Chevrolet Suburban Complaints (2023)

149 consumer complaints on file.

#11636860January 19, 2025
ENGINE
While driving my family home from our christmas vacation on the Garden State Parkway (NJ) the engine shut off and would not restart. This happened on a stretch of the highway with no shoulder while traveling at 65mph. Thankfully we were able to coast far enough to a section of highway with a shoulder. This incident left my [XXX] , [XXX] , my wife and I and our dog stranded in the freezing cold 100 miles from home. After a stressful next few days the Chevrolet dealership diagnosed it as blown bearings in the motor. It has now been over three weeks and no word from GM when a new motor will be available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11636839January 18, 2025
ENGINE, POWER TRAIN
When traveling at highway speeds our vehicle suddenly lost all engine power. Driving in the passing lane of [XXX] at 75 mph our 2023 Chevrolet suburban RST 6.2 lost all engine power and went into neutral. We were barely able to make it over to the right breakdown lane without getting hit and making it with no power. We were stranded on the busy interstate for three hours with my wife and three young kids in a very dangerous location. They were scared and because we barely made it into the breakdown lane and so close to speeding traffic had to stand outside of the vehicle close to the woods further from dangerous traffic. The Suburban was flatbedded to nearest Chevrolet dealer where we were told the engine was seized and would need to be totally replaced. We were lucky to be alive but now stranded 1000 miles away from home as we were returning from a vacation in Florida. The sudden lose of all engine power traveling on the highway with our entire family was both scary and dangerous. The suburban has now been in the shop for three weeks with no date in sight to be ready and 1000 miles away. This was a truly dangerous situation and thankfully we came out unscathed but I fear someone else may experience the same type of failure and not be so lucky. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11636670January 17, 2025
ENGINE
On January 1st driving east bound on road 520 in central florida. I was driving around 65mph when the vehicle suddenly shut off. The displayed showed a warning saying that something of the sort that I needed to press the brake to start the engine even though I was driving normally. I had to coast to the side of the road and I pressed the brake. once the brake was engaged the vehicle immediately went to park and will not start. I press the ingition button and the screen would go blank and no sound or warnings were displayed. I had to call the police to provide a safety as the vehicle was in a very dangerous area and all my family was on the vehicle. the police laid down flares and I contacted a tow truck using onstar. Onstar was unable to communicate with the vehicle to diagnosed the issue and no warnings or errors were displaying. The vehicle was towed to Carl Black Chevrolet of Orlando Florida. The dealer stated that the engine is locked (L87) and was not able to turn, therefore the vehicle does not start. The dealership technicians have informed that the vehicle needs a new engine and GM needs to approved, the vehicle is still under warranty and I've contact GM and until today, 17 days later, GM has not responded or allowed the dealership to fix my vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633963January 3, 2025
POWER TRAIN, VEHICLE SPEED CONTROL
While driving our 2023 Chevrolet Duramax diesel suburban, I was waiting, at a complete stop, against the median to make a U turn. When the traffic cleared, I began the turn when I suddenly noticed a nearly complete loss of power, hesitancy of engine engagement, and little response to the gas pedal being depressed. Then an error message appeared on the dashboard stating "Low acceleration warning". There was very little acceleration power available. The rear wheels seemed to spin. I was perilously endangered while making a U-turn across lanes because of this loss of power. The vehicle was then taken immediately to our local Chevrolet dealer who diagnosed a error code message (P0700, 0747) related to transmission valve and injectors. We are very concerned that this was a dangerous occurrence and should be further investigated. We have a 30-year history of Suburban ownership, however this is our first diesel model. We have never had problems of this significance, or seen this error message before. Since this diesel Suburban is nearly new, we are particularly concerned about the durability and safety of this vehicle. Please see attached servive report. The AC compressor was also failed and replaced
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11624410November 10, 2024
FUEL/PROPULSION SYSTEM, POWER TRAIN
DEF sensor has failed and required placement. Required three visits to the dealer to get them to address it (Grayling, MI, White Lake, MI and Charlottesville VA). Transmission throttle body failed and required replacement. Took 2 visits to get it addressed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622373October 28, 2024
ENGINE
The 2023 Chevy Suburban has a serious oil burning problem. It starts burning oil after 20,000 miles. It starts burning oil after 50,000 miles. Many people around me have this problem. Why is there no recall?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619593October 14, 2024
ENGINE
While driving on interstate, vehicle's engine turned off and transmission switched to neutral without warning. Vehicle was stopped and immobilized with no ability to shift or start.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619220October 10, 2024
SERVICE BRAKES
Failed break fluid detection
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11617210September 30, 2024
FUEL/PROPULSION SYSTEM
The fitting on the fuel pressure regulator on the engine began to separate from the housing and started spraying fuel all over the firewall and the fuel ran down the firewall onto the exhaust pipes. No check engine light signaled. The only way I knew that it was spraying, was I started to smell raw fuel through the air conditioning vents. Luckily I was able to get it to a dealer before any fuel caught fire. The dealer repaired it but GM stuck me with half of the bill for the repair. I have pictures of the failed part if necessary. This is extremely dangerous to anyone that may not pay attention to car issues unless a check engine light comes on.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11613930September 11, 2024
STRUCTURE:BODY, ELECTRICAL SYSTEM
The windows would go down all by themselves and not roll up . The infotainment system will flash on and off telling you to start strip all by itself. The door locks will lock you out and in not letting unlock the truck . The key fob is the only way to unlock it. I have taken it to the dealer five times to be repaired and they say GM software is not capable of finding the electrical problem. They just keep replacing parts. I filed a complaint with The State AG office and GM said they were not going to address the complaint because the vehicle was still under warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11613381September 9, 2024
VISIBILITY/WIPER
The wipers have stopped working on a least 6 different occasions. I have to pull over immediately due to not being able to see out the windshield. I try adjusting the switch through all the settings. I shut off the engine and restart the truck. I also turned off the rain sense function on the vehicle settings. Nothing I do will get the wipers working again. I have to wait for the rain to slow down to try to get to my destination. While I continue to drive, the wipers will start working again after about 15 or 20 minutes. The first time this occurred, they were only out for around 30 seconds before they started working again. It seems each occurrence is taking longer for the wipers to come back on. I took the vehicle to Armen Chevrolet of Ardmore on 08/05/2024 for service. They were not able to duplicate the problem. I was told to bring the truck back while the wipers are not working. That is a problem since this only happens intermittently. I fear for my safety and others if this happens at high speeds on a highway in heavy rain. I have another appointment on Monday 09/16/2024 to have diagnose the problem again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11600163July 8, 2024
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the vehicle lost electrical power, failing to display any information on the instrument panel; however, the vehicle still had motive power. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who determined that the instrument panel control module needed to be reset. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 2,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11593901June 12, 2024
ELECTRICAL SYSTEM, POWER TRAIN
I recently took my 2023 Chevrolet Suburban in to make sure everything was working properly with the power train... it has been having bucking and stuttering between 15-45mph, which was super concerning to me, as I am transporting 3 children [XXX]. I took in yesterday, and was called back today to confirm that the issue is happening... the problem is that instead of Chevrolet recalling these vehicles to have this computer issue taken care of... they did an update and are charging their clients to have this update done. This is a serious safety hazard, especially for families like mine that cannot afford to have this update done. I will likely have to drive around without having it done, all because of GM's greediness. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11584536April 22, 2024
ENGINE
The contact owns a 2023 Chevrolet Suburban. The contact stated while driving at approximately 70 MPH, the vehicle began to shake, fumes came out from the exhaust, and the check engine warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed with an engine lifter failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11582408April 11, 2024
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Automatic Emergency Braking system activated at ~77mph. Essentially I had started braking appropriately and at about the same time the AEB system seemed to conclude more breaking was needed. This led to brief loss of vehicle control when brakes COMPLETELY LOCKED at high rate of speed ~77mph. According to vehicle manual this system should not activate at speed great than 50mph (photo attached). This is dangerous because i could have lost control and/or someone behind me could smash into me. My vehicle does not have adaptive cruise. Vehicle and other systems otherwise work perfectly. As a side note the extreme brake application at high speed caused cargo within the vehicle to slam forward and destroy the windshield, in addition to being a scary event.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11574731February 29, 2024
STRUCTURE:BODY
Question 1) I’m experiencing bubbling under the factory paint and it’s available for inspection Question 2) Unknown Question 3) Yes Question 4) Yes it has been inspected by Chevrolet dealership Question 5) I noticed the defects when I bought the vehicle brand new in 3/1/2023
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11564950January 11, 2024
ELECTRICAL SYSTEM, ENGINE
While driving the vehicle on an extended road trip trip on the interstate the vehicle randomly shut off while driving at highway speeds. When the vehicle turned off all interior and exterior lights did not work. The engine turned off. In order to begin driving again the vehicle needed to be restarted. This issue happened 3 separate times. In between, the vehicle has been turned off. It is a safety issue to have your vehicle turn off randomly while driving at any speed. The issue has not been reproduced by the dealer. The vehicle has been seen by the dealer and stated "they are unable to find any issue" There was not indication before or after the 3 events that would indicate issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11564444January 9, 2024
STEERING, SERVICE BRAKES, ELECTRICAL SYSTEM
The power steering on the vehicle had failed on December 10th, 2023. The sign was displayed on the dashboard for the vehicle. The vehicle was taken to Sunrise Chevy and stayed with them for a month for repair and they have been unable to repair the issue. They said the rack and pinion had gone bad on this brand new car. This is very dangerous as the safety of myself as well as others on the road are compromised due to faulty steering problems.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11557477November 29, 2023
ELECTRICAL SYSTEM, UNKNOWN OR OTHER, BACK OVER PREVENTION: WARNINGS
On Star module failure. The module controls many different safety features and it has failed and has been on a backorder for months creating a safety issue every day.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11556381November 21, 2023
ELECTRICAL SYSTEM, VISIBILITY/WIPER, EXTERIOR LIGHTING
While driving on the highway at night during rainy conditions the wipers stopped in the up position, and at the same time, the headlights turned off. After a few seconds they resumed normal operation. My headlights were in the auto position and my wipers were also in the automatic setting. Being as that I was on a highway at night, in the rain, and going approximately 65mph surrounded by traffic, this was an extremely dangerous situation to be in. Without headlights and windshield wipers, my windshield was immediately obstructed and I was unable to see the road without headlights. More so, other traffic might have had trouble seeing my vehicle. This problem has not been replicated by myself or a dealer. It has been random in nature. When the incident happened, there were no warning lights on the gauge cluster or anything else inside the vehicle that seemed to be affected.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Suburban