BMW Z3 Complaints

253 consumer complaints on file.

#10622505August 15, 2014
SEATS
DRIVER SEAT BECAME LOOSE AND WOULD SLIDE FORWARD WHEN BRAKES WERE APPLIED AND BACKWARD ON ACCELERATION. THE MOVEMENT WAS ABRUPT ENOUGH TO BE DISCONCERTING, ESPECIALLY IN AN EMERGENCY MANEUVER. BMW DEALERSHIP ADVISED IT WAS EXPENSIVE TO REPAIR AND NOT DANGEROUS BECAUSE THE SEAT WAS NOT AT RISK OF FULLY DETACHING. I HAVE LIVED WITH IT, BUT IT IS A POTENTIAL CAUSE OF ACCIDENTS AND IT FEELS UNSAFE - AS IF THE SEAT MIGHT COME LOOSE. IT IS VERY DISTRACTING TO ANY DRIVER WHO IS NOT ACCUSTOMED TO IT AND EVEN TO ME - A LIKELY CAUSE OF DRIVER ERROR OR LOSS OF CONTROL DURING ABRUPT MANEUVERS. RECENTLY AS I LOOKED ON THE INTERNET FOR SOLUTIONS I FOUND THAT THIS IS AN EXTREMELY COMMON PROBLEM WITH 1999 M ROADSTER VERSION OF THE Z3. I THINK IT IS SUFFICIENT TO MERIT RECALL, BUT THAT IS WHAT YOU FOLKS DO FOR A LIVING... I HOPE YOU WILL LOOK INTO IT CAREFULLY. PS: THE DATE THAT I ENTERED IS A VERY ROUGH ESTIMATE. I DO NOT RECALL PRECISELY WHEN THE PROBLEM FIRST OCCURRED. THANK YOU *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10578088April 7, 2014
ENGINE
MY 1999 BMW ROADSTER ENGINE BEGAN TORQUING FROM IDLE TO VERY FAST WITHOUT ANY WARNING. I HAVE TAKEN IT TO MECHANICS AND THEY DO NOT KNOW WHAT WOULD CAUSE THIS. IT HAS HAPPENED MULTIPLE TIMES SINCE THEN. IT WILL STOP THIS WHEN I SHUT OFF ENGINE AND TURN IT BACK ON. I FEAR THIS COULD CAUSE A SERIOUS ACCIDENT. PLEASE ADVISE ON WHAT TO DO. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10567172March 6, 2014
TIRES, EXTERIOR LIGHTING, SEAT BELTS, SEATS, VISIBILITY:GLASS, SIDE/REAR, ENGINE AND ENGINE COOLING, STRUCTURE, EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
2001 BMW Z3. CONSUMER WRITES IN REGARDS TO SEVERAL VEHICLE PROBLEMS AND UNSATISFACTORY CUSTOMER SERVICE FROM DEALERSHIP. *SMD THE CONSUMER STATED HE PURCHASED THE VEHICLE ON EBAY. WHEN THE VEHICLE WAS ARRIVED AND THEN EVALUATED, HE WAS INFORMED THE TIRES WERE OVER 10 YEARS OLD, SEVERAL LIGHTS WERE INOPERABLE, BOTH FOG LIGHT AND LEFT PARKING AND TURNING LIGHTS DID NOT WORK. THERE WAS A CRACK IN THE DASHBOARD, THE SEAT BELT GUIDE ON THE DRIVER'S SEAT WAS BROKEN, THE SEATS SLID FORWARD WHEN STOPPING WHICH CAUSED HIM, TO UNEXPECTEDLY STEP ON THE ACCELERATOR THE REAR WINDOW WAS SCRATCHED AND FADED TO ZERO VISIBILITY, THE MAIN SPEAKER WAS BLOWN. IN ADDITION, A MANIFOLD HOSE REQUIRED REPLACEMENT DUE TO A LEAK, THE KEYS HAD TO BE REPROGRAMMED TO UNLOCK THE DOORS AND TRUNK. *JB THE DASHBOARD WAS CRACKED, THE REAR BRAKES FAILED UPDATED 04/15/15*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10562829February 4, 2014
SEATS
THE SEAT TRACKS OF BOTH THE DRIVER AND PASSENGER SIDE OF THE VEHICLE ALLOWED THE SEATS TO MOVE AT LEAST 10MM FORWARD AND REARWARD UNDER BRAKING AND ACCELERATION. THIS MOVEMENT CAUSES A PARTIAL LOSS OF CONTROL OF THE VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10544980September 23, 2013
AIR BAGS
TL* THE CONTACT OWNS A 2000 BMW Z3 ROADSTER. THE CONTACT STATED THAT WHILE TRAVELING 55 MPH, THE FRONT DRIVER'S SIDE AIR BAG ERRONEOUSLY DEPLOYED. THE CONTACT SUSTAINED BURNS, BRUISING, AND HAIR LOSS AS A RESULT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 82,754.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10524931July 15, 2013
AIR BAGS, SEAT BELTS
TL* THE CONTACT OWNS A 1996 BMW Z3. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STATED THAT THE SEAT BELT COULD NOT BE UNLATCHED WHEN THE DRIVER WOULD DEPRESS OR ADD ANY PRESSURE TO THE BRAKE PEDAL. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE AIR BAG SENSOR AND THE SEAT BELT ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10519677June 13, 2013
LATCHES/LOCKS/LINKAGES
DOORLOCK CYLINDER ASSEMBLY INSIDE DOOR BREAKS, CAUSING LOCK CYLINDER NOT TO BE HELD IN PLACE & WHEN KEY IS INSERTED IN LOCK CYLINDER THE WHOLE LOCK CYLINDER JUST TURNS WITH THE KEY. MAKING IT IMPOSSIBLE TO LOCK OR UNLOCK THE DOOR. I'M EXPERIENCING THIS PROBLEM WITH PASSENGER DOOR & THE DRIVERS DOOR IS STARTING TO ACT SLOPPY ALSO. THIS IS A PROBLEM EXPERIENCED BY MANY BMW OWNERS OF DIFFERENT MODELS. BESIDES BEING POORLY DESIGNED IT'S VERY EXPENSIVE TO REPAIR; APPROX. $500 TO $800 PER LOCK...NOTE "THE REPAIR DOES NOT REQUIRE NEW LOCK CYLINDERS, JUST THE HARDWARE THAT HOLD THE CYLINDER INPLACE, BUT THIS HARDWARE IS DIFFICULT TO FIND & THE BMW DEALER IS USUALLY THE ONLY PLACE TO GET IT AT A HIGH COST. I HAVE SEEN DOOR LOCK CYLINDER ASSEMBLY HARDWARE ONLINE FOR UNDER $20.00; BUT BMW CHARGES $100 TO $200." BMW PRIDES ITSELF ON QUALITY. I THINK THEY SHOULD STAND BEHIND THEIR MOUTH! I'VE HAD CARS OVER 40 YEARS OLD. THEY'VE HAD A LOT OF PROBLEMS, BUT DOOR LOCK CYLINDER ASSEMBLIES, NO & IT WOULDN'T HAVE BEEN THIS EXPENSIVE TO FIX! THANK YOU *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10505083March 28, 2013
LATCHES/LOCKS/LINKAGES:DOORS:LATCH, LATCHES/LOCKS/LINKAGES
THE CONSUMER STATED BARREL CYLINDER IN THE PASSENGER RIGHT SIDE DOOR JUST TURNS WHEN THE KEY IS INSERTED AND TURNS AROUND AND DOES NOT ENGAGE. *BF
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10491929January 9, 2013
AIR BAGS
DRIVER SIDE (DOOR) AIRBAG DEPLOYED WHILE DRIVING ON HIGHWAY. IMPACT CAUSED ME TO SWERVE INTO ONCOMING TRAFFIC LANES. *TR
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10477242September 27, 2012
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
I HAVE SUBFRAME DAMAGE, IN THE TRUNK IT'S MOST VISIBLE WITH THE CARPET OUT, I CAN SEE THE SPOT WELDS HAVE POPPED, CRACKED, BROKE FREE, WHATEVER. THUS CAN CAUSE A MASSIVE RISK TO AS IF ANYMORE POP THE DIFFERENTIAL COULD POSSIBLE TEAR NEXT THE BRACKET THAT HOLDS IT UP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10468504July 31, 2012
STRUCTURE:BODY, POWER TRAIN, SUSPENSION
I PURCHASED CAR 6-4-12 AFTER DRIVING THE CAR I NOTICED A SQUEAK AND A CLUNKING NOISE COMING FROM TRUNK, AFTER REMOVING TRUNK LINING THE SPOT WELDS [4] WERE BROKE LOOSE IN TRUNK FLOOR FROM CROSS MEMBER WHERE REAR END IS SUPPORTED.. I TOOK THE CAR TO DEALER WHERE CAR WAS BOUGHT HOPING THE DEALER HAD A SERVICE BULLETIN ON CAR I WAS TOLD THEY WOULD REPAIR CAR AT MY EXPENSE I ASKED IF THAT WAS AN ENGINEERED REPAIR OR JUST A TEMPORARY REPAIR THERE RESPONSE WAS ITS THE FIRST TIME IT HAD EVER HAPPENED.. AFTER SEARCHING THE INTERNET I FOUND IT WAS NOT THE FIRST TIME WELDS HAD COME LOOSE IN THE SUB FRAME AND IF NOT REPAIRED WOULD CAUSE MAJOR DAMAGE AND POSSIBLE CONTROL ISSUES. THIS CAR IS IN EXCELLENT SHAPE NO RUST ISSUES AT ALL WAS ALWAYS GARAGED NEVER DRIVEN IN WINTER I BELIEVE THE SUBFRAME AND REAR AXLE MOUNTING IS UNDER DESIGNED FOR THIS CAR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10467326July 19, 2012
ENGINE AND ENGINE COOLING
2008 BMW X3. CONSUMER STATES DEFECTIVE MOTOR MOUNT BOLTS THAT HAVE FAILED RESULTING IN A STRESS FAILURE OF THE COOLING SYSTEM *TGW
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10463048June 25, 2012
AIR BAGS
TRAVELING EASTBOUND ON HIGHWAY 101 IN AGOURA HILLS, CA A SMALL ROCK APPEARING IN MY LANE MADE A CLANKING SOUND WITH THE UNDERSIDE OF MY VEHICLE AT WHICH TIME THE PASSENGER SIDE AIRBAG DEPLOYED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10462350June 19, 2012
POWER TRAIN, ELECTRICAL SYSTEM
I AM DRIVING AS NORMAL AND THEN THE CAR BEGINS TO HAVE PROBLEMS SHIFTING AND THE TRANSMISSION INDICATOR LIGHT COMES ON. THE OWNERS MANUAL TELL YOU TO PULL OVER AND SHIFT THE CAR INTO PARK AND THEN APPLY THE PARKING BRAKE AND TURN THE CAR OFF AND THEN BACK ON. IT SEEMS TO TEMPORARILY CORRECT THE PROBLEM BUT IT STILL OCCURS ON DAYS WHEN THE AIR TEMP. IS HIGH. I HAVE HAD THE CAR ON THE DIAGNOSTIC A NUMBER OF TIMES WITH NO CURE. AS FAR AS I KNOW THERE ARE NO RECALLS ON THE TRANSMISSION OR ECU. BUT THIS COULD BE A MAJOR PROBLEM AT HIGH SPEEDS ON THE HIGHWAY OR IN CITY TRAFFIC IF THE CAR STALLS OR LOCKS UP BMW 2001 Z3 2.5I (STEPTRONIC SHIFTING) *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10459349May 23, 2012
SUSPENSION
I AM THE ORIGINAL OWNER OF THIS AUTO. I NOTICED A NOISE COMING FROM THE REAR OF THE VEHICLE ON DECELERATION. UPON INSPECTING THE CAR, I FOUND THAT THE REAR SUB FRAME WAS ALMOST BROKER IN HALF. THIS IS THE PART THE HOLDS THE ENTIRE REAR SUSPENSION FOR THE CAR. FROM RESEARCH I'M FINDING OUT THAT THIS IS A COMMON PROBLEM WITH Z-3 BMW'S IN WHAT APPEARS TO BE A FLAW IN THEIR ENGINEERING. I WAS VERY SHOCKED TO SEE THE DAMAGE AND THAT IF I WOULD HAVE CONTINUED TO DRIVE THE CAR, VERY SHORTLY THE PART WOULD HAVE FAILED, WIPING OUT THE WHOLE REAR SUSPENSION. I AM AMAZED THAT THIS WAS NOT A RECALL ITEM OR THAT I WAS NOT EVEN NOTIFIED THAT THIS WAS A POTENTIAL ISSUE SO THAT I COULD MONITOR THIS AND CATCH IT BEFORE A MAJOR FAILURE. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10436004November 16, 2011
POWER TRAIN:MANUAL TRANSMISSION, STRUCTURE:BODY
ON 24JUN2011, I SWERVED FROM A PARALLEL LANE TO AVOID BEING SIDESWIPED. NO CONTACT WAS MADE BETWEEN VEHICLES. HOWEVER, I NOTICED A NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHILE HAS A MANUAL TRANSMISSION. I TOOK THE VEHICLE TO AN AUTO BODY REPAIR SHOP. AFTER EXAMINING THE VEHICLE THEY TOLD ME THAT: THE FLANGE/BRACKET THAT HELD THE DIFFERENTIAL IN PLACE HAD A COMPLETE HAIR-LINE FRACTURE; AND, THAT A SUBSTANTIAL NUMBER OF SPOT WELDS HOLDING THE BODY ON TO THE FRAME HAD FAILED. I MADE CONTACT WITH THE LOCAL BMW DEALERSHIP MCGRATH BMW, OCATED IN WESTMONT, IL AND TOLD THEM OF THE INCIDENT. THEY STATED THAT THEY DID NOT UNDERTAKE BODY REPAIRS AND DIRECTED ME TO A FIRM WHICH DID ALL TYPES OF BODY AND STRUCTURAL REPAIRS AND WAS ACCREDITED BY BMW. I WAS GIVEN AN ESTIMATE FOR THE REPAIR OF BETWEEN $5,000-$6,000, AND WAS TOLD THAT THERE WAS NO PROGRAM OFFERED BY BMW TO SHARE IN THE COST OF THE FLANGE/BRACKET AND BODY REPAIR. I WENT BACK TO MY LOCAL BODY SHOP AND TOLD THEM TO ESTIMATE THE COST AND I ALSO REPORTED THE PROBLEM TO MY AUTO INSURANCE (STATE FARM). AN ADJUSTER FROM STATE FARM REVIEWED THE FAILURES AND STATED THAT THE CONDITION WAS ONE OF A PROBLEM IN MANUFACTURE AND NOT COVERED BY MY AUTO INSURANCE. MY BODY SHOP THEN GAVE ME AN ESTIMATE OF A NOT TO EXCEED FIGURE OF APPROXIMATELY $2,500. I TOLD THEM TO UNDERTAKE THE REPAIR. THE FLANGE/BRACKET HAS BEEN REPLACED AND REINFORCED AND THE BODY AND FRAME HAVE SINCE BEEN REWELDED AT A TOTAL COST TO ME OF $1600. ADDITIONALLY, I SPENT AN ADDITIONAL $100 FOR A ALIGNMENT (FIRESTONE OF COUNTRYSIDE, IL) THE LOCAL BODY SHOP IS DOUGLAS AUTO BODY, 4015 EBERLY AVENUE, BROOKFIELD, IL (708) 485-7774 - THEY ARE A BODY AND STRUCTURAL REPAIR SHOP APPROVED BY STATE FARM INSURANCE. THIS VEHICLE HAS BEEN USED BY ME AS A STREET VEHICLE AND NOT FOR RACING OR TRACK USE OF ANY KIND. THE FAILURES SEEM TO BE A MFG. DESIGN FLAW. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10433570October 30, 2011
STRUCTURE:BODY, SUSPENSION
I HEARD A CREAKING FROM THE REAR OF MY CAR, I PUT IT ON JACKS TO CHECK IT OUT. TO MY SURPRISE I FOUND EXTENSIVE DAMAGE TO THE FLOOR PAN MAINLY AROUND THE DIFFERENTIAL MOUNT. THE CAR IS UNDRIVABLE., BUT YET BMW WILL NOT TAKE FULL RESPONSIBILITY FOR THE MATTER. I SEE IT AS A SAFETY ISSUE AS IF I DID NOT CHECK IT AND CONTINUED TO DRIVE THE CRACKS AND TEARS IN THE BODY METAL THAT EXIST COULD HAVE CONTINUED EVEN FURTHER AND LED TO AN ACCIDENT OR WORSE. I WAS ESTIMATED AT A WHOPPING 5200 DOLLARS WHICH BMW SAID THEY WOULD ONLY PAY 3000 OF. I BELIEVE IT IS A MANUFACTURER DEFECT, SO IT SHOULD BE PAID IN FULLY BY THE COMPANY, BUT THEY WILL NOT STAND UP THE THEIR FAULT. I HAVE AT THIS TIME NO CHOICE BUT TO DRIVE THE VEHICLE IN ITS CURRENT STATE, THERE ARE CASES OF SIMILAR SUBFRAME PROBLEMS POPPING UP ALL OVER FORUMS ONLINE. ENTHUSIASTS OF THE Z3 WILL RECOGNIZE THIS ISSUE IF THEY TEDIOUSLY AND CAREFULLY INSPECT THEIR CARS, HOWEVER THE AVERAGE PERSON WHO JUST BUYS THEIR CAR AND DRIVES IT AROUND HAS ABSOLUTELY NO IDEA OF THE PROBLEM AT HAND AND THE POSSIBLE SAFETY ISSUE THAT IT MAY LEAD UP TO IF NOT TAKEN CARE OF PROPERLY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10430357October 16, 2011
POWER TRAIN
AT 86K MILES ON MY 1998 BMW Z3, THE THIN SHEET METAL BRACKET HOLDING THE REAR DIFFERENTIAL UP IN PLACE WELDED TO THE CHASSIS SPLIT IN HALF CAUSING THE REAR END TO HANG. THIS IS THE SECOND TIME IT HAS HAPPENED, ALSO AT 93,500 MILES, JUST 8 MONTHS LATER. THE CLUTCH IS STILL ORIGINAL AND THE CAR HAS NEVER BEEN ABUSED, OR RACED. I ALWAYS BABY THE CAR BECAUSE GAS IS SO EXPENSIVE, AND THIS SEEMS TO BE A PROBLEM WITH ALOT OF OTHER Z3'S THAT I HAVE SEEN ONLINE. THIS IS CLEARLY A MANUFACTURING FLAW. BMW CLAIMS THE CAR MUST HAVE HAD SOME REAR END IMPACT, EVEN THOUGH THIS IS CLEARLY NOT THE CASE. I WOULD LIKE TO SEE THEM REPLACE THIS PART WITH THICKER, OR STRONGER METAL AS IT CAN BE A VERY SERIOUS PROBLEM IF THE DIFFERENTIAL FALLS OUT AT HIGH SPEEDS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10422490August 29, 2011
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
TL* THE CONTACT OWNS A 1996 BMW Z3. THE CONTACT STATED THAT THERE WAS AN INCREASE IN EXHAUST FUMES AND A RATTLING NOISE WAS COMING FROM THE CATALIC CONVERTER. THE CONTACT ALSO STATED THAT EROSION IN THE MONOLITH BECAME LOOSE IN THE HOUSING. THE CHECK ENGINE LIGHT WOULD ALSO ILLUMINATE ON THE INSTRUMENT PANEL AT ANY TIME. THE DEALER AND MANUFACTURER DENIED ANY ASSISTANCE WITH REPAIRS OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 94,000 AND THE CURRENT MILEAGE WAS 97,000. UPDATED 09/21/11 *BF UPDATED 10/07/11
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10415652July 20, 2011
POWER TRAIN, SUSPENSION
I PURCHASED A USED 1998 BMW Z3 WITH THE 1.9 LITER ENGINE ON 10/14/2010 WITH 90564 MILES. IN MID NOVEMBER I TOOK THE CAR TO A MECHANIC FOR A CHECK ENGINE LIGHT WHICH WAS SERVICED. THE MECHANIC INFORMS ME THERE IS A PROBLEM WITH Z3'S ALONG WITH OTHER MODEL BMW'S WITH THE WAY THE REAR DIFFERENTIAL IS ATTACHED. THE PROBLEM SEEMS TO BE FLEXING IN THE SHEET METAL WHERE THE DIFFERENTIAL IS ATTACHED CAUSING FAILURE OF THE SPOT WELDS HOLDING THE WHOLE ASSEMBLY TOGETHER. HE SHOWED ME IN MY TRUNK WHERE TWO OF THE SIX SPOT WELDS HAD BROKEN. I HAVE RESEARCHED THIS ON THE DIFFERENT BMW FORUMS AND BMW IS CLAIMING THIS FAILURE IS DUE TO PERFORMANCE MODIFICATIONS OR CARS THAT HAVE BEEN TAKEN TO A TRACK OR AUTOCROSS. I DO NOT KNOW THE PREVIOUS HISTORY OF MY CAR BUT IT APPEARED TO HAVE BEEN TAKEN CARE OF. ON 6/30/2011 I HAD THE CAR IN THE SHOP AGAIN FOR SERVICE WORK AND MY MECHANIC FOUND TWO MORE BROKEN WELDS AND SOME SEPARATION IN THE REAR CHASSIS. THIS CAR IS PRETTY MUCH UN-DRIVABLE NOW DUE TO THIS CONDITION. I UNDERSTAND THERE IS A COUPLE OF COMPANIES THAT MAKE A REPAIR KIT FOR THIS THAT WILL STRENGTHEN THE TRUNK AREA AND PREVENT THIS FROM HAPPENING AGAIN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to BMW Z3