BMW 335i Service Bulletins
690 manufacturer communications on file.
- October 1, 2016•Document ID: 10146894Service Bulletin/Repair InstructionsSTRUCTURE
- Mfr Comm. #:
- B512616
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryDOOR FRAME TRIM DAMAGED. Door seal on the A-Pillar is damaged near exterior mirror. Mirror base gasket protrudes and interferes with door seal.
Associated Products (8)Associated Documents - October 1, 2016•Document ID: 10146892Service Bulletin/Repair InstructionsSERVICE BRAKES
- Mfr Comm. #:
- B340516
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryCBS BRAKE PAD CALCULATION AND CORRECTION. When a vehicle comes into the workshop for any repair or maintenance job, the bundling calculator recommends a brake maintenance checkup. No brake warning light is illuminated. CBS shows 3,107 miles or slightly higher for the next brake service displayed via Key Reader, or vehicle's Control Display (in Vehicle Info/Status/Service required/Brake pads) CAUSE CBS calculates the remaining brake pad wear based on brake pressure, speed, vehicle specific parameters (i.e. NAO pads), brake temperature as well as cumulative brake application time. Due to variation of these parameters and outside environmental influences, this calculation can deviate from the real brake pad wear. Starting from the above-mentioned production dates of the vehicles indicated, the CBS brake pad wear calculation has been changed, and is now based only on the brake pad wear sensor. Important Note: To avoid a too-slow wear prediction, the CBS brake model will estimate the need for repairs, in some cases, rather early. Calculation will level at 3,107 miles and stay at this value until the CBS brake pad wear sensor is triggered. https://www.bmwtis.net/tiscode/cgi-bin/bulletin.aspx?sie_path=/tsb/bulletins/htm_store/36...11/8/2016 Page 2 of 2 After the sensor is triggered, the CBS mileage will count down indicating to the customer that the brake repairs will be due.
Associated Products (148)Associated Documents - October 1, 2016•Document ID: 10146878Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- B111716
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryVOLUNTARY EMISSIONS RECALL CAMPAIGN 16E-A05 - N26 ENGINE: REPLACE TURBOCHARGER OIL SUPPLY LINE. Carbonization of the turbocharger sealing ring can cause the exhaust to smoke briefly during cold start up.
Associated Products (27)Associated Documents - September 1, 2016•Document ID: 10146849Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- B840916
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"SERVICE ACTION: SUPPLEMENTARY PAGE NEEDED IN OWNER'S MANUAL. Operator's manual of affected vehicles does not contain required information on wireless smartphone charging accessory. AFFECTED VEHICLE Vehicles which require this Service Action to be completed will show it as ""Open"" when checked either in the ""Service Menu"" of DCSnet (Dealer Communication System) or with the Key Reader."
Associated Products (53)Associated Documents - September 1, 2016•Document ID: 10146848Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B840416
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummarySOS MALFUNCTION DISPLAYED. An SOS malfunction is seen in the Kombi. When pressing the E-Call/SOS button in the overhead console, nothing happens. Fault code B7F33C (internal ECU error) is stored in the Telematics control unit (ATM/TCB2). There are 2 known causes for this failure. They are as follows: Software file missing from the ATM/TCB2 control module Water leak at shark-fin leading to corrosion in the ATM/TCB2 control module
Associated Products (52)Associated Documents - September 1, 2016•Document ID: 10146844Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- B641216
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"HVAC BLOWER NOT WORKING This Service Information bulletin supersedes SI B64 12 16 dated August 2016. HVAC blower is not working. Condensation occurs even though blower is working. CC message ""Increased battery discharge"" - standby current violation may be displayed. Climate control unit (IHKA) software"
Associated Products (56)Associated Documents - September 1, 2016•Document ID: 10146830Service Bulletin/Repair InstructionsSTRUCTURE:BODY:DOOR
- Mfr Comm. #:
- B513216
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryCREAKING NOISES FROM DOOR TRIM PANEL. Creaking noise is heard from door trim panel while driving on rough roads. Door trim panel is contacting the inner door panel.
Associated Products (53)Associated Documents - September 1, 2016•Document ID: 10146829Service Bulletin/Repair InstructionsFUEL SYSTEM, GASOLINE
- Mfr Comm. #:
- B513116
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryHOOD GAS-FILLED SHOCK ABSORBER MOUNT IS BROKEN. Hood gas filled shock absorber is loose or broken, the hood does not remain in the opened position. Gas filled shock absorber mounting point has broken free from the body.
Associated Products (37)Associated Documents - August 1, 2016•Document ID: 10147042Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL; EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT
- Mfr Comm. #:
- B840616
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryBMW ONLINE NON-FUNCTIONAL: CHECK ICC-ID IN ACCOUNT. BMW Online/BMW ConnectedDrive not functional. Vehicle and service cockpit have different ICC-ID's.
Associated Products (158)Associated Documents - August 1, 2016•Document ID: 10147041Service Bulletin/Repair InstructionsEQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- B840516
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryBMW ONLINE NON-FUNCTIONAL: CHECK ICC-ID IN ACCOUNT. The ConnectedDrive Services are non-functional after a hardware exchange of the telematics control unit. This is not indicated by CC-message. ConnectedDrive Services not synchronized by Telematics Control Unit.
Associated Products (160)Associated Documents - August 1, 2016•Document ID: 10147039Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- B661816
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryINFORMATION ON THE OPERATION OF THE SMART OPENER. INFORMATION ON THE OPERATION OF THE SMART OPENER MODEL F07 (5 Series Gran Turismo) F10 (5 Series) F12 (6 Series Convertible) F13 (6 Series Coupe) F15 (X5) F16 (X6) F22 (2 Series Coupe) F23 ( 2 Series Convertible) F25 (X3) F26 (X4) F30 (3 Series Sedan) F31 (3 Series Wagon) F32 (4 Series Coupe) F33 (4 Series Convertible) F34 (3 Series Gran Turismo) F36 (4 Series Gran Coupe) F48 (X1) F80 (M3 Sedan) F82 (M4 Coupe) F83 (M4 Convertible) F85 (X5 M) F86 (X6 M) G12 (7 Series) I01 (i3 Series) Vehicles with option code SA-0322 (Comfort Access) without M-Sport trim INFORMATION The smart opener (Contactless tailgate) operates as described below: Ignition key must be within 3 feet behind the vehicle, clear from any interference like a smartphone The customer must be at least an arms-length behind the vehicle Kick your foot forwards & backwards under the vehicle in one quick movement The taillights flash confirming that the trunk will open The trunk then successfully opens For more information an instructional video can be viewed which demonstrates the operation. Thanks to BMW of Tenafly for providing the video. tinyurl.com/Autotrunk1 https://www.bmwtis.net/tiscode/cgi-bin/bulletin.aspx?sie_path=/tsb/bulletins/htm_store/358...9/3/2016 Page 2 of 2 WARRANTY INFORMATION Not applicable. [ Copyright (c)2016 BMW of North America, Inc. ] https://www.bmwtis.net/tiscode/cgi-bin/bulletin.aspx?sie_path=/tsb/bulletins/htm_store/358...9/3/2016
Associated Products (122)Associated Documents - August 1, 2016•Document ID: 10147035Service Bulletin/Repair InstructionsEQUIPMENT:APPLIANCE:AIR CONDITIONER
- Mfr Comm. #:
- B641216
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"HVAC BLOWER NOT WORKING. HVAC blower is not working. Condensation occurs even though blower is working. CC message ""Increased battery discharge"" - standby current violation may be displayed. Climate control unit (IHKA) software"
Associated Products (54)Associated Documents - August 1, 2016•Document ID: 10147029Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL; EQUIPMENT ADAPTIVE/MOBILITY
- Mfr Comm. #:
- B611513
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"ACSM AND ICM WARNING LAMPS ILLUMINATED This Service Information bulletin supersedes SI B61 15 13 dated October 2013. Various warning lamps and check control messages relating to the ACSM and ICM systems are illuminated. Many ""No Message"" faults are stored for various control modules. The ACSM and ICM modules may also not be responding to a vehicle test in ISTA. Ground point Z10*10B is loose."
Associated Products (11)Associated Documents - August 1, 2016•Document ID: 10147022Service Bulletin/Repair InstructionsSTRUCTURE:BODY:TRUNK LID; STRUCTURE:BODY:TAILGATE
- Mfr Comm. #:
- B513016
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryTAILGATE UNINTENTIONALLY OPENS. Trunk/tailgate may open when vehicle is locked. Trunk/tailgate may open while the vehicle is in motion. Usually after stopping, such as a traffic light etc. Vehicle key trunk/tailgate button may accidentally be pressed, thus opening the tailgate.
Associated Products (155)Associated Documents - August 1, 2016•Document ID: 10147021Service Bulletin/Repair InstructionsSTRUCTURE:BODY:DOOR; EQUIPMENT:ELECTRICAL; EQUIPMENT ADAPTIVE/MOBILITY
- Mfr Comm. #:
- B512816
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryINTERMITTENT DISTORTION IN AUDIO SYSTEM, DRIVER'S SIDE. Distortion in audio system from subwoofer on driver's side. Rodent ingress into subwoofer enclosure.
Associated Products (27)Associated Documents - August 1, 2016•Document ID: 10147017Service Bulletin/Repair InstructionsENGINE; EQUIPMENT:OTHER:LABELS
- Mfr Comm. #:
- B511615
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"Delivery Stop: Remove Engine Oil Label. Affected vehicles in dealer inventory must not be retailed or delivered until the label is removed. Vehicles at ports of entry will be remedied prior to dealer delivery. On affected vehicles, there is an incorrect label regarding the appropriate engine oil. Affected vehicles can be identified with a ""Vehicle Comment"" in the DCS Warranty Vehicle Inquiry or ISPA Light. https://www.bmwtis.net/tiscode/cgi-bin/bulletin.aspx?sie_path=/tsb/bulletins/htm_store/248...9/3/2016 Page 2 of 2"
Associated Products (134)Associated Documents - August 1, 2016•Document ID: 10147015Service Bulletin/Repair InstructionsSERVICE BRAKES, AIR:ANTILOCK:WHEEL SPEED SENSOR; SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR/TONE RING
- Mfr Comm. #:
- B340616
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"DSC ""WHEEL SPEED SENSOR"" FAULT CODES AND MALFUNCTION INDICATOR LAMP- DIAGNOSTIC. 1. DSC's fault codes stored from two different wheel speed sensors (both front or both rear): 4809B0 - wheel speed sensor - front left - drive off recognition faulty and 4809CD - wheel speed sensor - front right - drive off recognition faultyor 4809B9 - wheel speed sensor - rear left - drive off recognition faulty and 480686 - wheel speed sensor - rear right - drive off recognition faulty. 2. Next ignition ON (after above codes stored). a) DME fault can occur:1F054D - drive, safety function: Drive power output reduced, DSC signals implausible and b) Malfunction Indicator Lamp (MIL) may light up. Faulty drive off recognition due to: a towing operation with a raised axle operation of the vehicle on the vehicle hoist operation of the vehicle on the roller test stand DSC diagnosis recognizes implausible wheel speeds, so no control is possible. DME fault is entered on safety grounds since the DSC fault still exists after a terminal change and may only be removed while driving."
Associated Products (51)Associated Documents - August 1, 2016•Document ID: 10147008Service Bulletin/Repair InstructionsSERVICE BRAKES, HYDRAULIC; POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE); ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC)
- Mfr Comm. #:
- B270216
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"REPAIRING TRANSFER CASE ACTUATOR (VTG SERVO-MOTOR). The Anti-lock Brakes (ABS), Brakes and Dynamic Stability Control (DSC) warnings are on and there may also be a ""Drivetrain Malfunction"" warning on in the Control Display. There is also an audible clicking noise coming from the transfer case actuator when cycling the ignition. The following fault codes may be stored: (DSC) 5F3A - Clutch gearbox-ECU: clutch is open - rear-wheel drive! (VTG) 5463 - Break mechanics (VTG) 5462 - Error actuator or increased power requirements for clutch (VTG) 5461 - Error actuator control Internal wear to the plastic gears of the transfer case actuator."
Associated Products (53)Associated Documents - August 1, 2016•Document ID: 10146998Service Bulletin/Repair InstructionsELECTRICAL SYSTEM; EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT
- Mfr Comm. #:
- B012016
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
SummaryFOOTWELL MODULE: LIMITED WARRANTY EXTENSION TO 8 YEARS/125,000 MILES. When performing ISTA/D diagnosis and/or a programming procedure (software update) on an affected vehicle, the Footwell Module (FRM) could fail. There is a compatibility issue with certain combinations of vehicle software (Plant Integration ILevel) and the Footwell Module hardware installed in the vehicle.
Associated Products (43)Associated Documents - August 1, 2016•Document ID: 10146991Service Bulletin/Repair InstructionsEQUIPMENT; ELECTRICAL SYSTEM
- Mfr Comm. #:
- B010916
- Date Added:
- November 5, 2018
- Manufacturer:
- BMW
Summary"N55 LEAK DIAGNOSIS MODULE (NVLD): LIMITED WARRANTY EXTENSION TO 10 YEARS/120,000 MILES. INFORMATION For the above-referenced vehicles, BMW of North America, LLC (""BMW NA"") is extending the limited warranty for the leak diagnosis module (NVLD) to: 10 years/120,000 miles as determined by the vehicle's original in-service date Recall or Service Action. There is no immediate repair required unless the BMW vehicle is currently experiencing this problem. Customer Notification Letter - VIN and Component-specific Warranty Extension Even though this is NOT a Recall, BMW NA will be sending VIN-specific customer notification letters in a phased release."
Associated Products (11)Associated Documents