Volkswagen · Model Report
Showing safety data for the 1999 model year only.
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.8L VR6 ENGINES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE RECOMMENDED COLD TIRE INFLATION PRESSURE PUBLISHED ON THE LABEL FOR TIRES OF THE SIZE 205/50 R15 86H IS 0.1 BAR (1.45 PSI) TOO LOW. IT SHOULD BE 2.5 BAR (36.3 PSI). THE LABEL RECOMMENDS 2.4 BAR (34.8 PSI = 35 PSI).
ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.
WOULD LIKE TO KNOW IF THERE IS ANY RECALLS ON MY JETTA. I CHECK ENGINE LIGHT COMES ON. I TOOK IT TO 4 REPAIR SHOP AND NO ONE COULD FIND WHATS WRONG WITH IT. I'VE PAID OVER 1200 ON OTHER REPAIRS. WHAT CAN I DO . *TR THANKS CHRISTINA
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1999 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, SMOKE BEGAN TO FILL THE CABIN OF THE VEHICLE. THE CONTACT STOPPED THE VEHICLE AND SAW THAT SMOKE WAS BELLOWING FROM BENEATH THE STEERING COLUMN. THE SMOKE DISAPPEARED AFTER SOME TIME. THE CONTACT THEN ATTEMPTED TO RESTART THE VEHICLE AND THE AIR BAG DEPLOYED INDEPENDENTLY. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO A DEALER. THE VEHICLE WAS TAKEN TO A DEALER FOR INSPECTION AND THE CONTACT WAS AWAITING THE RESULTS. THE FAILURE AND CURRENT MILEAGE WAS 115,144.
THE VW VEHICLE IS PROGRAMMED TO CRIPPLE THE ENGINE PERFORMANCE AND SPEED IN CASE OF AN EPC FAULT. ANY FAULT CAUSING A RICH OR LEAN CONDITION WILL CAUSE THIS "LIMP MODE". THIS IS A SAFETY ISSUE ESPECIALLY PEOPLE ON THE HIGHWAY GOING 65-75MPH AND A 80,000 POUND TRACTOR TRAILER BEHIND THEM AS ONE PERSON EXPERIENCED. THERE ARE TOO MANY NON-VITAL COMPONENT FAILURES TO LIST THAT CAN CAUSE THIS FAULT. I REFER TO NON-VITAL MEANING THE COMPONENT FAILURE WILL NOT HARM THE DRIVER OF THE CAR. THE FAULT LIGHT INDICATION ISN'T ENOUGH? NOW THEY HAVE THE RIGHT TO FORCE YOU INTO A REPAIR SHOP AND BUY MORE VW PARTS. I FEEL THAT THIS IS A MONEY MAKING SCAM ENDANGERING OUR LIVES. WE DO NOT PUT A HALT ON THIS NOW- SOON ANY FAULT WILL CRIPPLE OUR CARS. IT'S NOT JUST VW (HYUNDAI DID A SIMILAR "LIMP MODE"). *TR
No injuries · No fire · No crash
THE MIDDLE REAR SEATBELT LOCKS UP AND WILL NOT RELEASE. THE SEATBELT LOCKING MECHANISM IS LOCATED IN THE SEAT IN AN INACCESSIBLE LOCATION AND IS ALSO NOT AVAILABLE TO RELEASE THE SEATBELT. *TR
No injuries · No fire · No crash
1999.5 VOLKSWAGEN JETTA GLS VR6, ALWAYS GETTING DTC CODES OF P1117, P0140, P1198, P1472, P1435, P0102, P0343, P1421.. THAT ALWAYS SAYS ABOUT OPEN OR SHORT CIRCUIT CONDITIONS AND POOR ELECTRICAL CONNECTIONS, AND SHORT TO GROUNDS FOR ELECTRICAL, WHICH IS ALL ELECTRICAL PROBLEMS, IF YOU SEARCH ONLINE THEM CODES YOU WILL SEE NUMEROUS PEOPLE WITH THE SAME PROBLEMS, AND AS WELL AS ALOT OF US HAVE TO BUY THE PARTS THAT IS LISTED AND PROBLEMS STILL AREN'T FIXED, WHICH TELLS US ITS AN ELECTRICAL ISSUE, NOT ISSUES WITH THE PARTS, WHICH CAUSES OUR #43 FUSE BLOW ALOT, AND ALOT OF HESITATION AND STALLING, I CANT EVEN TURN AROUND A CORNER OR TO GET OFF THE HIGHWAY WITHOUT STALLING, PLEASE FIX THESE PROBLEMS, ITS HAPPENING TO WAY TO MANY OF US AND IT IS ALSO AN SAFETY ISSUE. *TT
No injuries · No fire · No crash