Dodge Grand Caravan Complaints (2007)

182 consumer complaints on file.

#10679934January 30, 2015
FUEL/PROPULSION SYSTEM
TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT AFTER REFUELING AND DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FUEL FILTER WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10677120January 21, 2015
FUEL/PROPULSION SYSTEM
VEHICLE HESITATED FIRST TIME WHILE GOING 50 MPH AFTER REFUELING - REGULAR GAS. CHECKED THE TACH, WENT TO ALMOST ZERO, THEN BACK UP AGAIN. RODE ROUGH FOR A WHILE. STALLED FIRST TIME AFTER REFUELING W/ REGULAR GAS, @ 35 MPH, ALMOST CAUSING ME TO HIT A CURB - LOSS OF POWER STEERING AND BRAKES. RESTARTED OKAY. STALLED A 2ND TIME AFTER REFUELING AT RED LIGHT, JUST 500 FT FROM GAS STATION. TOOK 2 TIMES TO START IT. WHEN WE FIGURED IT WAS NOT A BAD TANK OF GAS, WE HAD OUR LOCAL MECHANIC CHECK IT, AND WE PAID OVER $200.00 FOR A CRANKSHAFT POSITION SENSOR TO BE REPLACED. BUT WE REFUELED THE VAN SOON AFTER, AND IT STALLED OUT AGAIN. THAT WAS WHEN I DECIDED TO LOOK ONLINE TO SEE IF ANYONE ELSE HAS ENCOUNTERED THE SAME PROBLEM. I WAS AMAZED AT HOW MANY PEOPLE HAD COMPLAINED, AND WERE TOLD IT?S NOT A KNOWN ISSUE. IT SOUNDS TO ME LIKE DODGE/CHRYSLER DOESN'T WANT TO ACCEPT RESPONSIBILITY FOR THE PROBLEM. I CHECKED ONLINE AND FOUND 40 COMPLAINTS FOR THE SAME ISSUE HERE: HTTP://EN.ALLEXPERTS.COM/Q/CHRYSLER-REPAIR-807/F/STALLING-REFUELING.HTM [DODGE CARAVAN AND/OR CHRYSLER TOWN & COUNTRY STALLING AFTER REFUELING]. THEY ALL CALLED DODGE/CHRYSLER AND WERE TOLD THAT IT WASN'T A KNOWN ISSUE. PLEASE FOLLOW THROUGH ON THIS, AND HAVE DODGE/CHRYSLER RECTIFY IT BEFORE SOMEONE IS KILLED. HERE IS A PAGE NOT BY DODGE THAT GIVES THE SOLUTION: HTTP://RICKSFREEAUTOREPAIRADVICE.COM/ENGINE-STALLS-AFTER-FILLING-TANK-CHRYSLER-MINIVAN/ THE REMEDY IS TO PAY OVER $700 FOR AN ENTIRE TANK, BECAUSE CHRYSLER DOESN'T SELL THE PART ALONE, WHICH IS THE VAPOR/LIQUID SEPARATOR VALVE. PLEASE HELP! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10668756December 29, 2014
ENGINE, FUEL SYSTEM, GASOLINE
WHEN IT FIRST BEGAN THE VAN WOULD STALL AND SKIP UPON ACCELERATION BETWEEN 20-50 MPH. NOW THE VAN STALLS AND/OR SKIPS AT ANY POINT OF ACCELERATION. THE ENGINE LIGHT COMES ON RIGHT AFTER THERE IS FUEL ADDED TO THE TANK AND THIS IS WHEN THE STALLING IS THE WORSE. THE ENGINE LIGHT ALSO COMES ON WHEN THERE IS1/4 TANK OF GAS LEFT AND THE DISTANCE TO EMPTY NUMBER JUMPS AROUND WHEN THERE IS LESS THAN 1/4 OF A TANK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10668258December 26, 2014
ELECTRICAL SYSTEM, SEATS, STRUCTURE:BODY
2007 DODGE GRAND CARAVAN SXT STOW N GO HAVING SEVERAL ELECTRICAL ISSUES. 1. PASSENGER POWER SLIDING DOOR FAILED, REPLACED POWER DOOR MOTOR, LOCK ACTUATOR, AND REPAIRED WIRING AS THE WIRES ACTUALLY BREAK/SNAP OVERTIME. POOR DESIGN. 2. LESS THAN TWO YEARS LATER PASSENGER POWER SLIDING DOOR HAS FAILED AGAIN, & POWER LOCKS WILL NOT WORK, & I CAN OPEN PASSENGER SLIDING DOOR AFTER LOCKING VEHICLE WITH KEY FOB AND ALARM WON'T SOUND! CANNOT GET MY CHILDREN IN AND OUT OF THIS DOOR WITHOUT REACHING IN AND PULLING UP THE LEVER FROM INSIDE (TOO STIFF, MY DAUGHTER ISN'T STRONG ENOUGH). THIS IS A SAFETY ISSUE AND RESEARCHING IT ONLINE SHOWS THAT IT IS WIDESPREAD. 3. POWER SEAT MOTOR HAS FAILED. WE HAVE STOW N GO SEATING. IN ORDER TO STOW THE 2ND ROW SEAT YOU MUST MOVE FRONT SEAT TO FULL FORWARD POSITION, THEN MOVE DRIVER SEAT BACK......DRIVER SEAT IS ALL THE WAY BACK NOW (FOR MY SPOUSE) AND I CANNOT MOVE IT FORWARD. GEARS ARE BROKEN. I CANNOT REACH THE PEDALS AND MY SEVENTH SEAT IS STOWED! I CANNOT GET MY SEAT BACK. 4. ON PASSENGER SIDE A PART BELOW DASHBOARD (I THINK IS RELATED TO HEATING AND COOLING) FELL OFF. MY FLOOR IS NOW WET EVEN AFTER REATTACHING IT. 5. LIGHT GALORE! MY VEHICLE ROTATES BETWEEN CHECK ENGINE, AND SERVICE TIRE SYSTEM WARNINGS. I'VE HAD IT CHECKED BY SEVERAL MECHANICS AND ALL SAY IT'S ELECTRICAL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10667349December 19, 2014
SERVICE BRAKES
I WAS DRIVING MY VEHICLE AND MY ANTI-LOCK BRAKES SYSTEM RESPONDED TO THE ICE ON THE ROAD AND I PROCEEDED TO PUMP MY BRAKE PEDAL TO SLOW THE VEHICLE DOWN AND THEN I NOTICED THAT THE BRAKE PEDAL WOULD GO ALL THE WAY TO THE FLOOR TO STOP THE VEHICLE SO I GOT HOME AND CHECKED THE BRAKE LINES FOR LEAKS AND DIDN'T FIND ANY AND THAT MY BRAKE RESERVOIR WAS FULL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10663395December 10, 2014
ELECTRICAL SYSTEM, LATCHES/LOCKS/LINKAGES
TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHEN THE FRONT DRIVER SIDE DOOR WAS LOCKED WITH EITHER THE KEY FOB OR MANUALLY, AN ABNORMAL NOISE EMITTED FROM THE DOOR PANEL. WHEN UNLOCKING THE DOOR FROM THE OUTSIDE, THE DOOR FAILED TO UNLOCK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 10,000. UPDATED 02/02/15*LJ UPDATED 6/8/2015 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10662645December 7, 2014
ENGINE, FUEL/PROPULSION SYSTEM
AFTER GETTING GAS, WHEN I SLOW TO COME TO A STOP THE CAR STALLS OUT. IT WILL USUALLY START RIGHT BACK UP AND I DON'T HAVE A PROBLEM UNTIL I GET GAS AGAIN. THIS IS A CONCERN AS I AM USUALLY DRIVING MY CHILDREN AROUND AND IT HAPPENED AFTER I PULLED OUT ONTO A BUSY 4 LANE ROAD AND HAD TO SLOW DUE TO AN UPCOMING LIGHT. WE WERE ALMOST HIT BECAUSE THE CARS COMING UP SAW THAT THE LIGHT WAS NOW GREEN. I PUT ON MY BLINKERS AS FAST AS I COULD BUT THAT DID NOT SAVE US FROM NEARLY BEING HIT AS WE WERE SITTING DUCKS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10661990December 3, 2014
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
THE INTERIOR IN THE FRONT OF THE VEHICLE WENT OUT. WHEN I TOOK IT OUT TO REPLACE IT, AND IT WAS MELTED ON ONE SIDE. THAT HAPPENED TO ME WITH THE OTHER SIDE OF THE FRONT INTERIOR LIGHTS, AROUND 2011 AND WHEN I WENT TO THE DEALERSHIP I WAS TOLD I WOULD HAVE TO BUY THE WHOLE ASSEMBLY AT A COST OF ABOUT $150.00 I THINK. I ASKED THEN IF THERE HAD BEEN A RECALL ON THIS AND WAS TOLD NO. I ASKED WHAT WOULD CAUSE THE LIGHT TO MELT AND HE SAID HE DID NOT KNOW. I LEFT IT AS I STILL HAD THE ONE ON THE DRIVERS SIDE BUT NOW I DO NOT HAVE EITHER AND THERE ISN'T ANY LIGHT IN THE FRONT OF THE CAR WHEN OPENING THE DRIVERS OR FRONT PASSENGER DOOR. PLEASE ADVISE ME IF THIS HAS BEEN A PROBLEM AND OR WHAT CAN I DO ABOUT IT. *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10653783November 10, 2014
FUEL/PROPULSION SYSTEM
SEVERAL TIMES FOLLOWING A FILL UP, THE VAN HAS STALLED OUT, USUALLY JUST A FEW HUNDRED FEET FROM THE PUMPS. UNFORTUNATELY, THIS USUALLY AS WE ARE PULLING INTO TRAFFIC. FROM WHAT I'VE READ ONLINE, THE ONLY FIX TO THIS PROBLEM IS TO REPLACE THE ENTIRE GAS TANK SYSTEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10653683November 9, 2014
FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
MY WIFE JUST FINISHED REFUELING AND PROCEEDED FROM THE STATION AND TURNED OUT ON THE HIGHWAY. UPON APPROACHING A STOPLIGHT CAME TO A COMPLETE STOP. AFTER THE LIGHT TURNED GREED PROCEEDED TO ACCELERATE, AFTER PRESSING THE ACCELERATOR THE VEHICLE BEGAN TO STUMBLE AND THEN STALL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10653147November 6, 2014
ENGINE, FUEL/PROPULSION SYSTEM
RIGHT AFTER GAS TANK FILL UP ENGINE STALLS,AND ON SEVERAL OCCASIONS WAS ON HIGHWAY ,AND POWER WENT OFF AFTER STALLING WITH LOSS OF CONTROL OF STEERING,AND RAPID DECELERATION WITH NEAR MISS OF BEING REAR ENDED. SOMEONE IS GOING TO BE KILLED,AND ACCORDING TO THE REPORTED INCIDENCES ON THE INTERNET SOMEONE WILL EVENTUALLY BE KILLED OR SEVERELY INJURED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10650659October 28, 2014
ENGINE, FUEL/PROPULSION SYSTEM
IN MAY 2014, AT APPROXIMATELY 55MPH, AFTER REFUELING AND DRIVEN 50 MILES. THE ENGINE LIGHT CAME ON. STOPPED VEHICLE AND CHECKED EVERYTHING THAT I COULD CHECK, AS I HAD JUST HAD IT SERVICED APPROX. 300 MILES PRIOR. CONTINUED ON TRIP, AFTER SPENDING NIGHT IN MOTEL, TOOK VEHICLE TO REPAIR FACILITY AND THEY DID DIAGNOSTICS...CAME UP WITH CODE 461, WHICH WAS FUEL LEVER SENSOR IN GAS TANK. CONTINUED ON TRIP, (1300 MILES), AFTER THAT TWO TIMES WHEN I HAD FILLED UP WITH GAS AGAIN THE VEHICLE DIED WITHIN 2 MILES...NO ENGINE LIGHT EVER CAME BACK ON. THIS CONTINUED THROUGHOUT THE SUMMER, OCCURRING 80% OF THE TIME I REFUELED...TOOK TO DEALER AS I HAVE EXTENDED WARRANTY, THEY ARE LOOKING INTO IT, BUT SAID BECAUSE THE ENGINE LIGHT DOESN'T COME BACK ON, THEY CAN'T EVALUATE IT. READ SOMEWHERE SINCE I TOOK IT BACK TO THE DEALER, THAT IF I DON'T FILL THE TANK UP FULLY, THAT WILL CURE THE PROBLEM? THE ENGINE DYING HAPPENS WHILE DRIVING LESS THAN 20MPH, SO FAR...COULD BE A PROBLEM PULLING OUT IN TRAFFIC? THIS IS NOW OCTOBER, STILL EXPERIENCING PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10640886October 2, 2014
ELECTRICAL SYSTEM
VEHICLE SHUT OFF WHILE DRIVING ON INTERSTATE AT 48MPH AND INCREASING. FIRST ALL DIALS DROPPED TO 0, BRAKES WOULD NOT WORK, WHEN PRESSING ACCELERATOR ENGINE WOULD REV UP BUT NO POWER - THEN THIS STOPPED ALSO. TURNED KEY TO OFF POSITION AND WAITED A FEW MINUTES, THEN TURNED CAR BACK ON AND ALL SEEMED WELL. THIS WAS VERY SCARY WITH CARS & TRUCKS WHIPPING BY AT 50 PLUS MPH! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10638968September 25, 2014
FUEL/PROPULSION SYSTEM, ENGINE AND ENGINE COOLING
AFTER FUELING THE VEHICLE, PULLING OUT FROM THE GAS STATION, THE VAN STALLS VIOLENTLY: LOSES POWER, LURCHES & SURGES. THIS HAS BECOME INCREASINGLY SEVERE, MOST RECENTLY NEARLY CAUSING A COLLISION WHEN THE VAN STALLED OUT AS WE WERE LEAVING THE GAS STATION IN HEAVY TRAFFIC. THE PROBLEM IS THE VAPOR/LIQUID SEPARATOR VALVE LOCATED AT THE TOP OF THE FUEL TANK. THE VALVE IS DESIGNED TO PREVENT LIQUID FUEL FROM ENTERING THE CHARCOAL CANISTER/EMISSIONS SYSTEM. WHEN THE VALVE FAILS, LIQUID GAS CAN ENTER THE LINE AND FILL THE CHARCOAL CANISTER. AFTER REFUELING THE PCM ON THE VEHICLE DETECTS A CHANGE IN FUEL LEVEL. THEN, WHEN THE ENGINE MEETS CERTAIN TEMPERATURE AND DRIVING CRITERIA, THE PCM ISSUES A PURGE COMMAND TO THE CHARCOAL CANISTER TO REMOVE THE STORED GAS VAPORS. IT?S AT THAT POINT THAT ALL THE LIQUID GAS IN THE LINE GETS SUCKED INTO THE CHARCOAL CANISTER. THE PCM EXPECTS TO SEE GAS VAPORS ENTERING THE INTAKE MANIFOLD AND IT IS PREPARED TO ADJUST AIR/FUEL MIXTURES TO COMPENSATE. HOWEVER, IT IS NOT PREPARED TO SEE LIQUID GAS COMING INTO THE INTAKE. THAT?S WHAT CAUSES THE ENGINE TO STALL. UNFORTUNATELY, THE ONLY FIX IS TO REPLACE THE ENTIRE GAS TANK. CHRYSLER DOES NOT SELL THE VAPOR/LIQUID VALVE AS A SEPARATE UNIT. WE ARE NOW AT NEARLY 100,000 MILES, AND THE PROBLEM PERSISTS AND CONTINUES TO GET MORE SEVERE. I HAVE CALLED DODGE, BUT THEY SAY THERE IS NO EXTENDED WARRANTY ON THE FUEL TANK/EVAPORATION CANISTER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10637670September 19, 2014
ENGINE, STEERING, FUEL/PROPULSION SYSTEM
ON APPROXIMATELY 04/07/2014 THE VAN WAS FILLED UP WITH GAS, I TOOK THE NOZZLE OUT WHEN IT SHUT OFF AND DID NOT PUT ANY EXTRA GAS INTO TANK. I STARTED UP THE VAN TO EXIT THE STATION WE DROVE ABOUT 100 YARDS AND THE VAN JERKED WITH A KNOCKING SOUND TWICE AND STALLED. I STARTED THE VAN BACK UP, WHEN IT DID START THE IDLE WAS ROUGH AND LOW. I HELD MY FOOT ON THE GAS PEDDLE TO SLIGHTLY RAISE THE RPM'S FOR ABOUT 30 SECONDS BEFORE WE PROCEEDED. IT TOOK A COUPLE OF MILES BEFORE THE VAN SEEMED TO BE ABOUT NORMAL. THIS HAS HAPPENED TWO OTHER TIMES SINCE THEN. ANOTHER COMPLAINT, THE FRONT BRAKES SQUEAK EVERY TIME YOU APPLY THEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10633409September 15, 2014
ENGINE, FUEL/PROPULSION SYSTEM
REFUELED VEHICLE, AFTER SHUTTING OFF IGNITION, VEHICLE STALLS IMMEDIATELY AFTER STARTING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10633429September 15, 2014
FUEL/PROPULSION SYSTEM
AFTER FILLING THE GAS TANK ON OUR 2007 DODGE GRAND CARAVAN, IT STALLS REGULARLY AFTER DRIVING A FEW HUNDRED YARDS. MOST RECENTLY IT STALLED AS MY FAMILY WAS MERGING IN TRAFFIC. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10632399September 11, 2014
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THIS FAILURE OCCURRED TWICE AFTER THE VEHICLE WAS FILED WITH FUEL. THE VEHICLE WAS TAKEN TO THE INDEPENDENT MECHANIC FOR A DIAGNOSTIC TESTING, HOWEVER THEY COULD NOT DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,000. RG *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10632112September 10, 2014
FUEL/PROPULSION SYSTEM, ENGINE, STEERING
WHEN I FILL UP MY VAN, THE VEHICLE WILL START HOWEVER AFTER A FEW MINUTES AND I AM ON THE HIGHWAY THE CAR COMPLETELY SHUTS OFF. HAVE HAD TO SEVERAL MECHANICS LOOK AT THE VAN, AND NO ONE KNOWS WHAT THE ISSUE IS. I TRY TO RIDE AROUND THE GAS STATION PARKING LOT TO INSURE THE VAN IS GOING TO RUN BECAUSE I HAVE HAD SEVERAL CLOSE CALLS WHEN THE VEHICLE SHUTS DOWN WHEN I AM TRYING TO CROSS TRAFFIC. I WILL THEN HAVE NO BRAKES, POWER STEERING, ETC. THE VAN SHUTS COMPLETELY OFF. I USUALLY ABLE TO RESTART THE VEHICLE. THIS IS A VERY UNSAFE ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10632326September 10, 2014
FUEL/PROPULSION SYSTEM, ENGINE
FREQUENTLY AFTER FILLING UP WITH GAS AT COSTCO, THE VAN STALLS, ESPECIALLY WHILE I AM GOING AROUND A TURN. IT HAS COME CLOSE TO CAUSING AN ACCIDENT BUT I HAVE BEEN ABLE TO PUT IT IN NEUTRAL AND GET IT STARTED QUICKLY ENOUGH TO AVOID GETTING REAR-ENDED. VERY STRANGE AND ANNOYING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Dodge Grand Caravan