Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2024 C40BEV, 2022-2025 S90, V90CC, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40, and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2025 S90, V90CC, C40, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40 and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Volvo Car USA, LLC (Volvo Car) is recalling certain 2023 S60, V60CC, XC60, XC90, XC40, and C40 vehicles. A diagnostic trouble code (DTC) may be falsely detected for the emergency call system (e-call) and display "e-Call Service Required" in the driver information module (DIM).
Volvo Car USA, LLC (Volvo Car) is recalling certain 2023 S60, V60, V60CC, V90CC, XC60, XC90, XC40, and C40 vehicles. A diagnostic error in the Brake Control Module 2 (BCM2) may cause a loss of Antilock Brake System (ABS), Electronic Stability Control (ESC), and traction control.
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
The contact owns a 2023 Volvo V60CC. The contact stated that while driving approximately 52 MPH, the vehicle drove over a small bump on the road, causing the front driver’s side seat belt to tighten and pull the contact closer to the seat by the neck after locking. The contact stated that the seat belt left a bruise on the neck after several seconds when the vehicle returned to normal operation. No warning lights were illuminated. The vehicle was not diagnosed or repaired. The vehicle was taken back to the residence. The manufacturer was not notified of the failure. The failure mileage was approximately 48,000.
No injuries · No fire · No crash
The contact owns a 2024 Volvo V60CC. The contact stated that while driving at various speeds, the turn signals, the blind spot detection system, and the side cameras became inoperable. The failure was intermittent. The vehicle was taken to the dealer, where the infotainment system software update was performed on several occasions; however, the failure persisted. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 500.
No injuries · No fire · No crash
Hello, I currently drive a 2016 Volvo V60 Cross Country which falls under the year of recalled vehicles related to the piston ring issue outlined in the Buchanan, et al. v. Volvo Car USA, LLC, et al., Case No. 2:22-cv-02227. According to the suit Volvo is supposed to replace my oil piston rings if it falls under warranty which is under 100k miles. For Volvo to confirm if my vehicle was impacted they performed an oil consumption test back in March of 2023 in which my vehicle failed meaning the rings still needed to be replaced. Three years later and Volvo Cars Tacoma has still refused to replace the piston rings after multiple follow up attempts. I have also reached out to other Volvo dealers in the area to try and get the rings replaced, but no one ever returns my phone calls. The oil check symptom test was done on my vehicle at 81k miles meaning it still feel under warranty at the time they told me they needed to be replaced. Since then, I have pleaded with them multiple times to fix the issue for three years with zero success although they are LEGALLY required to fix this issue. I took my car in for a repair in November of 2025 and requested they fix the piston ring issue then when they had my vehicle for others repairs and they still refused.
No injuries · No fire · No crash
Currently on going, second time around with high oil consumption problems. Dealer is saying warranty is holding up repairs, warranty points finger at dealership, and Volvo refuses to address the massive safety problem with oil consumption cars by refusing to fix. I will never buy another Volvo, and strongly recommend anyone considering a Volvo to think about how they’re treating current customers with the known oil consumption problem (horribly).
No injuries · No fire · No crash
The piston rings failed on the 5 cylinder engine. The car is not available for inspection as I got rid of it since it cost 16k to repair. My saftey and many others were put at risk as it would cause the engine to heat up excessively and possibly cause a friction weld of the pistons to the crank. This could imobilize the car during driving and cause a crash. I had the car inspected by a automotive tech and the piston rings were found to be at fault. I also had volvo themselves check snd they came to the same conclusion. They said this was normal on these cars. The warrenty company that I went through said they wouldn't cover piston rings. There was no warning about the piston ring problem other than after the fact when the engine drank all the oil and I got a low oil warning.
No injuries · No fire · No crash