BMW 335i Complaints (2007)

288 consumer complaints on file.

#10409791June 27, 2011
ELECTRICAL SYSTEM
COMPONENT: LOCKING SYSTEM DRIVER-SIDE DOOR LOCK FAILED TO UNLOCK WHEN USING THE REMOTE ON THE KEY. REPLACED BLOWN FUSE. A DAY LATER SAME PROBLEM SURFACED, ONLY THIS TIME ALL 4 DOORS ARE NOT UNLOCKING (FIRST PUSH OF THE BUTTON ON THE REMOTE SHOULD UNLOCK DRIVER DOOR ONLY; SECOND PUSH OF BUTTON UNLOCKS THE OTHER 3 PASSENGER DOORS. REPLACED TWO BLOWN FUSES (#56 AND #57). PROBLEM IS RESOLVED, BUT ONLY FOR A DAY OR TWO. LONG-TERM FIX IS TO REPLACE DOOR LOCK ACTUATORS ON ALL FOUR DOORS ACCORDING TO BMW'S OWN SERVICE BULLETIN. THE SAFETY ISSUE IS THAT THE DOORS ARE SUPPOSED TO OPEN MANUALLY FROM THE INSIDE WHEN THE ELECTRICAL SYSTEM IS UNABLE TO UNLOCK THEM. IN MY CASE, I WAS ONLY ABLE TO MANUALLY OPEN THE DRIVER-SIDE DOOR BY PULLING THE HANDLE ONCE TO UNLOCK, AND A SECOND TIME TO OPEN. THIS PROCEDURE DID NOT WORK ON ANY OTHER DOOR. I HAVE PURCHASED AN EMERGENCY HAMMER TO BREAK THE WINDOW FROM THE INSIDE IN CASE THIS HAPPENS AFTER AN ACCIDENT. ADDITIONAL INFO: THE GAS DOOR ALSO FAILS TO OPEN AS A RESULT OF THIS ISSUE. ONE HAS TO RELEASE THE GAS DOOR MANUALLY FROM INSIDE THE TRUNK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10396915April 20, 2011
LATCHES/LOCKS/LINKAGES
ELECTRIC DOOR LOCKS FAILED ON ALL FOUR DOORS. COULD NOT UNLOCK ANY PASSENGER DOOR UNTIL FUSE INSIDE GLOVE BOX WAS REPLACED. DRIVER COULD EXIT THE DRIVERS DOOR BY MANUALLY LIFTING DOOR HANDLE. NO APPARENT MEANS TO OPEN ANY PASSENGER DOORS (OR GAS DOOR COVER) UNTIL THE FUSE WAS REPLACED. HAD THERE HAVE BEEN A FRONT SEAT PASSENGER, THAT OCCUPANT WOULD HAVE TO CLIMB OVER CONSOLE AND EXIT THE DRIVERS DOOR TO EVEN ALLOW ACCESS TO THE FUSE PANEL. THIS IS THE SECOND OCCURRENCE IN THIS VEHICLE AND BASED ON MY ONLINE RESEARCH, IT IS A COMMON PROBLEM WITH THIS MODEL VEHICLE. IF THIS PROBLEM WERE TO OCCUR AND THEN AN ACCIDENT HAPPENED, IT WOULD BE A SERIOUS SAFETY ISSUE BECAUSE NONE OF THE PASSENGERS COULD EXIT RAPIDLY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10393832March 31, 2011
FUEL SYSTEM, GASOLINE
TL*THE CONTACT OWNS A 2007 BMW 335I. WHILE DRIVING APPROXIMATELY 65 MPH AND ACCELERATING THE CONTACT FELT A VIBRATION IN THE FRONT END OF THE VEHICLE. THE FAILURE OCCURRED INTERMITTENTLY. THE CONTACT STATED THAT THERE WAS A VOLUNTARY RECALL FOR THE HIGH PRESSURE FUEL PUMP AND A SOFTWARE UPDATE. THE VEHICLE WAS TAKEN INTO THE DEALER FOR THE RECALL REPAIRS AND TO DIAGNOSE THE FAILURE OF THE VIBRATION. THE TECHNICIANS STATED THAT THE LOW PRESSURE FUEL PUMP AND SPARK PLUGS NEEDED TO BE REPLACED. THE REPAIRS WERE NOT MADE BY THE DEALER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE A LOW PRESSURE FUEL PUMP AND SPARK PLUGS WERE REPLACED. AFTER THE REPAIRS WERE MADE THE CONTACT CONTINUED TO EXPERIENCE THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN STATED THAT THE FUEL INJECTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT SHE HAD AN AFTER MARKET WARRANTY AND THEY WOULD HAVE THE VEHICLE INSPECTED BY ONE OF THEIR INSPECTORS. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10389882March 11, 2011
LATCHES/LOCKS/LINKAGES
BMW 335I INTERIOR DOORS WERE LOCKED DUE TO ELECTRICAL/MECHANICAL MALFUNCTION/FAILURE OF THE DOOR LOCK SYSTEM. I HAD TO UNROLL THE WINDOWS AND CRAWL OUT AND PULL MY KIDS OUT OF THE BACK SEATS THROUGH THE WINDOWS. IF THIS WERE AN ACCIDENT, THERE WOULD HAVE BEEN SEVERE INJURIES AND MADE IT IMPOSSIBLE TO QUICKLY GET OUT OF THE CAR. ONLINE FORUMS INDICATE THIS IS A SERIAL PROBLEM AND SHOULD BE SUBJECT TO MANUFACTURER RECALL FOR THIS ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10389733March 10, 2011
FUEL SYSTEM, GASOLINE
HIGH PRESSURE FUEL PUMP FAILING RESULTING IN MY VEHICLE TO SHUT OFF AND NOT START. I'M VERY AFRAID THIS COULD HAPPEN WHILE PASSING A VEHICLE ON THE HIGHWAY OR WHILE ON A VACATION TRIP WITH FAMILY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10386081March 1, 2011
ENGINE AND ENGINE COOLING
2007 BMW 335I (BUILD DATE 11/06): CAR DISPLAYS "ENGINE MALFUNCTION" AND ENGINE POWER IS SUBSTANTIALLY REDUCED WITHOUT ANY WARNING OR PREDICTABILITY. TURNING CAR OFF AND THEN RESTARTING RESETS EVERYTHING AND THEN THE CAR WILL RUN NORMALLY UNTIL THE NEXT EPISODE OF "ENGINE MALFUNCTION." BMW DEALERSHIP HAS CHECKED ENGINE FAULT CODES AND BELIEVES THAT THIS PROBLEM IS RELATED TO PREMATURE WEAR OF THE "CAMSHAFT BEARING LEDGE." I HAVE ALREADY HAD MY FUEL PUMP REPLACED AND NOW THE CAR IS BEHAVING EXACTLY THE SAME WAY BUT BMW IS NOW CLAIMING ANOTHER ENGINE FAULT (CAMSHAFT BEARING LEDGE) AS THE SOURCE OF THE SUDDEN AND UNEXPECTED ENGINE POWER LOSS. I HAVE OWNED BMWS ALL MY LIFE AND HAVE NEVER AS DISAPPOINTED WITH A CAR AS I HAVE WITH THIS ONE. IT IS MY OPINION THAT THE ENGINE IN THIS CAR IS SO UNRELIABLE (UNPREDICTABLE POWER LOSS DUE TO MULTIPLE REASONS... NOT JUST THE FUEL PUMP) THAT IT PRESENTS A SERIOUS SAFETY HAZARD FOR BMW 335I OWNERS AS WELL AS OTHER MOTORISTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10385809February 28, 2011
FUEL SYSTEM, GASOLINE
2007 BMW 335I SEDAN PURCHASED USED FROM DEALER WITH 51,000 MILES. ABOUT ONE MONTH LATER, FUEL SYSTEM FAILED ON INTERSTATE CAUSING VEHICLE TO LOOSE POWER IN RUSH HOUR TRAFFIC WITH HIGH RISK OF ACCIDENT AND INJURY. CAR TOWED TO DEALER FOR ANALYSIS AND REPLACEMENT OF FUEL PUMP, KEPT FOR MORE THAN A WEEK. ONE MONTH LATER, THE SAME PROBLEM OCCURRED AGAIN. DEALER WOULD NOT COVER COST OF REPAIR BUT SAID THE CAR WAS DRIVABLE. DROVE CAR VERY MINIMAL OVER LAST TWO MONTHS, NOW CAR WILL NOT ACCELERATE TO MORE THAN 50 MPH AND SHUDDERS DRAMATICALLY. RESEARCHED RECALLS AND COMPLAINTS REVEALED A LONG HISTORY OF CONSUMER COMPLAINTS DESCRIBING MY EXACT CIRCUMSTANCES. PROCEEDING WITH VERY COSTLY REPAIR BUT APPREHENSIVE ABOUT RESULT, SAFETY AND DEPENDABILITY OF VEHICLE. MANUFACTURER SHOULD RECALL AND REPLACE FUEL SYSTEM IN ORDER AVOID POTENTIALLY FATAL CIRCUMSTANCES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10378269January 22, 2011
LATCHES/LOCKS/LINKAGES, ELECTRICAL SYSTEM
DOOR LOCKS FAILED USING KEY FOB OR BUTTON ON DASH. FOLLOWED SERVICE BULLETIN TO REPLACE FUSE, BUT PROBLEM KEEPS REAPPEARING. PASSENGER DOOR INOPERATIVE EVEN AFTER FUSE REPLACED AND OTHER DOORS WORKING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10371198December 19, 2010
WHEELS, TIRES:SIDEWALL
BMW 3 SERIES AND ALSO OTHER SERIES WITH RUN FLAT TIRES HAVE AN ISSUE THAT WITH AN AVERAGE BUMP LIKE A MANHOLE COVER THE WHEEL WILL CRACK. I HAVE REPLACED 3 SO FAR ON MY 2007 335I AT MY COST. AFTER RESEARCH I HAVE SEEN THAT THIS IS A COMMON ISSUE AND THAT EVERYONE HAS HAD THE SAME EXPERIENCE WITH BMW DENYING IT WAS THE WHEEL. THE CAR HAS 45,000+/- MILES ON IT. WHEN BROUGHT IN DUE TO RAPID AIR LOSS BMW STATES IT WAS THE DRIVING CONDITIONS NOT THEIR WHEEL. I DRIVE ON MOSTLY HIGHWAY ROADS AND SECONDARY ROADS TO MY HOUSE. I HAVE NEVER HIT ANY KIND OF POTHOLE OR CURB THAT WOULD CAUSE AN ALLOY RIM TO BE CRACKED. IN ALL 3 INSTANCES, THE CRACK IS EXACTLY THE SAME AND THE REPLACEMENT FOR THIS DAMAGE IS IN EXCESS OF $500 FOR THE RIM. IN TWO OF THE INSTANCES, I HAD TO GET A NEW RUN FLAT TIRE AS WELL AT A COST OF $400 A PIECE. ALL THREE OF THESE PROBLEMS HAVE OCCURRED OVER THE PAST 5 MONTHS!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10366723November 18, 2010
FUEL SYSTEM, GASOLINE
ENGINE BEGAN RUNNING ROUGH. WITHIN 1 MILE THE REDUCED POWER INDICATOR WAS ILLUMINATED ON THE DASH. SHUTOFF AND RESTARTED ENGINE - CHECK ENGINE LIGHT THEN ILLUMINATED. VEHICLE WAS TAKEN TO LOCAL DEALERSHIP AND PROBLEM DIAGNOSED AS A DEFECTIVE HIGH PRESSURE FUEL PUMP. DEALER REPLACED PUMP UNDER WARRANTY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10366725November 18, 2010
FUEL SYSTEM, GASOLINE
REDUCED POWER INDICATOR ILLUMINATED ON DASH. SHUT OFF AND RESTARTED ENGINE. CHECK ENGINE LIGHT THEN ILLUMINATED. AT TIME OF EVENT, OWNER WAS 160 MILES FROM RESIDENCE. VEHICLE CONTINUED TO OPERATE NORMALLY ALBEIT WITH SIGNIFICANTLY LIMITED POWER. VEHICLE WAS TAKEN TO DEALER THE NEXT MORNING AND PROBLEM DIAGNOSED AS DEFECTIVE HIGH PRESSURE FUEL PUMP. PART WAS REPLACED UNDER WARRANTY. DEALER SAID WHEN FUEL PUMP FAILED PREVIOUSLY (ON MARCH 11, 2010) THE REPLACEMENT PART WAS THE PREDECESSOR PART NUMBER. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10360017October 11, 2010
FUEL SYSTEM, GASOLINE
THE CAR STARTED NORMALLY BUT WITHIN A MILE IT BEGAN TO SHUDDER ABOVE ~2.5K RPM. I GOT TO MY DESTINATION WITHOUT FURTHER INCIDENCE. LATER THAT DAY SOON AFTER LEAVING THE PARKING LOT THE CAR DIED AT A STOP SIGN. SES AND OTHER LIGHTS CAME ON. I STARTED IT UP AND IT IMMEDIATELY DIED AGAIN. THIS HAPPENED REPEATEDLY UNTIL I FOUND THAT IF I GAVE IT THE RIGHT AMOUNT OF GAS AND KEPT IT UNDER A CERTAIN RPM I COULD OPERATE WITH VERY LIMITED POWER. THAT COMBINED WITH THE FACT IT WAS LARGELY DOWNHILL AND NOT VERY FAR TO MY HOUSE ALLOWED ME TO GET HOME SAFELY. I DROVE IT TO THE DEALERSHIP THE NEXT DAY (KEEPING IT WELL UNDER 2.5K RPM TO DO SO) AND THEY REPLACED THE HIGH PRESSURE FUEL PUMP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10358844October 2, 2010
FUEL SYSTEM, GASOLINE
LONG CRANKING BEFORE MY 07 BMW 335I STARTS. ENGINE LOSES POWER AND GOES INTO LIMP HOME MODE! DEALER REPROGRAMMED MY VEHICLE,BUT NOW IT HAS NO POWER! IT ALSO HAS A LOT OF TURBO LAG AT THE LOWER REV RANGE! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10357726September 26, 2010
FUEL SYSTEM, GASOLINE
HIGH PRESSURE FUEL PUMP FAILURE IN 2007 BMW 335I CONVERTIBLE @ 36K MILES. CAR WAS PURCHASED IN APRIL, 2010 WITH 32K MILES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10356899September 21, 2010
FUEL SYSTEM, GASOLINE
HIGH POWER FUEL PUMP FAILURE ON 2007 BMW 335I SEDAN. VEHICLE BEGAN EMITTING SMOKE OUT THE BACK, AND RUNNING VERY ROUGH. ON A LATER RESTART THE ENGINE COULD NOT STAY RUNNING. CAR WAS TOWED TO DEALER FOR REPAIRS. HPFP WAS REPLACED AND INJECTORS WERE REPLACED, ECU SOFTWARE UPDATED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10356614September 20, 2010
FUEL SYSTEM, GASOLINE
MY VEHICLE IS 2007 MODEL BMW 335I COUPE. I WAS ON THE FREEWAY 405 GOING APPROXIMATELY 70 MILES PER HOUR. THEN SUDDENLY AN ENGINE WARNING LIGHT "ENGINE MALFUNCTION" SIGN COMES UP WHICH LOWERS THE RPM AND THE SPEED OUTPUT OF THE ENGINE TO AROUND 30~ 40. I HAVE TO QUICKLY MERGE THE VEHICLE FROM THE INNER LANES TO THE RIGHT GOING ONTO THE CURB SINCE THERE WAS NO CURB ON THE INNER LANES. AFTER APPROXIMATELY 3 MINUTES AS I SLOWLY GUIDED MY VEHICLE TO THE SIDE, THE ENGINE SHUTS OFF ON ITS OWN WITH STUTTERING SOUND AND ENGINE CRANKING. I RESTARTED THE ENGINE SEVERAL TIMES TO NO AVAIL. I WAS EXTREMELY DANGEROUS AS THE SUDDEN SLOW DOWN AND ENGINE SHUT OFF MIGHT HAPPEN WHEN I AM IN THE MIDDLE OF THE FREEWAY AND THE CARS BEHIND OR NEXT TO ME MIGHT EASILY HIT ME WITH TYPICAL FREEWAY SPEED OF 70 MPH. I CALLED THE TWO TRUCK AND HAD THE VEHICLE TOWED TO A BMW CENTER. THEY INSPECTED THE VEHICLE AND BELIEVED THAT THE HIGH PRESSURE FUEL PUMP IS BAD AND WILL REPLACE THE FUEL PUMP FOR ME. IT APPEARS TO BE THAT THIS VERY SAME ISSUE APPEARED QUITE OFTEN TO A NUMBER OF 335I OR OTHER BMW MODELS USING THE SAME ENGINE, IN PARTICULAR TO THE 07 AND 08 MODELS. MORE OVER, A LOT OF THE CAR OWNERS HAVE THE SAME ISSUE HAPPENED TO THEM EVEN AFTER THEIR FUEL PUMP REPLACED ONCE OR EVEN TWICE. IT SEEMS LIKE THERE IS NO ABSOLUTE FIX FOR SUCH ISSUE AND IT POSES AS A TREMENDOUS DANGER FOR BMW DRIVERS WITH THIS SPECIFIC ENGINE SINCE YOU CANNOT BE CERTAIN WHEN HE PROBLEM WILL RE-OCCUR. SIMILAR COMPLAINS HAVE BEEN FILED AND THE ACTION CAN BE REFERRED HERE NHTSA ACTION NUMBER: PE08032. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10356325September 19, 2010
POWER TRAIN, FUEL SYSTEM, GASOLINE
CAR STALLING AND NO POWER IN THE MIDDLE OF THE ROAD WHILE DRIVING. NO POWER TO ACCELERATE. THIS HAPPENED WHILE I WAS MAKING A U TURN, CARS WAS COMING AT ME AT A HIGH RATE OF SPEED AND I COULDN'T GET POWER TO ACCELERATE. TRIED PULLING OVER SAFELY. CAR WAS OOZING POWER AND CANT RESTART NORMALLY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10355848September 15, 2010
ENGINE AND ENGINE COOLING:ENGINE
I HAVE HAD MY 3RD HIGH PRESSURE FUEL PUMP (HPFP) FAIL IN THE 3.5 YEARS THAT I HAVE OWNED MY CAR. ALL THREE REPLACED UNDER WARRANTY, BUT IT SEEMS TO BE A DESIGN FLAW SINCE THIS IS A RECURRING PROBLEM IN MY MODEL. ALMOST EVERYONE PEOPLE IN MY CAR CLUB WITH A 2007 OR 2008 MODEL YEAR 335I HAS HAD THEIR HPFP REPLACED AT LEAST ONCE. THE CAR BREAKS DOWN WITHOUT WARNING AND GENERALLY WHEN COMES TO A COMPLETE STOP. UPON FAILURE, THE ENGINE WARNS OF MALFUNCTIONS AND CONTINUE TO DRIVE IN A "LIMP" MODE, OFTEN STALLING WHEN COMING TO A COMPLETE STOP...SHUDDERING DURING THE DRIVE UNTIL I AM ABLE TO BRING TO A DEALERSHIP. I HAVE BEEN FORTUNATE THAT ALL THREE FAILURE HAVE OCCURRED DURING LOW SPEEDS AND STALLING OCCURRING AT STOP LIGHTS AND NOT DURING HIGH SPEED OPERATION. IF IT WASN'T FOR MY BMW ROADSIDE ASSISTANCE, I WOULD HAVE BEEN STRANDED ON ONE OF THE THREE OCCASIONS. BMW KNOWS THERE IS A REAL PROBLEM BUT REFUSES TO RECALL. THEY HAVE ISSUED DEALER SERVICE BULLETINS AND HAVE INCREASED THE WARRANTY ON THE HPFP REPLACEMENTS FOR 100,000 MILES. HOWEVER, A 100,000 MILE WARRANTY DOES NOT FIX REPLACING THE HPFP EVERY FEW MONTHS (MY 2ND IN 4 MONTHS). BMW MUST ISSUE A RECALL AS THIS IS DANGEROUS AND UNPREDICTABLE, ESPECIALLY SINCE THIS THEIR IS NO SYMPTOMS FOR THE IMPENDING MALFUNCTION AND THERE IS NO USER ERROR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10352134August 26, 2010
FUEL SYSTEM, OTHER
I OWN A 2007 BMW 335I. A FEW MONTHS AGO AFTER A SERVICE ISSUE FOR AN UNRELATED PROBLEM, MY VEHICLE DASH DISPLAY WENT HAYWIRE AND SHOWED AN ENGINE PROBLEM. I WAS TRAVELING ON A HIGHWAY AT SPEED AND SUDDENLY NO POWER. THE VEHICLES BEHIND ME HAD TO SWERVE TO AVOID HITTING ME. IT WAS ALSO DIFFICULT TO GET OVER ONTO THE SHOULDER. THE DEALERSHIP DIAGNOSED THE ISSUE AS A FAILED HIGH PRESSURE FUEL PUMP. AFTER SOME RECENT RESEARCH I HAVE READ THAT THIS IS A COMMON AND KNOWN ISSUE WITH MY VEHICLE, YET THERE HAVE BEEN NO MANDATORY RECALLS, MERELY REPLACEMENTS PUMP THAT IN MANY CASES FAILS AGAIN. I SEE THIS AS A POTENTIALLY LIFE-THREATENING ISSUE THAT IS WAITING TO OCCUR GIVEN THE RIGHT CIRCUMSTANCES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10351886August 26, 2010
FUEL SYSTEM, GASOLINE
2007 BMW 335I HPFP FAILED ON THE HIGHWAY CAR STALLED AND CAME TO A STOP AS I ROLLED OFF THE SHOULDER. A SECOND HIGH PRESSURE FUEL PUMP IS INDICATING THAT ITS GOING TO FAIL AND I AM SERIOUSLY CONCERNED ABOUT DRIVING IT. THE CAR ONLY HAS 16,000MILES AND DEALER REFUSE TO SWAP THE PUMP UNTIL THERE IS ACTUALLY FAILURE EVEN THOUGH I HAVE EXHIBITED ALL THE SIGNS THAT THE PUMP IS ABOUT TO FAIL AGAIN. THEY ONLY PROVIDED ME A SOFTWARE UPDATE. I AM SERIOUSLY CONCERNED FOR MY SAFETY AND AS A RESULT AM NOT DRIVING THIS CAR LONG DISTANCES OR ON THE HIGHWAY.. I THINK ITS ABOUT TIME AUTHORITIES STEP UP AND FORCE BMW TO DEAL WITH THIS VERY SERIOUS VEHICLE HAZARD, WHICH THEY ARE ABUNDANTLY AWARE OF, BUT REFUSE TO DO NOTHING ABOUT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to BMW 335i