Dodge Grand Caravan Complaints (2003)

219 consumer complaints on file.

#10175833December 11, 2006
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN, ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
POWER CABLE FOR RADIATOR FAN WAS RUBBING AGAINST AC TUBING. CABLE WORE THROUGH CAUSING A SHORT CIRCUIT, FAILURE OF RADIATOR COOLING FAN RESULTING IN OVERHEATING OF ENGINE. WIRE CABLE BUNDLE WILL HAVE TO BE REPLACED AND REROUTED TO PREVENT FUTURE VIBRATION EROSION OF CABLE BUNDLE.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10175412December 6, 2006
ELECTRICAL SYSTEM
THE HEADLIGHTS FLICKER OFF ON MY 2003 DODGE GRAND CARAVAN WITH 68,000 MILES. THIS ORIGINALLY HAPPENED ON VACATION WITH MY FAMILY OF 5 IN THE CAR ON A HIGHWAY IN TENNESSEE. WHEN THE LIGHTS WENT OFF I REACHED FORWARD TO TOUCH THE SWITCH AND THEY CAME BACK ON. 3 WEEKS WENT BY WITHOUT ANOTHER INCIDENT. NOW ALMOST DAILY THE LIGHTS FLICKER OFF AND COME BACK ON WHEN I TOUCH THE SWITCH. THIS HAS NOT BEEN REPAIRED YET. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10174265November 26, 2006
ELECTRICAL SYSTEM:IGNITION, VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
MY PASSENGER AND DRIVER POWER WINDOWS STOP WORKING, SOMETIMES FOR LONG PERIODS OF TIME. IN ADDITION, THE IGNITION KEY WILL NOT TURN FROM IT'S LOCKED POSITION (STEERING WHEEL IS "NOT" LOCKED) *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10173088November 9, 2006
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
BALL JOINTS HAVE FAILED SEVERAL TIMES. SHOULD BE A RECALL AS THE FAILURE OF THE JOINTS PREVENTS A VEHICLE FROM PASSING INSPECTION AS IT IS AN IMPORTANT SAFETY ISSUE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10172924November 8, 2006
STRUCTURE:BODY:ROOF AND PILLARS
DT*: THE CONTACT STATED THERE WAS CRACKING ON THE ROOF WHERE THE FRONT DOORS MET THE ROOF AND BODY. THE FRONT DOORS WERE OFF ALIGNMENT AND IT LOOKED AS THOUGH THE ROOF WAS PULLING UP. THE DEALERSHIP DETERMINED THE SERVICE REPRESENTATIVE NEEDED TO INSPECT THE VEHICLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10172761November 6, 2006
VEHICLE SPEED CONTROL
DT*: THE CONTACT STATED WHILE DRIVING 30 MPH, THE ENGINE REVVED WITHOUT WARNING. THE RPMS ROSE TO 4500, AND DROPPED BACK DOWN TO 2000. THE VEHICLE WAS SHUT OFF AND RESTARTED, BUT THE PROBLEM RECURRED IMMEDIATELY. THE VEHICLE WAS NOT SEEN BY A DEALER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10171954October 27, 2006
EXTERIOR LIGHTING:HEADLIGHTS, SERVICE BRAKES, HYDRAULIC
BOUGHT VAN USED ABOUT A YR AGO - IS A 2003 DODGE GRAND CARAVAN- ISSUES SINCE PURCHASE NOT SATIFYINGLY DEALT WITH ARE ( BETWEEN END DEC 05 TO MID NOV 06- NOTICED BRAKES NOISES SINCE BOUGHT IT - SEVERAL CALLS AND A CHECK THEY SAID THERE WAS DUST MAKING THE NOISE - LESS THAN 9 MO LATER NEEDED TO REPLACE THE PADS AND ROTARS - THEY MADE EXCUSES THEY WEAR OUT - HAD THEY INFORMED ME THEY WERE WEARING OUT WHEN THEY FOUND DUST ID HAVE HAD THEM IN LONG BEFORE NEEDING ROTARS FIXED - SINCE NEW BRAKES AND ROTARS IN OCTOBER HEAR SAME NOISE AND THEY DISMISS IT. ALSO - HAVE TROUBLE WITH LIGHTS AND HEAT AND ELECTRICAL COMPONENTS DIMMING AND SEEMING TO DIE OUT WHEN DECELERATING A LOT SINCE I BOUGHT IT - HAD IT IN AD CALLED SEVERAL TIMES - THEY SAY THEY CANT SEE ANYTHING WRONG ADN THAT DODGE WAS MADE TO DO THAT ? . NOT HAPPY WITH MY PURCHASE AND FEEL I AM OUT NEAR 20,000 - ALSO ABS LIGHT CAME ON SHORTLY AFTER BRAKES REPAIRED THIS MONTH- COVERED ITEM BUT LESS THAN DEDUCTIBLE SO STUCK WITH NEAR 85 DOLLAR BILL - THEY SAID AGAIN THIS JUST HAPPENS - SEEMS THAT IS STANDARD ANSWER TO TROUBLE IT JUST HAPPENS - I DONT FEEL THE BRAKES JUST HAPPENED AND I AM SURE THE LIGHT TROUBLE COULD BE A HAZARD IF IT STALLED COMPLETELY ON A BUSY ROAD. DODGE SHOULD LOOK CLOSER AT THIER VEHICLES. AM ALSO GONNA CHECK OUT VEHICLE FOR THE OTHER TROUBLE STATED HERE IN REGARDS TO SEATBELTS AND CRACKS - HAVE CHILDREN AND THAT IS MAJOR SAFETY ISSUE - IF IT HAPPENS AND ANYONE IS HURT YOU CAN BET ILL BE RUNNING TO A LAWYER - SAME WITH THE DOWN IDLE WITH BRRAKEING AND ABS GOING OUT - JUST PRAYING FOR NO INJURIES - NOTE THAT PRINTOUT I RECIEVED TODAY HAS OLD OWNERS STUFF ON IT AND NOTICED THAT THE NOISE FROM TIRES AND FRONT IS NOT A NEW PROBLEM THAY HAD IT IN SEVERAL TIMES ALSO FOR IT. OH - AND GUESS WHAT THEY CHARGE FOR A 2 INCH TRAILER HITCH BALL - 89.00!!! HAD I KNOWN THAT ID HAVE GONE TO WALMART AND PAID WAYYYY LESS. ALL FOR THE CASHOLA AN NOT THE GOOD OF TH CUSTOMER I SUPPOSE HUH? *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10171553October 22, 2006
STEERING:HYDRAULIC POWER ASSIST SYSTEM
POWER STEERING WAS MAKING A WHINING NOISE ABOUT A YEAR AFTER WE GOT IT, I TOOK IT INTO THE DEALER AND THEY COULD NOT FIND A PROBLEM. AFTER 4 VISITS BACK TO THE DEALER THEY REPLACED THE POWER STEERING RACK 6 MONTHS LATER THE NOISE IS BACK. I KNOW OF 3 OTHER PEOPLE THAT HAVE THE SAME MINI VAN AND THEY ALL HAVE EXPERIENCED THE SAME PROBLEM. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10171047October 17, 2006
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS, SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
DT*: THE CONTACT STATED WHILE TRAVELING 5 MPH, THE BRAKE ROTORS FAILED AND THE PADS WERE COMPLETELY WORN OUT. THE SERVICE DEALER REPLACED BOTH SETS OF PADS AND ROTORS ON THE FRONT WHEELS. UPDTATED 11/03/06. 8JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10170766October 13, 2006
STEERING:LINKAGES:TIE ROD ASSEMBLY
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THERE WAS POPPING NOISE AND A PRONOUNCED VIBRATION WITHIN THE FRONT SUSPENSION. THE VEHICLE WAS INSPECTED BY A DEALER WHO DETERMINED THE STABILIZER BAR BUSHINGS WERE WORN AND NEEDED TO BE REPLACED. ALTHOUGH THE BUSHINGS WERE NOT REPLACED, WHILE APPLYING PRESSURE TO THE BRAKES AT ANY SPEED, THE POPPING NOISE PROGRESSIVELY GOT WORSE. THE CONTACT INSPECTED THE VEHICLE AND DETERMINED IT WAS BOTH TIE ROD END BALL JOINTS THAT WERE WORN AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT ALERTED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10170646October 12, 2006
ELECTRICAL SYSTEM:WIRING
ALL POWER ACCESSORIES INCLUDING PW, PL, LIGHTER, RADIO, AND ALL EXTERIOR LIGHTS, SHUT-OFF AND USUALLY AFTER A MINUTE TURN BACK ON AND THE VEHICLE JERKS INTO GEAR AT LOW SPEEDS AND SLAMS INTO GEAR AT HIGH SPEEDS, TAKING THE SPEED OF THE VEHICLE FROM 100K TO 60K IN A MILLISECOND. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10169981October 5, 2006
STEERING
I HAVE A 2003 DODGE GRAND CARAVAN THAT WAS PURCHASED IN DECEMBER OF 2004. I NOTICED THAT THE POWER STEERING WAS MAKING A HUMMING NOISE. TURNING, AND IDLING. I ALSO NOTICED THAT IT WAS SPORADIC AND WOULD GO ON FOR DAYS AND THEN ONE DAY WOULD NOT MAKE A SOUND. I HAVE TAKEN IT TO THE DEALER AND THEY TOLD ME THE POWER STEERING FLUID WAS LOW. I CHECKED IT MANY TIMES AND IT WAS FINE. THEY TOLD ME THAT THE POWER STEERING NEEDED TO BE FLUSHED AND THERE SHOULD BE NO REASON FOR POWER STEERING TO BE FLUSHED. I AM SERIOUSLY CONCERNED THAT SOMETHING TERRIBLE IS GOING TO HAPPEN WITH THIS ISSUE. I HAVE AN EXTENDED WARRANTY AND THE DEALER SAID THAT IT IS NOT ANYTHING THAT NEEDS TO BE REPLACED. I DON'T FEEL GOOD ABOUT THIS AT ALL!!! WE ARE ABOUT AT 54,000 MILES AND THIS STARTED HAPPENING ABOUT 8 MONTHS AGO OR SO. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10165407August 14, 2006
ELECTRICAL SYSTEM, POWER TRAIN:AUTOMATIC TRANSMISSION
DT*: THE CONTACT STATED THE VEHICLE STALLED FOUR TIMES WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO WAS UNABLE TO DUPLICATE THE PROBLEM. FINALLY THE DEALERSHIP DETERMINED THE BLACK BOX NEEDED TO BE REPLACED. WHILE DRIVING THE VEHICLE 25 MPH, THERE WAS A VERY LOUD NOISE. THE VEHICLE WOULD NOT GO INTO GEAR. THE VEHICLE BEGAN TO ROLL WHEN PLACED IN PARK. THE EMERGENCY BRAKE WAS ENGAGED TO STOP THE VEHICLE WHICH WAS LATER TOWED TO A DEALERSHIP FOR INSPECTION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10165146August 10, 2006
ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM, POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
OWN A 2003 DODGE GRAND CARAVAN SPORT . CAR WAS TOWED TO DODGE DEALER ON FRIDAY JULY 20,2006 , DUE TO ROUGH ENGINE IDLING. WAS TOLD THAT IT WAS A PCM , WOULD TAKE UNTIL THE FOLLOWING WEDNESDAY TO HAVE TO PART SHIPPED IN ( I LIVE IN THE CHICAGO AREA ). ON THURSDAY DODGE CALLED TO SAY THAT THE ROCKER ARM IN THE # 5 PISTON NEEDED TO BE REPLACED, THIS WOULD TAKE ADDITIONAL TIME. THE ROCKER ARM WAS REPLACED AND AGAIN DODGE CALLED TO ADVISE ME THAT NOW THERE WAS A SHORT IN THE ELECTRICAL HARNESS AND THEY WOULD NEED TO TRACE TO LOCATE THE SHORT. CAR WAS FINALLY RETURNED TO ME ON AUGUST 9,2006 . MY WIFE USED IT TO GO TO THE STORE , SHE CALLED ME AND SAID THE CAR HAD DIED WHILE STOPPING AT A RED LIGHT .THIS WAS JUST 4 HOURS AFTER PICKING THE CAR UP FROM THE DEALER. CAR WAS AGAIN TOWED TO DODGE DEALER. TOTAL TIME DODGE HAS HAD MY CAR IS NOW 21 DAYS AND COUNTING . I'VE HAD TO RENT 3 DIFFERENT CARS DURING THIS TIME ALL ON MY OWN EXPENSE . *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10164378August 3, 2006
WHEELS
DT*: THE CONTACT STATED THE TIRES LEAKED AIR AND NEEDED TO BE FILLED EVERY DAY. THE DEALERSHIP REPLACED THE VALVE STEM, BUT THE PROBLEM PERSISTED. THE ALLOY WHEELS WERE PITTING WHICH CAUSED THE AIR TO LEAK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10163975July 31, 2006
CHILD SEAT, CHILD SEAT:BASE
DT*: THE CONTACT STATED WHILE MAKING A TURN TRAVELING 25 MPH, THE CHILD SAFETY SEAT UNLATCHED FROM THE BASE AND FLIPPED OVER. NOW THE SEAT MUST BE PUSHED IN MULTIPLE TIMES TO ENSURE IT IS LATCHED TO THE BASE. THIS IS A COSCO 22-630 MRC MANUFACTURED JULY 26, 2005.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10163513July 26, 2006
EXTERIOR LIGHTING:HEADLIGHTS
DT*: THE CONTACT STATED THAT THE HEADLIGHTS ON THE VEHICLE ONLY WORKED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10162707July 17, 2006
ENGINE AND ENGINE COOLING:COOLING SYSTEM, STEERING:LINKAGES:TIE ROD ASSEMBLY, STRUCTURE:BODY:TRUNK LID, SUSPENSION:FRONT:WHEEL BEARING, POWER TRAIN:AUTOMATIC TRANSMISSION, EQUIPMENT:APPLIANCE:AIR CONDITIONER, ELECTRICAL SYSTEM:STARTER ASSEMBLY
MY 2003 NEW DODGE CARAVAN HAD THE TRANSMISSION REPLACED X3, AIR CONDITIONER REPLACED X1 THEN REPAIRED AGAIN X 2, REPLACED STARTER, WHEEL BEARING, TIE ROD & CONTINUES TO HAVE PROBLEMS. THESE MAJOR PROBLEMS STARTED WHEN THE CAR HAD ONLY 30, 000 MILES AND IS ONLY AT 60, 000 MILES. THE DEALER NOR CHRYSLER CORPORATION WILL REPLACE OR REFUND THIS CAR STATED IT DOES NOT FALL UNDER LEMON LAW. MULTIPLE TIME LOST FROM TAKING IN THIS CAR TO BE FIXED ALONG WITH EXTRA MONEY SPENT TO GET RENTALS WHILE THIS CAR WAS IN THE SHOP. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10161786July 7, 2006
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
DT*: THE CONTACT STATED THAT THE FRONT PASSENGER WINDOW WOULD NOT ROLL DOWN. THE VEHICLE WAS PARKED WHEN THE INCIDENT OCCURRED. THE DEALER WAS CALLED ON 07/07/06 AND AGREED TO REPAIR THE WINDOW FOR A CHARGE. THE MANUFACTURER WAS ALSO CALLED ON 07/07/06 WHO OFFERED NO RESOLUTION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10160804June 26, 2006
SEAT BELTS:FRONT
DT*: THE CONTACT STATED THAT BOTH THE FRONT DRIVER AND PASSENGER SIDE SEATBEALTS BECAME UNBUCKLED IN A CRASH. THE VEHICLE EXPERIENCED BOTH A FRONTAL AND REAR IMPACT; THE CRASH INVOLVED 3 OTHER VEHICLES. THE VEHICLE WAS 2ND IN THE ROW OF VEHICLES INVOLVED IN THE COLLISION. THE VEHICLE WAS TRAVELLING 70 MPH AT THE TIME OF THE ACCIDENT. THE INCIDENT WAS THE FIRST TIME THE CONSUMER ENCOUNTERED THE SEATBELT BECOMING UNBUCKLED WITHOUT DEPRESSSING THE RELEASE BUTTON. THE BUCKLE WAS FREE OF DIRT AND OTHER CONTAMINANTS. THE CONTACT'S FEET WENT THROUGH THE FRONT PASSENGER SIDE OF THE WINDSHIELD. THE PASSENGER SUSTAINED A BROKEN LEFT TOE, CRUSHED LEFT FOOT, CUTS ON THE RIGHT FOOT AND LEG. THE DRIVER SUSTAINED AIRBAG BURNS ON BOTH ARMS AND CHEST, AS WELL AS A KNOT ON THE HEAD. THE VEHICLE WAS TOTALLED, AND PICTURES WERE TAKEN. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS CONTACTED WHO DIRECTED THE CONTACT TO THE CONTACT'S INSURANCE COMPANY.
Crash:
Yes
Fire:
No
Injuries:
4
Deaths:
0

← Back to Dodge Grand Caravan