURE FAILURE OF THE PART AND SHOULD BE COVERED OR RECALLED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10393551March 29, 2011
STEERING
I RECENTLY PURCHASED A 2006 DODGE CARAVAN SXT. ONE WEEK LATER THE RACK AND PINION NEEDS REPLACEMENT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10393000March 27, 2011
STEERING
I HAVE A 2006 DODGE GRAND CARAVAN STX 3.8L VAN. THE VAN HAS BEEN MAKING A LOUD WHINING NOISE OVER THE PAST SEVERAL MONTHS. THE NOISE IS PREVALENT WHEN COLD OR WARM AND WHEN TURNING. THOUGHT THIS MAY BE A POWER STEERING ISSUE. CHANGED POWER STEERING FLUID. NOISE STILL PERSISTS. TIGHTENED SERPENTINE BELT. NOISE STILL PERSISTS. TOOK IT TO A MECHANIC. MECHANIC SAID IT WAS A RACK AND PINION ISSUE. IS THERE A RECALL ON THIS. DOES ANYONE ELSE HAVE THIS ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10392042March 17, 2011
UNKNOWN OR OTHER
CAR WAS PARKED. I HAD OPENED DOOR MANUALLY. THOUGHT IT WASN'T FULLY OPENED; HIT POWER BUTTON ON DOOR JAMB TO OPEN FULLY. THEN LEANED AGAINST DOOR WITH LEFT HAND AND BENT OVER TO REMOVE ICE TRACKS FROM SHOES. DOOR CLOSED INSTEAD OF OPENING AND BEFORE I COULD REACT IT CLOSED AND LOCKED ON THUMB AND SEVERED IT COMPLETELY JUST IN FRONT OF KNUCKLE . SENSORS SUPPOSEDLY DESIGNED TO PREVENT DOOR CLOSING ON LIMBS DID NOT WORK. SENSORS ARE SUPPOSED TO PREVENT THIS INJURY, OR SO I THOUGHT. CAR HAS 3 BUTTONS TO ACTIVATE DOORS: OVERHEAD CONSOLE; REMOTE KEY & INSIDE DOOR JAMB. IF SENSOR DOES NOT WORK POWER DOOR COULD ACTIVATED FROM ANY ONE OF THESE LOCATIONS BY SOMEONE NOT FULLY AWARE OF ACTIVITY AROUND DOOR TO CAUSE SERIOUS INJURY.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10386923March 8, 2011
LATCHES/LOCKS/LINKAGES, STRUCTURE:BODY:DOOR
2006 DODGE CRAND CARAVAN REAR POWER SLIDING DOORS. INITIALLY WOULD NOT UNLOCK WITH ELECTRIC LOCKS. NOW DOORS OPEN/CLOSE PARTIALLY ABOUT 10 INCHES FROM THE CLOSED POSITION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10386136March 2, 2011
STEERING, ENGINE AND ENGINE COOLING
AFTER HAVING MY 06 DODGE GC SERVICED AT THE LOCAL DEALER FOR A CATALYTIC CONVERTER AT 72,000 MILES, I WAS INFORMED MY RACK AND PINION WAS BAD AND NEED TO BE REPLACED FOR $1100. JUST THE RESPONSE FOR THIS SITE ALONE LEADS ME TO BELIEVE THIS IS A BIGGER PROBLEM AND DODGE SHOULD FIX THE PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10384208February 23, 2011
STEERING
2006 GRAND CARAVAN RACK & PINION WENT BAD. THIS SEEMS TO BE A PROBLEM WITH ALL CHRYSLER VANS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10383049February 17, 2011
AIR BAGS:FRONTAL
ON FEBRUARY 8, 2011 WHILE DRIVING IN THE RAIN MY 2006 DODGE GRAND CARAVAN AIRBAG LIGHT CAME ON. ON FEBRUARY 14, 2011 I READ ONLINE ABOUT NHTSA CAMPAIGN ID# 10V008000 AND NHTSA ACTION # RQ09003 THAT STATED THIS PROBLEM WOULD BE COVERED BY CHRYSLER FREE OF COST. ON FEBRUARY 17,2011 I TOOK THE VEHICLE TO DODGE FOR THIS TO BE FIXED AND THEY STATED M VIN WAS NOT ONE OF THE VINS COVERED BY THE SAFETY CAMPAIGN SO I HAD TO PAY $225 TO HAVE THE FRONT AIRBAG CRASH SENSOR AND WIRING LEADING UP TO THE SENOR REPLACED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10381092February 8, 2011
AIR BAGS
I HAVE 2 2006 GRAND CARAVANS, BOTH WITH ABOUT 80K MILES. BOTH OF THE AIRBAG LIGHTS CAME ON AT ABOUT THE SAME TIME AND THEY STAY ON. CHECKING THE INTERNET, CHRYSLER HAS ISSUED RECALLS FOR OVER 300K 2005 AND 2006 VEHICLES. I CALLED CHRYSLER AND ONE OF THE CARS IS COVERED AND THE OTHER IS NOT. THE VIN IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10379882February 1, 2011
STEERING
RACK AND PINION NEEDS TO BE REPLACED ON MY VAN THAT HAS LESS THAN 60,000 MILES. IT IS LEAKING POWER STEERING FLUID. *LN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10379665January 31, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION
TL*THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE THE VEHICLE WAS STOPPED, THE VEHICLE WOULD NOT MOVE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE CONTACT PRESSED HARDER BUT THE VEHICLE DID NOT RESPOND. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP BUT THE FAILURE COULD NOT BE DIAGNOSED. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED HIM TO TAKE THE VEHICLE TO A LOCAL DEALER FOR A DIAGNOSTIC TEST. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE FAILURE OCCURRED THREE TIMES SINCE OCTOBER 2010. THE FAILURE MILEAGE WAS 68,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Dodge Grand Caravan