Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.
The vehicle's Supplemental Restraint System (SRS) safety network experienced a total electrical blackout, resulting in complete airbag non-deployment during a severe unibody-deforming hit-and-run collision. The vehicle was stationary when a high-speed car rammed the passenger side and front profile. Kinetic forces split the cast aluminum steering rack housing completely in half, fractured front CV axle joint cages, and shifted the engine subframe mounts (creating physical gaps and shiny mechanical abrasions beneath the rust layer). Despite catastrophic structural distortion—which twisted the greenhouse safety cage and cracked the windshield directly beneath the laser cluster—zero front, side, or curtain airbags deployed. No dashboard SRS warning lights illuminated prior to or after the crash.A post-crash scan by a Master Mechanic confirms high-speed CAN-bus fragmentation, storing module timeouts U016700, U042268, and steering column resistance deployment inhibitors B1C0224, B1CO424, B1C0524. Additional codes include P134600, P134613, P261086, P0A0F68, C006468, B109B15, B116415, and B108467.Teardown reveals extensive, pre-existing saltwater intrusion residue inside passenger footwell fuse blocks (Centers B/C) and the under-hood relay box, plus green cupric carbonate oxidation on chassis grounds. This induced extreme electrical resistance, blinding the SRS module's ability to read the crash pulse. Occupant safety was heavily compromised; the driver sustained a severe concussion, whiplash, and active neurological time-loss blackouts after being struck by flying cabin cargo during the pulse. Both front seatbelt receiver buckles permanently bound and locked. The vehicle was inspected by local police under an active criminal hit-and-run report. Diagnostic logs are preserved and available for federal review.
Engine blew up while my daughter was driving due to excessive oil consumption. Issue known by Volvo but we bought the car in 2023 and the 8year warranty recall was just about to expire and we knew nothing about it. Very dangerous
No injuries · No fire · No crash
Component/System that failed: The engine (T5 Drive-E) experienced sudden loss of propulsion and entered reduced engine performance mode. The vehicle is currently available for inspection and was towed to an authorized Volvo dealer following the incident. How safety was put at risk: On July 3, 2025, while driving approximately 75 mph on a crowded interstate highway in rural Ohio with cruise control engaged, the vehicle suddenly and without warning lost propulsion. Traffic included semi-trucks and other vehicles, with limited shoulder availability. The sudden loss of acceleration at highway speed created an immediate risk of rear-end collision and left the vehicle unsafe to operate. Confirmation or reproduction: Prior to the failure, in July 2024 at approximately 92,000 miles, I reported abnormal oil consumption to an authorized Volvo dealer and raised a known Volvo service advisory related to oil consumption in the T5 Drive-E engine. The dealer acknowledged the advisory but refused testing, stating the vehicle did not meet Volvo’s internal threshold. After the failure, a service agent acknowledged that this issue is known to occur in this model at approximately this mileage. Inspections: The vehicle was serviced at an authorized Volvo dealer in Bethesda, Maryland just days prior to the incident. Following the failure, the vehicle was towed to an authorized Volvo dealer in Columbus, Ohio. Volvo Cars USA has not repaired the vehicle and denied a goodwill request. Warnings or symptoms prior to failure: There were no warning lamps or messages prior to the loss of propulsion. The engine warning light and a “Reduced Engine Performance” message appeared only after power was lost.
No injuries · No fire · No crash
The vehicle shakes and engine abruptly shuts off even after a new tune up
No injuries · No fire · No crash
02/15/2025 I received a letter for oil consumption recall that was dated on 02/03/2023. Appointment was made same day I received the letter on 02/15/2023 and appointment couldnt be set sooner then 02/23/2023 which is the date the Oil consumption was done at Volvo of Bellevue. They changed the oil and sealed it and had me drive it 1000 miles, they said I didn't have an oil consumption problem and I disagreed because I told them I have to put in oil all the time. They said it has exceeded the 8yr or 100K miles of the extended warranty of the vehicle which ever comes first. I argued it had less then 100K miles when I got the letter on 02/15/2023 and the appointment couldnt be set til 02/23/2025 and Volvo of Bellevue said not to worry about it and they would take care of the recall. But after they had me pay for the oil change they said it exceeded the 100K miles and 8 yrs age of the vehicle. I argued the letter was sent to me after the vehicle was 8 years old and the avg miles of 12K was over 100K miles and I argued this was a known problem with Volvo but they kept on selling these vehicles knowing these vehicles have oil consumption problems. They refused to fix the car unless I paid them Thousands and thousands and thousands of dollars. I trusted what they told me that there was no oil consumption and in less then 7K miles later my engine smoked from their oil change and there was no oil in the vehicle as the engine had consumed all the oil and my car sat in my driveway for 22 months and I replaced many parts and still car wouldn't run. I took it back to Bellevue Volvo on 07/23/2025 to see what was wrong with the vehicle and they said the pistons were bent.
No injuries · No fire · No crash