Chevrolet Sonic Recalls

16 recalls on file.

• Recall23V516000July 27, 2023
  AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE

  General Motors, LLC (GM) is recalling certain 2013 Buick Verano, Chevrolet Camero, Sonic, and Volt vehicles. The driver-side air bag inflator may explode during deployment due to a manufacturing defect.

  Remedy

  Dealers will replace the driver-side air bag module, free of charge. On some 2013 Volt vehicles, the steering wheel will be replaced as well, free of charge. Owner notification letters were mailed October 23, 2023. Owners may contact Buick customer service at 1-800-521-7300 and Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232413120.

• Recall18V342000May 27, 2018
  SEATS

  General Motors LLC (GM) is recalling certain 2018 Chevrolet Sonic vehicles. A joint in the driver's seat-back frame may not be properly welded, reducing the strength of the seat-back frame.

  Remedy

  GM will notify owners, and dealers will replace the driver's seat-back, free of charge. The recall began June 28, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18178.

• Recall16V422000June 10, 2016
  ELECTRICAL SYSTEM:SOFTWARE

  General Motors LLC (GM) is recalling certain model year 2015-2016 Chevrolet Sonic and Trax, and 2013-2015 Spark vehicles equipped with a Bring Your Own Media radio. The affected radios may fail to provide an audible warning chime when the driver fails to fasten their seatbelt or if the driver leaves the key in the ignition. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 208 "Occupant Crash Protection" and 114 "Theft Protection."

  Remedy

  GM will notify owners, and dealers will update the radio software, free of charge. The recall began on July 22, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 45340.

• Recall16V257000April 28, 2016
  EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

  General Motors LLC (GM) is recalling certain model year 2013-2016 Chevrolet Sonic and Trax vehicles and 2013-2015 Chevrolet Spark vehicles equipped with a Bring Your Own Media radio. The affected radios may fail to provide an audible warning chime when the driver, after turning off the ignition and leaving the key in the cylinder, waits 10 minutes or longer to open the door. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114 "Theft Protection."

  Remedy

  GM will notify owners, and dealers will update the radio software, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 17130.

• Recall15V416000June 30, 2015
  EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

  General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Spark vehicles manufactured April 30, 2014, to May 20, 2015, and 2015 Chevrolet Sonic vehicles manufactured June 18, 2014, to June 10, 2015. In the affected vehicles, equipped with the base radio and OnStar, the radio may lock up due to a software issue, causing the display to go blank and all audio functions to cease. Because of this, there may be no warning chimes such as the reminder to buckle the seat belt and the key being left in ignition when the driver goes to exit the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 208 "Occupant Crash Protection", and 114 "Theft Protection."

  Remedy

  GM will notify owners, and dealers will update the radio software, free of charge. The recall began on August 11, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15504.

• Recall14V543000September 9, 2014
  AIR BAGS

  General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Sonic vehicles manufactured July 28, 2014, to August 1, 2014. Due to a loss of electrical connection in the steering column, in the event of a severe crash, the driver's frontal air bag deployment may be limited to the first-stage deployment only instead of the intended first-stage and second-stage deployments.

  Remedy

  GM will notify owners, and dealers will test the terminals in the IP harness clock spring coil connector and replace any loose terminals, free of charge. The recall began in October 2014. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14537.

• Recall14V417000July 2, 2014
  EQUIPMENT:ELECTRICAL

  General Motors LLC (GM) is recalling certain model year 2013-2014 Buick Encore all-wheel-drive vehicles manufactured August 23, 2012, to September 9, 2013; Verano vehicles manufactured August 8, 2012, to June 20, 2013; Chevrolet Cruze vehicles manufactured August 7, 2012, to August 16, 2013, and 2012-2014 Chevrolet Sonic vehicles manufactured May 10, 2011, to August 16, 2012 equipped with a Calix oil pan/block heater. In cold temperatures, the insulation on the engine block heater cord can become damaged, allowing the wires to be exposed.

  Remedy

  GM will notify owners, and dealers will replace the engine oil pan/block heater cord with a new cord that is rated for temperatures of minus 40 degree Celsius. The recall began in August 2014. Owners may contact Buick customer service at 1-800-521-7300 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14257.

• Recall14V315000June 12, 2014
  POWER TRAIN:AUTOMATIC TRANSMISSION

  General Motors LLC (GM) is recalling certain model year 2012 Chevrolet Sonic vehicles manufactured March 1, 2012, to June 29, 2012, and equipped with a 6 speed automatic transmission and 1.8L four cylinder engine. In the affected vehicles, the transmission turbine shaft may fracture.

  Remedy

  GM will notify owners, and dealers will replace the transmission turbine shaft, free of charge. The recall began on August 8, 2014. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14234.

• Recall14V300000June 6, 2014
  AIR BAGS

  General Motors LLC (GM) is recalling certain model year 2012 Buick Verano vehicles manufactured December 2, 2011 to July, 16, 2012, Chevrolet Cruze vehicles manufactured December 7, 2011 to July 25, 2012, Chevrolet Sonic vehicles manufactured December 5, 2011 to August 2, 2012, and Chevrolet Camaro vehicles manufactured December 1, 2011 to June 11, 2012. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.

  Remedy

  GM will notify owners, and dealers will replace the steering wheel air bag coil, free of charge. The recall began on July 25, 2014. Chevrolet owners may contact GM at 1-800-222-1020. Buick owners may contact GM at 1-800-521-7300. Note: This is an expansion of recalls 12V-522 and 13V-023.

• Recall13V464000September 26, 2013
  FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING

  General Motors (GM) is recalling certain model year 2013 and 2014 Chevrolet Sonic vehicles manufactured August 2, 2013, through August 12, 2013. Due to insufficient welds, the front fuel tank strap bracket may separate from the vehicle.

  Remedy

  GM will notify owners, and dealers will inspect the front fuel tank strap bracket, and repair it as necessary, free of charge. The recall began on November 7, 2013. Owners may contact GM at 1-800-521-7300. GM's recall campaign number is 13296.

• Recall13V220000May 24, 2013
  ELECTRICAL SYSTEM

  General Motors LLC (GM) is recalling certain model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; model year 2014 Chevrolet Impala; and 2013 Chevrolet Sonic vehicles. Originally, in May 2013, GM recalled 1,627 model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; and model year 2014 Chevrolet Impala vehicles. In October 2013, GM informed the agency that it was adding model year 2013 Chevrolet Sonic vehicles to this campaign , representing an additional 8,050 units. The total number of vehicles being recalled is now 9,677. On the affected vehicles, the brake lamps may intermittently flash without the brakes being applied and the cruise control may disengage. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, reflective devices, and associated equipment."

  Remedy

  GM will notify owners, and dealers will reprogram the body control module. The recall began on June 13, 2013. Owner's may contact Chevrolet at 1-800-630-2438 or Cadillac at 1-866-982-2339. GM's recall number is 13158.

• Recall13V023000January 24, 2013
  AIR BAGS

  General Motors LLC (GM) is recalling certain model year 2012 Chevrolet Camaro, Cruze and Sonic, and model year 2012 Buick Verano vehicles. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.

  Remedy

  GM will notify owners, and dealers will replace the steering wheel air bag coil, free of charge. The safety recall began on February 13, 2013. Owners may contact General Motors at 1-800-521-7300.

• Recall12V522000October 31, 2012
  AIR BAGS

  General Motors is recalling certain model year 2012 Buick Verano, Chevrolet Cruze, and Chevrolet Sonic vehicles. The driver side frontal air bag has a shorting bar which may intermittently contact the air bag terminals.

  Remedy

  General Motors will notify owners, and dealers will replace the steering wheel airbag coil, free of charge. The safety recall began on January 11, 2013. Owners may contact General Motors at 1-800-521-7300.

• Recall12V454000September 17, 2012
  ELECTRICAL SYSTEM

  General Motors LLC (GM) is recalling certain model year 2013 Chevrolet Sonic vehicles manufactured from May 29, 2012, through August 29, 2012. When a turn signal lamp fails to operate, the Body Control Module (BCM) in these vehicles does not detect this condition and will not indicate the condition to the driver. Thus, These vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, Reflective Devices, and Associated Equipment."

  Remedy

  GM will notify owners, and dealers will reprogram the BCM and the vehicle's key fobs, free of charge. The safety recall began on October 3, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546.

• Recall12V408000August 20, 2012
  VISIBILITY:WINDSHIELD WIPER/WASHER

  General Motors LLC (GM) is recalling certain model year 2012 Chevrolet Sonic vehicles manufactured from May 5, 2011, through February 24, 2012. These vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 104, "Windshield Wiping and Washing Systems." The windshield wiper washer hose on these vehicles may separate from the washer fluid reservoir. If this occurs, washer fluid will not be available to the windshield.

  Remedy

  GM will notify owners, and dealers will secure the windshield washer hose to prevent separation, free of charge. The safety recall began on September 7, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546.

• Recall11V599000December 28, 2011
  SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS

  GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET SONIC VEHICLES MANUFACTURED FROM JUNE 2, 2011, THROUGH NOVEMBER 21, 2011. ON SOME OF THESE VEHICLES, THE FRONT BRAKE INNER OR OUTER PAD MAY BE MISSING.

  Remedy

  GM WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE FRONT BRAKES FOR A MISSING INNER OR OUTER PAD. IF A BRAKE PAD IS MISSING, DEALERS WILL INSTALL NEW INNER AND OUTER PADS, A NEW BRAKE CALIPER, AND A NEW ROTOR. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 14, 2012