Chevrolet · Model Report
Showing safety data for the 2001 model year only.
RIFLED AIR CONDITIONING (RAC) IS RECALLING 6 MY 2001 CHEVROLET EXPRESS PRIVATE TRANSPORT, MY 2005 THOMAS BUILT FS65, MY 2006-2007 MONITOUR BUS, AND MY 2007 C-2 SCHOOL BUS VEHICLES BUILT ON FREIGHTLINER, AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
RIFLED AIR CONDITIONING (RAC) IS RECALLING 6 MY 2001 CHEVROLET EXPRESS PRIVATE TRANSPORT, MY 2005 THOMAS BUILT FS65, MY 2006-2007 MONITOUR BUS, AND MY 2007 C-2 SCHOOL BUS VEHICLES BUILT ON FREIGHTLINER, AND GM CHASSIS AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403,"PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.
Vehicle shuts down during operation. I just saw there is a recall on your site saying same problem but mine didnt qualify. I have burned wires in harness to instrument panel. I found two wires at harness where code reader plugs into . O was able to ground them but now a couple months later same problem. I found burnt wires in harness and I cannot access to evaluate or replace. I've completed repairs myself, I am poor and dont know any honest affordable mechanics as I am capable of most reasonable repairs. I think my van falls under overheating panel warranty as described by this website. I still have 2 years of payments on van
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2001 CHEVROLET EXPRESS 3500 EQUIPPED WITH DEXTERO DHT2 TIRES, SIZE: LT245/75R/16 (NA). WHILE TRAVELING AT HIGHWAY SPEEDS, THE REAR PASSENGER TIRE EXPERIENCED A BLOW OUT. THE VEHICLE WAS TOWED TO AMERICAN CUSTOM TIRE INC (1300 W MAIN ST, QUARTZSITE, AZ) WHERE IT WAS DIAGNOSED THAT THE INTERNAL SIDEWALL FAILED. THE TIRE WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND DID NOT ASSIST. THE VIN AND VEHICLE FAILURE MILEAGE WERE UNKNOWN. THE TIRE FAILURE MILEAGE WAS 1,500.
No injuries · No fire · No crash
THE "PCM"-PUMP CONTROL MODULE LOCATED ON THE INJECTION PUMP THAT IS IN CHARGE OF OPERATING AND COORDINATING PUMP OPERATIONS FAILS AFTER 30,000 TO 40,000 MILES. THIS CAUSES THE VEHICLE TO STOP RUNNING--NO BRAKES OR STEERING SIMILAR TO IGNITION SWITCH PROBLEM IN OTHER VEHICLES. GM LIKES TO GET 1,400 TO FIX, AFTER THE TOW. THANKS [XXX] A BETTER FIX NEEDS TO BE MADE HERE RATHER THAN INSTALLING ANOTHER DEFECTIVE PART. THIS PROBLEM HAPPENS IN ALL THE 6.5 DIESEL MOTORS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
No injuries · No fire · No crash
THE REAR MAIN SEAL, FRONT HARMONIC SEAL AND POWER STEERING PUMP SHAFT SEAL ARE LEAKING. THE VEHICLE HAS 96,000 MILES ON IT. THIS SHOULD NOT BE. I TOOK IT TO A SHOP LAST WEEK TO HAVE PROBLEM FIXED. NEED HELP VERY EXPENSIVE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
No injuries · No fire · No crash
DEFECTIVE PAINT. THE PAINT ON FRONT OF VEHICLE AND ROOF CHIPPING AND RUSTING. I HAVE OBSERVED MANY OTHER CHEVROLET VANS WITH THE SAME ISSUE. HAVE NOT NOTICED THE SAME ISSUE WITH OTHER VANS MADE BY OTHER MANUFACTURERS.
No injuries · No fire · No crash