Dodge Grand Caravan Complaints (2007)

182 consumer complaints on file.

#10607913July 2, 2014
FUEL SYSTEM, GASOLINE
THIS IS A DEFECT PETITION FILED PURSUANT TO 49 U.S.C. 30162. OUR 2007 GRAND CARAVAN SXT HAS ABOUT 44,000 MILES ON IT AND IT HAS BEGUN STALLING AFTER REFUELING. THIS ONLY HAPPENS WHEN THE FUEL TANK IS REFUELED TO FULL CAPACITY. THE PROBLEM STARTED ABOUT A MONTH AGO. TODAY, MY WIFE (WITH KIDS IN CAR) STALLED ON THE HIGHWAY. THE DANGER WAS THAT SHE WAS ON A TURN AND THE STEERING WHEEL BECAME IMPOSSIBLE FOR HER TO TURN IT. THIS IS A MAJOR SAFETY ISSUE, AND MY HOPE IS THAT CHRYSLER MAKES GOOD ON A DEFECTIVE PART. (I SEE THEY DID THAT AFTER A GOV'T INVESTIGATION OF A SIMILAR NATURE FOR OTHER CARS...AFTER AN INVESTIGATION BY NHTSA!) ***THIS IS A WIDESPREAD ISSUE FOR VEHICLES FROM 2004 TO 2013. SEE THREAD BELOW FOR REFERENCE; HTTP://EN.ALLEXPERTS.COM/Q/CHRYSLER-REPAIR-807/F/STALLING-REFUELING.HTM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10607466July 1, 2014
ENGINE, STEERING, ELECTRICAL SYSTEM
ON THREE SEPARATE OCCASIONS WHEN DRIVING THE CAR, THE IGNITION KEY SUDDENLY SHUT OFF THE ENGINE CAUSING DIFFICULTY WITH STEERING AS WELL. THIS WAS CHECKED BY THE DEALERSHIP WHO COULD FIND NO REASON FOR THE ACTION. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10585663April 30, 2014
ELECTRICAL SYSTEM
TL-THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 15 MPH, THE ENGINE STALLED WITHOUT ANY WARNING. THE ENGINE RESTARTED AND RESUMED NORMALLY. THE FAILURE RECURRED TWO MOMENTS LATER. THE MALFUNCTION ONLY OCCURRED AFTER REFUELING. THE VEHICLE WAS CURRENTLY BEING REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILAGE WAS 81,000. JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10576073March 31, 2014
STEERING
I HAVE A 2007 DODGE GRAND CARAVAN. WHILE NOT A GM VEHICLE, I HAVE EXPERIENCE THE SAME ISSUE WITH THE IGNITION AS HAS BEEN REPORTED ON THE GM VEHICLES. I HAVE HAD SEVEN INCIDENTS. THE ISSUES INVOLVES VEHICLE LOSING ALL POWER. ALL GAUGES WILL DROP TO ZERO AND STEERING WILL BE LOST. I HAVE HAD TO SWITCH THE VEHICLE OVER TO NEUTRAL AND PULL OVER TO THE SIDE OF THE ROAD. UPON SHUTTING OFF THE VEHICLE AND RESTARTING, THE VEHICLE STARTS FINE. AFTER HEARING ABOUT THE GM RECALL, I TOOK ALL EXCESS KEYS OFF OF MY KEY CHAIN. I HAVE NOT ENCOUNTERED THE PROBLEM SINCE. HOWEVER, THIS IS VERY CONCERNING TO ME. AT ONE TIME, I WAS TURNING AROUND A CIRCULAR MONUMENT AND ALMOST COULD NOT MAKE IT TO THE SIDE OF THE ROAD IN NEUTRAL. I FEAR THAT THIS IGNITION ISSUE IS AFFECTING MORE VEHICLES THAN JUST GMS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10568585March 11, 2014
INTERIOR LIGHTING, EXTERIOR LIGHTING
JUST BOUGHT A 2007 DODGE GRAND CARAVAN AND REALIZED THE FRONT READING LIGHTS WERE NOT WORKING. I TOOK OF THE PLASTIC COVERS IN AN ATTEMPT TO CHANGE THEM AND OBSERVED THAT THE BULB HAD COMPLETELY MELTED THE PLASTIC AND BURNT PART OF THE CASING. IT APPEARS AS THOUGH THE PLASTIC HOUSING WAS VERY CLOSE TO, OR HAD ALREADY, CAUGHT ON FIRE. I AM WORRIED THAT IF WE PUT A NEW LIGHT BULB IN THE SAME HOUSING IT WILL LIKELY CATCH THE WHOLE VAN ON FIRE. THE SAFETY OF MY FAMILY BEING PARAMOUNT, I DO NOT FEEL SAFE DOING SO. AFTER REVIEWING THIS PROBLEM ONLINE, I FOUND NUMEROUS OTHER GRAND CARAVAN OWNERS CLAIMING TO HAVE HAD THE SAME PROBLEM. THIS ISSUE NEEDS TO BE FIXED BEFORE SOMEONE GETS HURT, OR EVEN WORSE, KILLED. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10566124February 26, 2014
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS, WHEELS
THE TPMS FAILED. THE VALVE STEM CRACKED OFF WHEN ADDING AIR. AIR WAS BEING ADDED BECAUSE THE VALVE STEM WAS LEAKING, AND THE TIRE WAS NEAR FLAT, AND I WANTED TO TAKE IT TO A REPAIR SHOP. THIS IS THE SECOND TPMS VALVE FAILURE I HAVE HAD. FORTUNATELY, BOTH OCCURRED AT A STANDSTILL. I SEE TALES ON THE INTERNET OF FAILURE AT HIGH SPEED, FOLLOWED BY VARY RAPID DECOMPRESSION AND TIRE FAILURE. EXPENSIVE, IF NOT UNSAFE. IN MY OWN CASE, WITH OVER 50 YEARS DRIVING EXPERIENCE AND 2 YEARS AS A MECHANIC, I HAVE NEVER SEEN A VALVE STEM FAILURE BEFORE. NOW, I HAVE TWO. EXPERT MECHANICS ARE ADVISING TO REPLACE THEM WITH STANDARD VALVES, AND I WILL. FROM AN ECONOMIC VIEW, THE SEVERAL FAILURES OF THE STEMS, AND STEM FAILURES, HAVE COST ME ABOUT 6 CENTS PER MILE. GAS HAS COST ME ABOUT 18 CENTS PER MILE (AT TODAYS COST). THUS, THE TPMS SYSTEM MAINTENANCE IS ABOUT 1/3 OF THE GAS COST. I DOUBT VERY SERIOUSLY THAT THE TPMS SYSTEM SAVES THAT MUCH IN GASOLINE USE. BUT FROM A SAFETY PERSPECTIVE, I AM NOT WILLING TO RISK SUDDEN DEPRESSURIZATION FOLLOWED BY TIRE DESTRUCTION AT HIGHWAY SPEEDS. THUS, I WILL BE PULLING THOSE OUT BEFORE MY NEXT HIGHWAY TRIP. AFTER TALKING WITH SEVERAL MECHANICS, LOOKING AT THE DESIGNS, AND LOOKING AT EXPERIENCES OF OTHERS, I CONCLUDE THAT TPMS IS A GOOD IDEA WITH A BAD EXECUTION. IF THEY ARE NOT (NEARLY AS SECURE) AS OLDER VALVE STEMS, THEY SHOULD BE DE-MANDATED. FINALLY, I NOTE THAT AT LEAST SOME OF THESE HAVE MERCURY IN THE PACKAGE AS A ROTARY SWITCH. AS MUCH AS WE ARE SPENDING TO REMOVE MERCURY FROM THE ENVIRONMENT . . . *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10562878February 4, 2014
ENGINE, FUEL SYSTEM, GASOLINE
VEHICLE STALLS IMMEDIATELY AFTER FILLING GAS TANK COMPLETELY. I LET PUMP TURN OFF AUTOMATICALLY AND DO NOT OVERFILL. HAS HAPPENED REPEATEDLY IN TRAFFIC AND IS DANGEROUS. AFTER A FEW MILES, NO MORE STALLING OR SPUTTERING. LOTS OF REPORTS OF THIS PROBLEM WITH DODGE/CHRYSLER VEHICLES ONLINE BUT COMPANY CLAIMS NO KNOWLEDGE OF PROBLEM. FIX IS TO REPLACE FUEL TANK AND ATTACHED PARTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10556902December 21, 2013
FUEL/PROPULSION SYSTEM, ENGINE, POWER TRAIN
I JUST COMPLETED FILLING UP MY VEHICLE WITH REGULAR GASOLINE. ABOUT 100 YARDS FROM THE FILLING STATION, MY VAN STUTTERED AND STALLED. IT DOES THIS EVERY TIME I FILL IT UP. IT STALLED IN THE MIDDLE OF AN INTERSECTION. I DID SOME RESEARCH AND IT LOOKS LIKE IT IS THE RESULT OF A FAILED COMPONENT OF THE EMISSIONS SYSTEM AND A PRETTY COMMON PROBLEM WITH CHRYSLER/DODGE VANS. HTTP://COMMUNITY.CARTALK.COM/DISCUSSION/2137227/ENGINE-DIES-AFTER-GASOLINE-FILL-UP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10552983November 19, 2013
SERVICE BRAKES
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE PARKING BRAKE CABLE BECAME FRACTURED WHEN ENGAGED, CAUSING THE VEHICLE TO SLIGHTLY ROLL AWAY IN REVERSE. THE CONTACT SHIFTED INTO PARK TO STOP THE VEHICLE. THE CONTACT CALLED THE DEALER BUT NO REPAIRS WERE PERFORMED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 94,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10548540October 19, 2013
FUEL SYSTEM, GASOLINE
EVERYTIME I FUEL MY DGC, AFTER I START UP, THE ENGINE WILL SPUTTER AND STALL OUT, EVEN OUT IN TRAFFIC. I HAVE PUT IT IN PARK, RESTART (IT RESTARTS ROUGH), AND THEN REV THE ENGINE A FEW TIMES TO WORK OUT SPUTTERS AND ROUGHNESS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10499246February 19, 2013
LATCHES/LOCKS/LINKAGES, ELECTRICAL SYSTEM
THE POWER LOCKS HAVE QUIT WORKING ON THE REAR SLIDING DOORS WHERE MY CHILDREN SIT. NO WAY TO UNLOCK DOORS FROM OUTSIDE TO REMOVE CHILDREN IN CASE OF ACCIDENT. THE DOORS WILL NOT OPEN FROM THE INSIDE UNLESS MANUALLY PULLED UP. THIS IS A VERY VERY COMMON PROBLEM WITH DODGE. ONLY ONE MANUAL KEY HOLE TO UNLOCK VAN ON DRIVERS DOOR. THIS IS VERY DANGEROUS FOR PASSENGERS ESPECIALLY CHILDREN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10494909January 28, 2013
EXTERIOR LIGHTING
TL* THE CONTACT OWNS 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE INTERIOR LIGHTS ON THE FRONT DOME WIRING SYSTEM BURNT OUT. THE INSTRUMENT PANEL WIRING SYSTEM WAS PARTIALLY BURNT OUT CAUSING THE LIGHT TO ILLUMINATE ON AND OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 98,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10494809January 26, 2013
WHEELS, TIRES:TEMPORARY/EMERGENCY SPARE TIRE
SPARE TIRE WINCH CARRIER FAILED CAUSING SPARE TIRE TO COME LOOSE. SPARE TIRE STRUCK THE LEFT REAR WHEEL AND CAUSED A BLOW OUT. INSPECTION OF THE WINCH REVEALED A FRAYED STEEL CABLE WITH THE ENTIRE "DOG BONE", CARRIER ASSEMBLY, AND SPARE TIRE MISSING. SPARE TIRE AND CARRIER ASSEMBLY WAS NOT ABLE TO BE RECOVERED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10488975December 17, 2012
LATCHES/LOCKS/LINKAGES
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE REAR LIFT GATE DOOR COULD NOT BE OPENED WITH THE KEYLESS ENTRY FOB, MANUAL KEY OR BY USING THE LATCH MANUALLY. THE CONTACT HAD THE LATCH ASSEMBLY REPLACED HOWEVER, THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 70,000. UPDATED 01/30/13*LJ UPDATED 1/31/2013 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10487242December 3, 2012
STRUCTURE, SEATS
WE WERE STOPPED BEHIND AN AMBULANCE IN TRAFFIC WHEN A LARGE PICK-UP TRUCK BARRELED INTO US. DRIVER WAS INTOXICATED. MY 5-YEAR OLD DAUGHTER WAS STRAPPED INTO THE BUILT-IN BOOSTER SEAT IN THE MIDDLE BENCH. ON IMPACT, THE WHOLE BENCH CAME OUT OF THE FLOOR AND FLIPPED HER FORWARD AND THEN BACKWARDS. SHE SUSTAINED A BLACK EYE. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10485839November 23, 2012
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
HEAD LIGHTS STOPPED WORKING. NOT SIMPLE BULB REPLACEMENT, MAJOR ELECTRICAL PROBLEM IN POWER DISTRIBUTION SYSTEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10485425November 21, 2012
STRUCTURE:BODY:DOOR, STRUCTURE:BODY
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE ENTERING THE VEHICLE, A CHILD BECAME CAUGHT IN THE PATH OF THE CLOSING AUTOMATIC SLIDING DOOR. THE CHILD BECAME PINNED TO THE FRAME AND SUSTAINED MINOR BRUISING AS A RESULT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD WAS DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE ISSUE. THE FAILURE MILEAGE WAS UNAVAILABLE. THE CURRENT MILEAGE WAS 93,572. UPDATED 1/2/13 *CN UPDATED 01/09/13
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10483910November 10, 2012
VISIBILITY:GLASS, SIDE/REAR, VISIBILITY/WIPER
REAR WINDOW SHATTERED WHILE PARKED OVERNIGHT IN A LOCKED GARAGE. NO IMPACT, TEMPERATURE ABOVE FREEZING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10475683September 17, 2012
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE TRAVELING 50 MPH, THE ACCELERATOR PEDAL SEIZED CAUSING THE VEHICLE TO ACCELERATE ERRONEOUSLY. THE CONTACT WAS ABLE TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD WHERE IT STARTED TO SHAKE AND STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 68,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10472399August 24, 2012
WHEELS
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT AFTER TAKING THE VEHICLE FOR AN OIL CHANGE, THE TIRE VALVE STEM IN THE TREAD HOUSING FRACTURED. AS A RESULT, THE FRONT DRIVER SIDE TIRE DEFLATED AND THE TIRE PRESSURE SENSOR INDICATOR WARNING LIGHT ILLUMINATED. THE REPAIR SHOP REPLACED THE TIRE PRESSURE INDICATOR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 76,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Dodge Grand Caravan