Chevrolet HHR Complaints (2006)

1,006 consumer complaints on file.

#10335329June 8, 2010
SERVICE BRAKES, HYDRAULIC
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED UPON INITIAL START, THE BRAKE PEDAL WOULD FALL FURTHER INTO THE FLOORBOARD THAN NORMAL. WHEN THE FAILURE WOULD OCCUR, THE ABS AND TRACTION WARNING LIGHT WOULD ILLUMINATE. THE DEALER ADVISED THE FAILURE WAS ATTRIBUTABLE TO THE STEERING AND REPLACED THE STEERING COLUMN BEARING. THE FAILURE PERSISTED AND THE VEHICLE WAS TAKEN TO A SECOND DEALER WHERE THE FRONT HUB BEARING ASSEMBLY WAS REPLACED. THE FAILURE SEEMED TO HAVE BEEN REPAIRED HOWEVER, THE WARNING LIGHTS WOULD CONTINUE TO ILLUMINATE INTERMITTENTLY. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 75,084 AND THE CURRENT MILEAGE WAS 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10334730June 5, 2010
STEERING
MY CAR, CHEVROLET HHR LS 2006, LOST POWER STEERING MORE THAN 10 TIMES AS OF DECEMBER OF 2009. I HAD MY CAR REPAIRED AT CHEVY DEALER 4 TIMES ALREADY FOR SAME PROBLEM. EACH TIME THEY FIXED THE PROBLEM, BUT IT CAME BACK AGAIN AND AGAIN, AND RECENTLY IT HAPPENED MORE OFTEN. I LEASED THIS BRAND NEW CAR IN 2006. AT THE END OF 3 YEARS LEASING, I BOUGHT IT IN 2009. I TOOK GOOD CARE OF IT ALL THE TIME. THE POWER STEERING FAILURE FIRST HAPPENED IN DEC. OF 2009. WHEN I WAS DRIVING ON THE ROAD, SUDDENLY IT WAS HARD TO MAKE A TURN, AND MY CAR WAS THROWN FORWARD EACH TIME WHEN I GOT OIL TO MOVE FORWARD. THE MESSAGE "POWER STEERING" POPPED UP ON THE DISPLAY PANEL. I HAD MY CAR TOWED TO CHEVY DEALER BECAUSE THE DRIVING WHEEL COULD NOT BE MOVED AT ALL AFTER RESTARTED THE CAR;HOWEVER, WHEN MY CAR WAS AT CHEVY DEALER, THE PROBLEM DISAPPEARED AND THEY COULD NOT FIND OTHER PROBLEM. THEN 2 MONTHS LATER, IT HAPPENED AGAIN AND DISAPPEARED AFTER HALF DAY. AFTER THIS REPEATED 3 OR 4 TIMES, MY CAR WAS TOWED THE 2ND TIME TO CHEVY DEALER ON FEB.26, 2010 BECAUSE THE DRIVING WHEEL COULD NOT TURNED. THIS TIME THEY FOUND SOMETHING AND FIXED IT. IN THE FOLLOWING 3 MONTHS, THIS PROBLEM WAS HAPPENED AND GONE AT LEAST 3 TIMES. WE WERE SCARED AND DID NOT DARE TO DRIVE FAR FROM HOME. ON MAY 24, 2010, MY HUSBAND GOT SAME PROBLEM WITH ENGINE LIGHT ON AND HE DROVE TO CHEVY DEALER IMMEDIATELY. THEY FIXED IT. ONLY ONE WEEK LATER, ON JUNE 2ND, THE CAR WAS TOWED THE 3RD TIME TO THE CHEVY DEALER FOR SAME PROBLEM. THEY REPLACED THE STEERING COLUMN AND STEERING MODULE. MY HUSBAND PICKED IT UP THE NEXT DAY, BUT JUST AFTER 2 MILES DRIVING, SAME PROBLEM OCCURRED, SO HE HAD TO DRIVE BACK TO THE DEALER RIGHT AWAY. THEY FIXED IT AND DROVE 50 MILES TO TEST IT AND IT WAS GOOD. YESTERDAY I DROVE IT HOME AND IT WAS GOOD TOO. BUT THIS MORNING, SAME PROBLEM HAPPENED AGAIN. SINCE IT IS SATURDAY, THE CHEVY STORE DOES NOT OPEN. WE CAN NOT GO ANYWHERE, EVEN GROCERY STORES. THIS REALLY IS A DISASTER, WE ARE SO SCARED! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10331097May 18, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION
2006 CHEVY HHR - AUTOMATIC TRANSMISSION DOES NOT LOCK INTO POSITION, CAN FREELY SLIP TRANSMISSION SHIFTER FROM PARK, REVERSE, NEUTRAL, DRIVE AND LOWER GEARS WITH LITTLE PRESSURE AND WITHOUT DEPRESSING THE SHIFTER LOCKING LATCH. GM HAS RECALLED 2010 MODELS WITH SIMILAR ISSUES BUT NONE OF THE PREVIOUS YEAR MODEL HHRS DEALERSHIP WANTS $150.00 TO TRY NEW BATTERY TO SEE IF IT WILL FIX THE PROBLEM. IF THIS SOLUTION DOES NOT WORK THEN THEY WANT ANOTHER $160.00 FOR NEW SHIFTER UNIT... LABOR FOR BOTH THESE ITEMS ARE NOT INCLUDED, JUST COST OF PARTS. I BELIEVE GM RECOGNIZES ISSUE: GM TSB #06-07-30-004F. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10330475May 14, 2010
STRUCTURE:BODY:DOOR, LATCHES/LOCKS/LINKAGES
2006 CHEVY HHR . THE DRIVERS SIDE DOOR INTERIOR DOOR HANDLE SNAPPED OFF IN MY HAND WHEN I TRIED TO OPEN THE DOOR, SMACKING INTO MY KNUCKLE AND ALMOST CAUSING MY HAND TO FLY BACK INTO MY FACE. THE DOOR MUST NOW BE OPENED BY ROLLING DOWN THE ELECTRIC WINDOW AND OPENING FROM THE OUTSIDE HANDLE. TWO DEALERS SO FAR REFUSE TO FIX THE ISSUE, TELLING ME THEY DON'T HAVE PARTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10330237May 13, 2010
STEERING
2006 CHEVROLET HHR - UNDER NORMAL OPERATING CONDITIONS, WHILE DRIVING AT LOW SPEEDS (15 - 25 MPH) AND TURNING TO THE RIGHT, CAR WILL "CHIME", "POWER STEERING" APPEARS ON THE CONTROL PANEL AND THE POWER STEERING WILL GO OUT MAKING VEHICLE VERY HARD TO DRIVE. ONCE CAR IS SHUT OFF AND RESTARTED, POWER STEERING BEGINS WORKING AGAIN. TOOK VEHICLE TO LOCAL MECHANIC, WAS TOLD THAT THE ELECTRONIC STEERING CONTROL UNIT AND ENTIRE STEERING COLUMN NEEDED TO BE REPLACED. COST WOULD BE $1,355. TAKING IT TO CHEVY DEALER TODAY FOR SECOND OPINION. PURCHASED CAR USED IN 2008 WITH 27,000 MILES ON IT. CURRENTLY HAS 77,000 MILES. HAPPENS APPROXIMATELY 4 TIMES PER WEEK FOR THE PAST MONTH. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10330320May 13, 2010
SERVICE BRAKES, HYDRAULIC
TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING AT 35 MPH, THE CONTACT STATED THAT THE BRAKES WOULD NOT ENGAGE, CAUSING THE STEERING WHEEL TO SHAKE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT CALLED THE AUTHORIZED DEALERSHIP AND WAS ADVISED THAT THEY WOULD REPAIR THE VEHICLE. THE CURRENT MILEAGE WAS APPROXIMATELY 67,000. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10329657May 10, 2010
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE ATTEMPTING TO OPEN THE DRIVERS DOOR, THE HANDLE WOULD NOT WORK AND THE DOOR WOULD NOT OPEN. THE VEHICLE WAS TAKEN TO THE DEALER FOR FURTHER INSPECTION. THE FAILURE AND CURRENT MILEAGES WERE 56,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10327928April 28, 2010
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE EXITING THE VEHICLE, THE CONTACT NOTICED THAT THE INSIDE DRIVER DOOR HANDLE WAS BROKEN. THE DEALER ADVISED HIM THAT HE WOULD HAVE TO PAY OUT OF POCKET FOR THE REPAIRS. THE VEHICLE HAD NOT BEEN REPAIRED WHEN THE COMPLAINT WAS FILED. THE CURRENT MILEAGE WAS APPROXIMATELY 37,300. THE FAILURE MILEAGE WAS APPROXIMATELY 37,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10326925April 21, 2010
LATCHES/LOCKS/LINKAGES
IF MY BATTERY DIES I CAN NOT GET IN THE CAR NO MATTER WHAT. MY CAR IS EQUIPPED WITH ONE LOCK ON THE DRIVER SIDE. BECAUSE THE BATTERY IS DEAD THE CAR WILL NOT ENGAGE THE ACTUATOR ON THE LOCK EVEN WITH KEY ENTRY. I HAVE TO CALL A LOCKSMITH TO GET IN THE CAR. IF I ACCIDENTALLY LOCKED A BABY IN THE CAR AND THE BATTERY WAS NOT WORKING I CANNOT GET IN THE CAR. KEY, REMOTE WHATEVER. I HAVE TO CALL A LOCKSMITH. IN MY CASE THE ACTUATOR STOPPED WORKING. SO REGARDLESS IF I HAVE A KEY OR REMOTE I CANNOT GET IN. IF THIS ACTUATOR FAILS ON THE DRIVERSIDE I CANNOT GET IN, BUT MY BABY MAY BEEN THE CAR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10326495April 19, 2010
STEERING
I WAS DRIVING MY 2006 HHR THAT HAS ELECTRONIC POWER STEERING (EPS) WHICH FAILED FOR NO APPARENT REASON ON 4-18-2010. THERE WERE NO EVENTS LEADING UP TO THIS OTHER THAN I WAS JUST GOING ABOUT 1MILE FROM WORK TO HOME. THERE WERE NO CRASHES OR INJURIES AS A RESULT. ON LOOKING INTO THE PROBLEM I FOUND THAT GM HAS A RECALL ON OTHER VEHICLES THAT HAS THE IDENTICAL ELECTRONIC POWER STEERING BUT THE HHR IS NOT ONE OF THEM ON THE RECALL LIST.. I DID FIND THE 60AMP FUSE BLOWN THAT PROTECTS THIS SYSTEM FROM OVERLOAD CONDITIONS. THERE WERE NO HARD TURNS AGAINST THE WHEEL STOPS EITHER RIGHT OR LEFT. THE FUSE JUST BLEW. I REPLACED THE FUSE JUST TODAY 4-19-2010 AND THUS FAR THE SYSTEM SEEMS TO BE OPERATING NORMALLY. AS TO WHY THE FUSE BLEW IN THE FIRST PLACE WELL THAT'S THE MILLION DOLLAR QUESTION! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10325950April 16, 2010
STEERING
WHILE DRIVING A TONE ALERT SOUNDING AND POWER STEERING WARNING CAME ACROSS DIGITAL DISPLAY, AT TIME LOST ALL POWER STEERING AND COULD HARDLY STEER AUTO TO THE SIDE OF ROADWAY. AFTER CALLING THE CHEVROLET GARAGE WAS TOLD THIS IS A COMMON PROBLEM WITH THE ELECTRICAL MOTOR AND SEVERAL OTHERS WERE RECALLED BUT NOT FOR THE HHR I HAVE. IF THE ELECTRICAL MOTORS ARE FAILING IN OTHER MODELS GM SHOULD REPLACE ALL THE ELECTRICAL POWER STEERING MOTORS TO AVOID ACCIDENTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10324887April 10, 2010
ELECTRICAL SYSTEM, LATCHES/LOCKS/LINKAGES
IGNITION KEY DOES NOT COME OUT OF THE STEERING COLUMN IT IS STUCK IN THE IGNITION ,CAR STARTS AND SHUTS OFF BUT THE KEY CANNOT BE REMOVED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10324731April 9, 2010
STEERING
TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THE POWER STEERING WOULD FAIL WHENEVER THE VEHICLE WAS IN OPERATION AND WOULD RESET ITSELF WITHIN A MILE. THE DEALER ADVISED PERFORMING A DIAGNOSTIC TO DETERMINE THE CAUSE OF FAILURE. THE MANUFACTURER ALSO ADVISED HAVING A DIAGNOSTIC PERFORMED, AT THE OWNERS EXPENSE, BEFORE THEY WOULD PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS 61,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10323699April 4, 2010
STEERING
POWER STEERING MOTOR FAILURE. THIS HAPPENS UNDER NORMAL DRIVING WITH NO WARNING WHAT SO EVER. IT DOES NOT MATTER IF YOU ARE ON THE FREEWAY OR AROUND TOWN, IT HAS HAPPENED DURING BOTH. THE VEHICLE DOES FLASH POWER STEERING ON THE INFORMATION CENTER. THIS IS THE FOURTH TIME THIS HAS HAPPENED IN THE PAST 6 WEEKS AND I AM CONCERNED ABOUT REPLACING DUE TO HAVING THE SAME PROBLEM WITH THE REPLACEMENT PART. MY WIFE IS THE PRIMARY DRIVER OF THE VEHICLE AND HAS STATED THAT IT IS VERY HARD TO CONTROL. TODAY SHE WAS DRIVING HOME WHEN THE FAILURE OCCURRED. SHE WAS ALMOST HOME AND THE STEERING BEGAN TO WORK PROPERLY WHILE SHE WAS IN THE MIDDLE OF A RIGHT HAND CURVE. SHE HAD AMPLE AMOUNT OF PRESSURE ON THE STEERING WHEEL AT THAT TIME TO KEEP THE CAR IN THE ROAD (AT A REDUCED AND SAFE SPEED) AND THEN SUDDENLY SHE HAD POWER STEERING AGAIN. SHE RAN INTO THE DITCH BUT NO DAMAGE WAS DONE THAT I CAN FIND. BOTH HER AND MY CHILDREN USE THIS CAR DAILY AND WITH ITS CURRENT PROBLEM, I DON'T FEEL IT'S SAFE DRIVE OR SALE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10323586April 3, 2010
ELECTRICAL SYSTEM
IGNITION WILL NOT TURN TO LOCK AND KEY CANNOT BE REMOVED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10323072March 31, 2010
SUSPENSION:FRONT
TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING APPROXIMATELY 65 MPH THE VEHICLE BEGAN TO SHAKE. THE FAILURE OCCURRED WHENEVER THE VEHICLE WAS IN OPERATION. THE CONTACT EXPERIENCED THE IDENTICAL FAILURE ON FORTY SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN STATED THAT BOTH FRONT STRUTS REQUIRED REPLACEMENT. THE VEHICLE WAS REPAIRED FOR THE MALFUNCTION. THE FAILURE MILEAGE WAS 55,000. THE CURRENT MILEAGE WAS 87,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10322537March 28, 2010
STEERING
2006 CHEVY HHR POWER STEERING IS FAILING. (STUTTERS ON AND OFF) *CN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10321420March 22, 2010
POWER TRAIN:AUTOMATIC TRANSMISSION, UNKNOWN OR OTHER
I OWN A 2006 CHEVY HHR, AND WITHIN THE PAST TWO WEEKS HAVE EXPERIENCED A PROBLEM (WHICH APPARENTLY, AFTER LOOKING ONLINE, SEVERAL OTHER OWNERS HAVE EXPERIENCED). WHEN I PUT MY CAR IN PARK, AND GO TO TURN OFF THE IGNITION, IT WON'T LET ME TAKE OUT MY KEY, AND MY STEERING WHEEL WON'T LOCK. THIS HAPPENS EVERYTHIME THAT I TRY TO TURN OFF MY CAR NOW, WHICH IS AT LEAST ABOUT TEN TIMES DAILY. I HAVE TO "SLAM" IT INTO PARK TO GET THE KEY OUT. I AM NOT SURE THOUGH THAT WHEN THIS IS DONE IF MY CAR IS TRULY IN PARK. I WENT TO MY CAR REPAIRMAN, WHO SAID THAT THIS DEFINITELY NEEDS TO BE LOOKED AT BECAUSE IF I CONTINUE TO "SLAM" IT IN PARK, I COULD EVENTUALLY BREAK THE SHIFTER- WHICH IN MY MIND COULD DEFINITELY CAUSE AN ACCIDENT/ OR PROPERTY DAMAGE. I AM TAKING MY CAR IN ON WEDNESDAY FOR THIS PURPOSE, NOT SURE YET WHAT THE COST WILL BE, BUT I STRONGLY BELIEVE THAT THIS PROBLEM SHOULD BE LOOKED AT BY DOT. *DT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10320973March 19, 2010
STEERING, ELECTRICAL SYSTEM
TO WHOM IT MAY CONCERN, I RECENTLY HAD REPAIR WORK DONE ON MY WIFE'S 2006 HHR LT2. THE PROBLEM WE WERE HAVING WAS THAT SHE WOULD RANDOMLY LOSE POWER STEERING WITH A WARNING CHIME AND A NOTIFICATION ON THE INSTRUMENT PANEL. THIS WOULD BE TEMPORARILY RESOLVED BY RESTARTING THE VEHICLE. I WASTED LITTLE TIME AND HAD IT TESTED AT CLASSIC CHEVROLET IN SUGAR LAND,TX. THEY SOON DISCOVERED THAT THE POWER STEERING MOTOR WAS FAULTY. I HAD THEM REPLACE IT. NOW I'VE BEEN A LIFELONG GM CUSTOMER AND I WAS VERY DISAPPOINTED WITH THIS EXPENSE, NOT ONLY WAS IT A FAILURE UNASSOCIATED TO NEGLECT BUT IT WAS ALSO A VERY DANGEROUS PROBLEM. THIS PROBLEM IS ALSO HIGHLY DOCUMENTED ON THE WEB BY MANY OTHER HHR OWNERS. AFTER GM ANNOUNCED THE RECALL OF 1.3MIL VEHICLES WITH THIS PROBLEM. THE HHR WAS NOT LISTED YET BUT THE CHEVY COBALT AND PONTIAC G5 WERE. THE HHR SHARES THE SAME POWER STEERING MOTOR AS THE COBALT AND G5. GM PART # 20763801. JTEKT NORTH AMERICA IS THE PRODUCER OF THIS MOTOR. FROM WHAT I DISCOVERED ON THE INTERNET, GM HAS FILED A LAWSUIT AGAINST JTEKT IN RESPONSE TO THIS ISSUE. IT IS STILL UNCLEAR TO ME HOW GM HAS NOT INCLUDED THIS MODEL IN THERE RECALL. I HAVE RECENTLY BEEN DENIED REIMBURSEMENT BY CHEVROLET FOR MY EXPENSES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10320658March 18, 2010
POWER TRAIN:DRIVELINE
2006 HHR KEY STICKS IN IGNITION. BUTTON THAT IGNITES SHIFTER BROKEN AND STICKS IN PLACE CAUSING THE SHIFTER TO BE EASILY ENGAGED AT ANY TIME. CAR IS AT 70,822 MILES. CAR DEALER STATES IT IS NOT COVERED BY TRANSFERABLE MANUFACTURERS 5 YR/100,000 POWERTRAIN WARRANTY. CAR WAS PURCHASED USED 05/2007. COST TO COVER REPLACEMENT IS OVER 300.00. IF OPERATORS DO NOT GET THIS REPLACED I AM SURE IT WILL CAUSE PROPERTY DEATH, INJURY, AND ACCIDENTS AS THE SHIFTER CAN BE ENGAGED BY A SLIGHT BUMP TO PARK, REVERSE, NEUTRAL, ETC. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet HHR