Chevrolet Suburban Complaints (2021)

185 consumer complaints on file.

#11732284April 19, 2026
FUEL/PROPULSION SYSTEM
My 2021 Chevrolet Suburban experienced a sudden no start condition which required the vehicle to be towed for repair. A diagnostic inspection determined that both the fuel pump and the fuel pump control module had failed. I paid out of pocket for the full repair, including replacement of both components. Several months later, GM issued a safety recall for the fuel pump control module on this vehicle. I submitted a reimbursement request to GM. GM agreed to reimburse only the control module , but refused to reimburse the fuel pump, even though the pump failure was directly caused by the defective module that is now under recall. Federal recall reimbursement guidelines require manufacturers to reimburse the full cost of the remedy for the defect. In this case, the defective module caused the fuel pump to fail, making the pump replacement part of the necessary remedy. GM’s refusal to reimburse the full repair cost leaves me paying for damage caused by the recalled component. I am requesting NHTSA’s assistance in reviewing GM’s refusal to reimburse the full repair cost associated with this recall related failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730078April 8, 2026
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, LANE DEPARTURE: WARNING
Lane departure assist, adaptive cruise control, auto emergency braking, adaptive high beam, forward collision warning system became unresponsive while driving on highway during trip. Had to take vehicle into GM dealership for ADAS camera replacement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729192April 4, 2026
ELECTRICAL SYSTEM
Had an engine replacement in dec of 2025 and had to pay for it since wasn’t under warranty or recall. And now my replacement engine which has a warranty now. Just failed in March 2026 which about 3 months later. Had metal shavings in engine and multiple cylinders misfiring. And now I don’t have a family vehicle to drive my family around again. There should’ve been a recall on my engine, but wasn’t this is not fair. And I’m paying the price for it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727466March 27, 2026
STEERING
The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving at various speeds, the steering wheel was difficult to turn to the left or the right. The contact stated that the failure was intermittent, but was a recurring failure. There was no warning light illuminated. The contact stated that prior to the failure, there was an abnormal whining sound while turning the steering wheel. The vehicle was not taken to a local dealer or independent mechanic to be diagnosed or repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 33,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726495March 23, 2026
ENGINE, POWER TRAIN
My 2021 Chevrolet Suburban experienced a sudden and complete engine failure at approximately 79,000 miles. The vehicle became inoperable and is currently at a dealership pending evaluation. There were no prior warnings indicating an imminent catastrophic failure. A sudden engine failure of this nature presents a significant safety concern, including the risk of loss of propulsion during operation. The failure has been confirmed by the dealership, and no repairs have been authorized at this time pending further review. This complaint is being submitted to document a sudden and severe engine failure and to request evaluation of potential safety-related defects involving internal engine components.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725782March 20, 2026
POWER TRAIN, STEERING, ELECTRICAL SYSTEM
I am submitting this complaint to report a serious safety issue involving my 2021 Chevrolet Suburban equipped with the 3.0L Duramax diesel engine. The vehicle has experienced a recurring problem related to the engine wiring harness. While driving, the vehicle will unexpectedly stall without warning. At the same time, there is an immediate loss of power steering assist, significantly reducing the ability to safely control the vehicle. This creates a dangerous situation, especially at highway speeds or in traffic. The failure appears to be linked to a defect or malfunction in the engine wiring harness, which may be causing intermittent electrical interruptions to critical engine systems. There were no prior warning signs sufficient to prevent the incident. This issue poses a substantial safety risk not only to the driver and passengers but also to other motorists. Sudden engine shutdown combined with loss of steering assist increases the likelihood of a crash. I believe this may be a systemic defect affecting other vehicles of the same model and configuration. I urge the National Highway Traffic Safety Administration to investigate this issue and determine whether a recall should be issued. Vehicle Information: Make: Chevrolet Model: Suburban Year: 2021 Engine: 3.0L Duramax Diesel
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724367March 14, 2026
ENGINE, POWER TRAIN
On Friday, March 13, 2026, while traveling at approximately 60 mph on the highway, my 2021 Chevrolet Suburban equipped with an L87 6.2L V8 engine experienced a sudden and complete loss of motive power. The failure sequence began with a dashboard warning prompting me to "press the start button again," followed immediately by the vehicle shifting into neutral without any driver input. Despite repeatedly pressing the accelerator, the vehicle continued to decelerate and could not re-engage drive. A second dashboard warning displaying "engine recall" then appeared mid-incident. Subsequently, the rear wheels locked, forcing the vehicle to coast to a complete stop on the hard shoulder without any brake input required from the driver. Upon coming to a full stop, the start button continued flashing with repeated prompts to press it, the vehicle lock emblem illuminated on the dashboard, and the vehicle became fully and mechanically immobile, unable to shift out of neutral or transition into any other gear. The engine could not power the vehicle at all. My safety and the safety of other motorists were directly and seriously endangered, as the failure occurred without warning in the middle lane of an active highway at highway speed, leaving the vehicle unable to maneuver or accelerate out of harm's way. A responding police officer confirmed the road hazard on scene and remained present to protect the vehicle and occupants while we awaited assistance. The AAA tow truck operator independently concurred upon arrival. The vehicle was transported to Classic Chevrolet, Grapevine, TX, the same day and is currently awaiting full technical inspection by the dealership's service team; an official mechanical diagnosis remains pending. The dealership service advisor has verbally confirmed awareness of an active engine and powertrain/transmission recall affecting this vehicle. The failed component — the L87 6.2L V8 engine and associated drivetrain — is available for inspection
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724006March 12, 2026
ENGINE
While driving the Engine warning light, service ESC light, and collision light all came on and an engine knock started. I also experienced a loss of power at the same time. Car was taken to local Chevy dealership for evaluation and repair. Dealership advised that they dropped the oil and found metal shavings in the oil. After further investigation, we were advised that it was a crankshaft connecting rod failure. We have an extended warranty and were waiting to hear back on repair coverage. GM denied the repair as this vehicle is not part of the active recall. Our warranty company also denied the repair stating we did not have adequate records of oil changes. Receipts for oil and filters were provided.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723836March 12, 2026
VEHICLE SPEED CONTROL, ENGINE AND ENGINE COOLING
See attached document for complaint.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723503March 11, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving 35 MPH on the highway, the vehicle stalled. The contact pulled over to the side of the road. There was no warning light illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was repaired out-of-pocket. The contact related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The manufacturer was notified of the failure and informed the contact that the VIN was not under recall. The failure mileage was approximately 92,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722922March 9, 2026
POWER TRAIN
Rear Axle is grinding. Took vehicle into dealer and it is the well documented rear axle issue but this vehicle is not included in a recall. The differential fluid was replaced and figure 8s were done but there is still grinding. The rear axle also drags at times when in auto 4wd. The dealer said the next step would be to replace the axle. This is the issue: Differential Noise/Failure: Reports indicate a rubbing noise while turning, often attributed to the rear differential. In some cases, the entire rear differential has required replacement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722779March 8, 2026
ENGINE
In April of 2022 with 26k miles my vehicle had its first engine failure, Chevrolet dealership had to replace engine lifters due to a known engineering defect with the 2021 6.2 L87 engine. Now in late February 2026 with 80k miles my engine has locked up and requires a brand new engine replacement. For some reason, even though this is a L87 6.2L 2021 engine it is not part of the broader recall for this exact same engine failure for the same engine year and model.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722005March 4, 2026
ENGINE
While driving, the engine malfunctioned. There were no warning lamps, messages, or other symptoms prior to the malfunction. The vehicle has been inspected and repaired by a Chevrolet dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719559February 21, 2026
ENGINE, UNKNOWN OR OTHER, FORWARD COLLISION AVOIDANCE: WARNINGS
The check engine and traction control light came on in my car. This was accompanied by a clanking sound, shaking. The panel said “ SERVICE ESC” “ service traction control” and “ forward collision system unavailable” The Chevrolet light logo on the back of my car will also not turn off occasionally whenever the car is turned off.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719462February 20, 2026
POWER TRAIN
My [XXX] Daughter lost the ability to put the vehicle in reverse while running errands on a Saturday. We had to push the truck out of the parking spot "backwards" in neutral in order to get the vehicle in a position to put it in "drive". She had been going in and out of shopping centers (forwards and backwards) earlier when the reverse suddenly stopped. I dropped the vehicle at a nearby auto shop in a fit of desperation (maybe 1/2 mile away). They told me they thought the transmission was shot, so I picked it up and took it to Andean Chevrolet (Dealer) in Cumming, GA. While driving it to Andean on Tuesday (2/17), the transmission went into low acceleration mode where I couldn't go into upper gears and topped-out at 3,500 rpm's max for the 13+ miles (30 min) drive. Andean confirmed on Friday (2/19) that the entire transmission is shot with metal all inside of the fluid, gears being broken, and the valve body being broken. The truck is 5.5 years old with 93K mile on it and we were just shocked. The repair for GM Reman transmission was quoted at ~$9.2K and we just finalized a call directly with GM Customer Service to see if GM would offer any discounts to the Dealer on the repairs. We are still waiting on that result while the repairs are being made. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718829February 18, 2026
POWER TRAIN, FUEL SYSTEM, GASOLINE, ELECTRICAL SYSTEM:12V/24V/48V BATTERY
The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving 45 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended, and the vehicle decelerated unintendedly. Additionally, the vehicle failed to exceed 42 MPH. Later in the day, the gear shifter was shifted to reverse; however, the vehicle failed to reverse as intended. The vehicle was taken to the dealer, where it was diagnosed with transmission valve body failure. The contact was informed that the transmission valve body needed to be replaced. The vehicle was repaired. The contact stated that the vehicle was at the dealer from December 2024 until June 2025. The vehicle was picked up from the dealer. The contact stated that while driving at an undisclosed speed, the engine seized and failed to restart. The vehicle was towed back to the dealer, where the contact was informed that the fuel pump had failed, and the battery was drained. The contact was informed that the battery and the fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 35,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718673February 17, 2026
ENGINE
Engine failure at 86,000 miles with documented regular oil change and recommended services
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717955February 14, 2026
ENGINE
My vehicle was taken in to shop due to recall recommendation I received in GM app for fuel pump control module . After repair was done my engine begin ticking the same day and failed a week later . I documented the whole thing and filed a claim with GM however the dealership that did the repair are not responding to GM . The dealership is alm Chevorlet south in Jonesboro ,GA this vehicle stalled out while I was on the highway . Please help me this vehicle belongs to my limo fleet and this is detrimental to my business . After multiple attempts to get it diagnosed they kept telling me I had to wait in line for weeks out to get it checked out although the problem arose after the new part installation . Then when I brung it back with failed engine soon after they told me that I had to sign a liability release waiver for them to check out the vehicle stating that the vehicle was high mileage and not their fault . The service manager literally instructed me not to leave my vehicle when I wanted to because it would not speed up the process for it to be seen I brung it back when instructed but it was to late because the engine had already failed . They literally forced me to sign a waiver stating that they wouldn’t diagnose it if i didn’t sign the waiver . These people are committing a fraudulent scam and their are unsafe vehicles on the road that arent being treated properly due to these practices . Please contact the dealership and or GM to take this matter more seriously .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717307February 11, 2026
POWER TRAIN
The contact owns a 2021 Chevrolet Suburban. The contact stated that while in reverse (R), the vehicle failed to reverse as intended. The contact’s wife continued driving at approximately 55 MPH, and an unknown message was displayed, and the vehicle failed to exceed 55 MPH. Additionally, the transmission was stuck in gear and failed to upshift into the next gear as designed. The vehicle was pulled over to the side of the road, and the battery was disconnected and reconnected, but the message remained displayed. The vehicle was towed to an independent mechanic, where it was determined that the transmission control valve needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 81,600.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716916February 10, 2026
ENGINE
The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving at various speeds, an abnormal oil consumption was noticed. No warning light was illuminated. In addition, the vehicle was previously taken to a local dealer, where an oil consumption test was performed; however, the contact was advised to bring the vehicle back for further investigation. An appointment with the same local dealer was scheduled to inspect the vehicle. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Suburban