Chevrolet Silverado Complaints (2003)

2,092 consumer complaints on file.

#11739790May 24, 2026
TIRES:SIDEWALL, TIRES
TIRE SIZE 75R16, BRIDGESTONE V-STEEL RB215, IS THE BRANDED AND EXACT TIRE ON THE TRUCK WHEN ON 05/23/2026 DRIVING NORMALLY DOWN A LAS VEGAS RURAL ONE-WAY NEIGHBORHOOD STREET I WAS DRIVING DOWN THE ONE-WAY STREET (7200 PIRATES COVE) WHERE THERE ARE PARKED VEHICLES ALONG THE SIDES OF STREET FROM RESIDENTS ETC..... ON BOTH SIDES OF STREET IN VERY CLOSE PROXIMITY. AND AS I WAS PASSING THE SMALL RESIDENTIAL INTERSECTION W/ NO STOP SIGNS IN PLACE, THE TIRE IS EITHER SLIICED BY SHARP OBJECT IIN THE STREET OR JUST BLOWN FROM MANUFACTURER DEFECT, HEAT, OR THE LIKES, ANYWAY IT BLOWS ON THE PASSENGER SIDE OF THE TRUCK DIRECTLY BESIDE A VEHICLE PARKED ALONG THE RIGHT SIDE HEADING EASTBOUND, WHEN IT BLOWS THE VEHICLE DROPS ON THE PASSENGER SIDE LOSES CENTER OF CONTROL AND DESPITE EFFORTS TO AVOID, IT CAUSES MY COLLISION WITH THE PARKED CAR ON THE RIGHT, BECAUSE IT IMMEDIATELY WENT FLAT TO RIM, AND I WAS COLLIDED INTO, THE REAR-END OF A UNOCCUPIED VEHICLE WHICH THEN COLLIDED SLIGHTLY WITH VEHICLE IN FRONT OF IT WHICH LIGHTLY REAR-ENDED A THIRD PARKED CAR IN FRONT OF IT ALSO UNOCCUPIED AND PARKED. AND THE AIRBAG THEN DEPLOYED WITHIN THE VEHICLE ON IMPACT. THIS COULD HAVE RESULTED IN WORST OUTCOMES, MY DEATH OR SERIOUS INJURIES, OR SOMEONE ELSES INJURIES. AND THIS HAPPENED WITH NO WARNING PRIOR TIRE ISUES OR PUNCTURES AND VERY LIMITED TREAD USE OR TIRE PROLONGED ROAD EXPOSURES AND OTHER WEAR AND TEAR RELATED ACTIONS/ACTIVITIES. SO IM ISSUING HIS COMPLAINT BECAUSE THAT IS A RATHER SERIOUS DEFECT IF INDEED THE TIRE AND ITS MODEL, BRAND AND MANUFACTURER HAVE A POSSIBLE RECALL AND PRODUCT DEFECT ON IT'S TIRES THAT COULD BLOW ANYTIME, ANYWHER ON IT'S OWN THATS VERY DANGEROUS FOR ANYONE TO BE USING THE TIRES FOR VEHICLE OPERATION. THEY SHOULD BE PULLED FROM THE PLACES BEING SOLD AT PROMPTLY DISPOSED OF AND NEW REPLACEMENTS FOR AFFECTED DRIVERS
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11731112April 14, 2026
SERVICE BRAKES
While driving down a 50 mph roadway there was a line of cars slowing for a vehicle to make a turn. When gently pushing the brakes to slow down, brake went clear to the floor and could not slow down. Truck was driven into the ditch to avoid rear-ending vehicles. This happened immediately without warning, all braking prior to this incident was normal. When taken to our mechanic, they advised the brake lines underneath were notorious for rusting out and failing, new stainless steel lines were then installed to correct the problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11609048August 16, 2024
TIRES
The contact owns a 2003 Chevrolet Silverado 2500 equipped with Prinx Tires, Tire Line: High Country, Tire Size: 245/75/R16, DOT Number: 04N18HTPC1323. The contact had the tires rotated by an independent mechanic. Upon inspection of the tires, the contact discovered cracks along the base of the tire treads on all four tires. The contact notified the mechanic about the defect and was given a credit for the remaining mileage on the tires warranty. The contact notified the manufacturer about the failure through voicemail and email; however, the contact never received a response. The contact stated that the four tires were replaced. The tire failure mileage was 21,942. The vehicle failure mileage was 342,422.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11576333March 9, 2024
ELECTRICAL SYSTEM
My heater started to shut off then I’d turn it off then turn it back on then it’d come back on again. That went on for a few days. Started my truck in the morning and let it warm up for a few moments when I hear truck is on fire. The fire was in the cab of the truck. It was investigated and they said fire started in the right side of the dash which is where the faulty part is from what I’ve learned about other Chevy trucks same make model and year as my truck
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11535383July 30, 2023
ELECTRICAL SYSTEM
Instrument panel stopped working. Speedometer, fuel gauge and ammeter not working.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11531325July 10, 2023
POWER TRAIN
The component that failed according to the Chevrolet dealer is the "transfer case pump clips", which came loose inside the transfer case and wore a hole through the case causing the oil to come out. If I would not have noticed the oil on the back of my truck, I could have continued to drive the truck, which could have caused the transfer case gears to lock up the front and rear axles while driving and could have caused me to wreck, causing injury to myself, my family or someone else. I marked the area of the leak with a sharpie as depicted in the photos.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11529895July 1, 2023
AIR BAGS
When starting vehicle , after initial dash lights times out, I now get an AIRBAG 9malfunction light). Tried resetting, did not work. Now, every time I start the engine, the comes on and stays on.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11527998June 20, 2023
STEERING
The vehicle was being driven in a parking lot, fortunately, when there was a loud snapping noise that resulted in the total loss of steering control. The vehicle was moving at about 5 MPH at time of the incident. 10 minutes prior, it was being driven on the Freeway at 60 to 65 MPH. In the parking lot, at the time of the steering failure, it was put into Park, ignition was turned off and a Tow service was called to tow vehicle home. The next day, I (the owner) inspected the steering system and found the reason it failed. A threaded connection on the "Pitman Arm" had snapped in half, terminating the connection between the steering column and the center link, causing catastrophic failure of steering system. The vehicle was transported to a repair facility where my diagnosis was confirmed. The Pitman Arm was replaced, at a cost of about $600.00 and returned to service. There were no warning signs, that I was aware of, prior to the component failure. In my opening sentence, I use the term "fortunately" , which truly is an understatement . Had the incident occurred 10 minutes earlier while on the freeway or if it hadn't occurred in a parking lot at a relatively low speed, I don't even like to think about the death, injury and damage that would have occurred.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11525226June 3, 2023
UNKNOWN OR OTHER
When I try and use my left turn signal the hazard lights turn on!! Read numerous instances of this problem online with no solutions! A gentleman online referred me to turn this in to you(nhtsa.gov). The problem is ongoing!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11489582October 17, 2022
SERVICE BRAKES
Hydroboost valve pump shows a recall.,and it's not working properly
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11489023October 12, 2022
POWER TRAIN
I had to replace the replace the housing on my transfer case as it wore a hole in and was leaking. At a cost of 1200 dollars due to myself catching it early as later with a fully disabled case would have been 2600 dollars. My mechanic who deals in transmission repairs told me this a very common problem for Chevy trucks from 1999 to 2006. He claimed he had done 7 transfer cases in one week and was actually replacing a fully wrecked one for 2600 dollars as I brought mine in to be worked on . It had worn a hole through the transfer case and was leaking. As this seems to be a serious defect . I feel it should have been under a recall and reimbursement should be in order for those who paid out of pocket for repairs. My mechanic also stated that he has replaced them at 35, 000 miles and on up. No rhyme or reason to when they fail or leak.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11472912July 8, 2022
STRUCTURE:BODY
The undercarriage or frame of our recent purchase of our 2003 used chevrolet k1500 silverado was discovered recently after purchase to be rusted through and through and chipping off day by day. A private master mechanic has looked the truck over and said that it was not safe to drive. Upon further investigating, the panels that hold up the roof of the truck underneath the interior panels are rusting through and through to the point of breaking. Dealership we bought it from just shrugged their shoulders and said basically oh well, it was sold as is. under the truck on the frame where the wheels are attached, forgive my descriptions but im no mechanic, looks like they can break off at any minute. we have ony about 3/4 of a front and back bumper we later discovered, and the roof of the truck looks as if it had rusted and messed up beause someone before us put plaster to redo the roof of the truck. im scared to put my mother in law in this truck to go anywhere because if it got into a wreck... it would be devestating for everyone. truck has been in a wreck before. pictures and truck is available for inspection upon request,
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11468173June 8, 2022
FUEL/PROPULSION SYSTEM
My truck is a older model Chevrolet Silverado pickup HD the problem is it say engine power reduced. I have had it worked on a few times and keeps reducing if engine power. Can you tell me if there is a recall on this issue or at one point there was a recall? I have had the truck almost 2 years any info would be appreciated. I bought the truck from an individual.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11465070May 17, 2022
SERVICE BRAKES, STEERING
2003 CHEVROLET Silverado1500 HD have power hydro brake liitle leaking when driving so loud same time steering to turning so loud and very hard apply brake step on brake so loud try to stop not easy scary and parked at home right now, i beleive fact recall now because your repoert said that "found none recall", it is now problems same my dad have van recall for 2003 Express 1500 and Express 2500 van problems hybro booster brake and steering system found recall now... as 2003 CHEVROLET Silverado 1500 hd problem same thing the problem, you shoud add up recall because show " no found recall " ???, are you notice different? It parts are same problems with van and truck power hydro and brake/steering system . Please let me to know and email back to me sooner, Thanks.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11461974April 24, 2022
UNKNOWN OR OTHER
UNKNOWN. I went out to the to go somewhere, got in and noticed several big cracks.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11460336April 10, 2022
ENGINE AND ENGINE COOLING
In the middle of the taxiway, while I was traveling my truck turned off while it was running and did not turn on again, putting my safety at risk by being in the middle of the taxiway, after several minutes the truck was able to be removed from the road, then I was able to investigate that I am not the only one that the same thing has happened to him, there is no Safety Recall in this regard, the GM fabric is aware of these cases but only wrote a TSB, it was diagnosed with the scanner and it gave code U1800, before the event there were no lights warning but after the event there is a check engine light on.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11424383July 12, 2021
STEERING, SERVICE BRAKES, HYDRAULIC
The contact owns a 2003 Chevrolet Silverado 2500. The contact stated that while driving at various speeds, the power steering failed causing the steering wheel to become hard to maneuver. The contact heard an abnormal sound coming from the hydro boost area when the brake pedal or accelerator pedal were depressed. The vehicle was taken to the dealer and diagnosed that the intermediate shaft was faulty. The intermediate shaft was replaced however, the failure recurred. The contact requested the dealer to replace the power steering pump but the dealer informed the contact that the failure was caused by the power steering pump. The manufacturer was made aware of the failure and a case was opened. The failure mileage was 115,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11422203June 24, 2021
ELECTRICAL SYSTEM
I was driving in normal conditions around 45 mph with the air conditioner on high. Smoke starts pouring out from underneath the dash on the passenger side and once I get stopped the blower motor resistor had caught fire. I was able to put the fire out myself no incident report was filed. It caused damage to my dash but I was able to extinguish it rather quickly to avoid further damage. I just bought this pick up for my 17-year-old son and if he had of been driving things could’ve been a lot worse especially if his reaction time is any slower than mine.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11417701May 18, 2021
FUEL/PROPULSION SYSTEM, STEERING, ENGINE
My engine has been giving me lean condition codes p0171, p0174 and truck is lacking performance really bad and coolant problems too please message me back
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11397881February 25, 2021
ELECTRICAL SYSTEM
IGNITION WILL NOT INTERMITTENTLY START VEHICLE. DASH LIGHTS COME ON
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Silverado