Chevrolet · Model Report
Showing safety data for the 1996 model year only.
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1995-1999 CHEVROLET MONTE CARLO Z34 PASSENGER VEHICLES. THE BRAKING PERFORMANCE IN WET WEATHER OR WET ROAD CONDITIONS IS REDUCED MORE THAN A DRIVER WOULD EXPECT.
THESE VEHICLES WERE ASSEMBLED WITH ONE OF THE FOUR BRAKE BOOSTER TABS NOT PROPERLY LOCATED IN THE FRONT OF DASH REINFORCEMENT ASSEMBLY.
TL* THE CONTACT OWNS A 1996 CHEVROLET MONTE CARLO. WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE SEIZED WITHOUT WARNING. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1996 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE MAKING A LEFT TURN, THE VEHICLE CRASHED INTO ANOTHER VEHICLE AND THE FRONT AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE DRIVER AND THE REAR PASSENGER SUSTAINED UNKNOWN INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE.
THE FUEL PRESSURE REGULATOR IN THE ENGINE COMPARTMENT DEVELOPED A SEVERE LEAK. THE LEAK CAUSED FUEL TO BE RELEASED IN LARGE QUANTITIES DIRECTLY INTO THE UPPER INTAKE MANIFOLD AND OUT THE THROTTLE BODY. FUEL CONTINUED TO FLOW OUT INTO THE AIR CLEANER HOUSING AND EVENTUALLY THE ENGINE COMPARTMENT AND ONTO THE GROUND. SEVERAL GALLONS OF FUEL WERE DISCHARGED IN THIS FASHION. THE VEHICLE WAS RUNNING POORLY BUT GAVE NO INDICATION THAT THERE WAS A LEAK UNTIL THE AIR CLEAN WAS OPENED. THE PART THAT FAILED WAS A STANDARD MOTOR PRODUCTS PART NUMBER PR216T PURCHASED FROM ROCKAUTO.COM ON 5/15/2013 AND INSTALLED SHORTLY THEREAFTER. VEHICLE MILEAGE AT INSTALLATION WAS APPROXIMATELY 131000. THE PART FAILED ON 10/20/2014 AT VEHICLE MILEAGE148243 MILES. THE PART WAS INSTALLED TO CORRECT A SIMILAR SITUATION INVOLVING A MUCH LESS SEVERE LEAK IN AN OLDER PART. THE FUEL LEAKAGE WITH THE OLDER PART DID NOT ESCAPE THE UPPER INTAKE MANIFOLD. AGE AND ORIGIN OF THE OLDER PART ARE NOT KNOWN. THE OLDER PART MAY HAVE BEEN ORIGINAL TO THE VEHICLE. GIVEN THE SIGNIFICANT QUANTITY OF FUEL DISCHARGED AND THE REPEATED NATURE OF THE FAILURE, I FEEL AN INVESTIGATION IS WARRANTED. *TR
No injuries · No fire · No crash
TL*THE CONTACT OWNS A 1996 CHEVROLET MONTE CARLO. WHILE DRIVING 25 MPH, THE TRANSMISSION GEARS SLIPPED OUT OF PLACE. A LOCAL MECHANIC ATTEMPTED TO REPLACE THE TRANSMISSION AND DID NOT HAVE ALL OF THE NECESSARY COMPONENTS TO DO SO. THE MANUFACTURER COULD NOT IDENTIFY OR LOCATE THE CORRECT TRANSMISSION FOR HIS MODEL. NO REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 80,000. THE CURRENT MILEAGE WAS 100,000.
No injuries · No fire · No crash
DT*: THE CONTACT STATED THE VEHICLE STALLED IMMEDIATELY UPON STARTING THE ENGINE. THE VEHICLE WAS RESTARTED BUT IMMEDIATELY STALLED AGAIN. THE ABS LIGHT ALSO ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR SERVICE.
No injuries · No fire · No crash