Toyota Tacoma Complaints

8,484 consumer complaints on file.

#11455547March 7, 2022
STRUCTURE:FRAME AND MEMBERS
The contact owns a 2005 Toyota Tacoma. The contact stated that while his vehicle was parked, he noticed that the subframe was extremely rusted. The contact noticed a 10-inch crack on the inside driver’s side rear of the vehicle. The vehicle was taken to the dealer dealer and the contact was informed that the subframe needed to be repaired. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 170,000. Consumer stated rust is the worst near the catalytic converters. It is also bad just in front of the rear tires. It’s a manufacturer flaw where they designed the double wall to where water could get in but not get out and the frame rots from the inside out. This truck was garage kept.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11455349March 5, 2022
ENGINE
There is a known factory defect on a robotic seal around the engine block, in which the robot misses a half inch piece of the engine block, causing oil seepage and leaking of engine oil. The problem is on dozens of Toyota forums and I have also consulted with two different dealerships that have verified this. The 4 cylinder engines in the Tacoma have already been recalled for this issue but they are offering no reimbursement or recall on the 6 cylinder engines. The engine begins leaking oil early in it its life as mine has been. An engine should not fail at 20k 30k or 80k miles due to a factory defect. Toyota should be offering a fix for this issue as it will significantly cut the life of rhe engine. This can cause engine fire and various other safety issues in these trucks if enough engine oil leaks down into a hot engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11455023March 3, 2022
SERVICE BRAKES
The contact owns a 2021 Toyota Tacoma. The contact stated while driving approximately 65 MPH, the brake pedal was depressed and went to the floorboard. There was no warning light illuminated. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that brake lines, brake pads, and brake rotors needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 9,400.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11454448February 28, 2022
EXTERIOR LIGHTING
We paid $638.42 to repair a leak issue which later became a recall. We we are now having difficulty getting Toyota to reimbursement that money.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11454500February 28, 2022
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS
While driving on 3 lane interstate, with the adaptive cruise control on, while passing a semi truck the front collision brake system activated. I was doing 72 miles an hour when it happened. The result was almost got rear-ended by another vehicle when my truck applied the brakes unexpectedly. The semi did not cross into my lane. My lane was clear. 0
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11454095February 25, 2022
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
The contact owns a 2008 Toyota Tacoma. The contact stated that he took his vehicle to get inspected and was informed that the chassis was extremely corroded and would collapse if the mechanic attempted to jack the vehicle up. The contact became aware that the failure was common. The contact stated that the vehicle was included in a service campaign where rust inhibitor was applied on the chassis of the vehicle however, the treatment failed to prevent the subframe from rusting. The dealer nor the manufacturer was not notified of the failure. The failure mileage 267,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11453728February 24, 2022
STRUCTURE:BODY
Severe rusting and corrosion of chassis/under body, body and frame of truck.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11453195February 21, 2022
UNKNOWN OR OTHER
I jacked the truck up, following the directions in the owners manual and the jack went right through the frame of the truck. Upon further inspection, the frame was seen to be flaking and crumbling apart. I looked into recalls and found that Toyota settled this situation on 2006-2008 and some 2010 Tacomas. Obviously my 2010 Tacoma is one of the defective ones.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11452435February 17, 2022
ENGINE, UNKNOWN OR OTHER, FUEL/PROPULSION SYSTEM
The engine light and the track off warning light came on at the same time as i started the engine when i got off work. on the way home i noticed acceleration was not happening as it should when i pressed the gas pedal. I had a mechanic code it and he said it was the switching valve and the air injection pump which would cost about 1200 dollars to fix. My 2015 Toyota Tacoma only have 35000 miles on it. After during so research i found that this is a problem with other toyota truck owners. This could be a safety problem while driving in a situation where you would need to accelerate in fast moving traffic and maintain speed without slowing the traffic behind you
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11452535February 17, 2022
POWER TRAIN
The differential drive housing failed due to corrosion resulting in the differential oil leaking out at a significant rate and in loss of lubrication of the differential gears. The condition was detected before any significant loss of material condition or function but could have lead to a loss of vehicle control if the differential had failed. The local Toyota Dealer has not reviewed the condition as of yet. A review of several Tacoma internet forum sights finds similar corrosion failures described (oil leaking from differential housing). There is no monitoring/warning indicator for the oil level condition in the differential housing in this vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11451779February 13, 2022
STRUCTURE:BODY, UNKNOWN OR OTHER
Never received recall on frame, why wasn't I sent a recall and why don't dealership notify me when leaf springs were replaced?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11450976February 8, 2022
STRUCTURE:BODY, SUSPENSION, SERVICE BRAKES
I was totally aware of the recall for these year models of Tacoma and I brought the truck in several times to have the frame inspected and asked for it to be replaced. The folks at Dorschel Automotive group turned me away saying it did not meet the "rust perforation standard." Lo and behold, when Dorschel was bought by Bob Johnson Auto Group, the first time I took it in they recognized that the frame was entirely rotted and would not pass inspection. At this point, I called Toyota Customer Service and they said they would not honor the recall as it is outside the window of time. Yet this is not a matter of me not taking proper action. I did. I did my due diligence and I am being harmed by the negligence of the service managers at Dorschel. I made Toyota aware that the frame inspection was not done properly. I could see visible rust and I made mention of that. Now I am in a really tough spot. The truck only has around 130K miles on it and planty of useful life but for this faulty frame. Consumer stated attempted to access the benefits under the warranty recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11450876February 7, 2022
ENGINE
I was told of a coolant leak in my truck... Took it in to have it looked at and there is a bubble in the block that popped. Toyota current has the same issue with their 2.5 liter engines when a flow meter wasn't working properly causing issues with the casting of the engine blocks. I brought this to Toyota and they say its out of warrantee. This isn't a warranty issue its a safety issue now because if the vehicle looses all coolant it can overheat causing catastrophic failure to the engine. The service director told me personally that it wouldn't matter if I babied this truck or if I rode it hard the bubble would've popped either way. The pictures I sent are of the passenger side of the block on the left side of the motor mount.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11450734February 7, 2022
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owns a 2019 Toyota Tacoma. The contact stated while driving 60 MPH and depressing the accelerator pedal, the vehicle failed to accelerate. The contact stated that the traction control, collision control, and LSD warning lights were illuminated. The contact was able to continue driving and the warning light turned off independently. The contact took the vehicle to the local dealer where the vehicle was currently being serviced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 42,600.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11450428February 4, 2022
STRUCTURE:BODY
The paint is peeling off the top sections of both of my trucks rear doors. The paint appears to be peeling away down to either the primer or possibly the bare metal. This trucks paint code is 040 super white.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11450486February 4, 2022
UNKNOWN OR OTHER, STRUCTURE:BODY, SUSPENSION
On my last vehicle inspection, the mechanic told me that he will fail me next time due to a rotting frame. This is a serious safety hazard. Through my research, this is a common problem with this year truck (2008) and other years. To my knowledge, I was never contacted by Toyota as far as any recall. This truck still looks new and I am very dissapointed with what I read about this so called "Recall" has expired or about to expire in 2023. I would like very much to have this repaired. I don't know how to go about it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11450135February 3, 2022
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
The contact owns a 2011 Toyota Tacoma. Upon purchase of the vehicle, the contact received a Carfax report from the independent dealer that the vehicle had been placed under a service campaign for frame corrosion. The contact took the vehicle to a dealer where he was denied the service campaign because his vehicle was in a non-cold climate state. The manufacturer was also notified, and also denied his claim. The contact stated that he had discovered corrosion on the sub frame of the vehicle. The vehicle was not repaired. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11450175February 3, 2022
STRUCTURE
The contact owns a 2009 Toyota Tacoma. The contact stated while driving approximately 60 MPH, the tire hit the wheel well and the frame was ripped apart. The dealer sent a technician to the contact’s home to inspect the vehicle. The contact was informed that the sub frame needed to be replaced however, the vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer informed the contact that the vehicle was out of warranty. The failure mileage was approximately 250,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11449864February 2, 2022
ENGINE
The contact owns a 2020 Toyota Tacoma. The contact stated that while driving at 60 MPH, the vehicle inadvertently stalled temporarily. There were no warning lights illuminated. The contact was able to continue to drive the vehicle. The contact stated that the failure reoccurred for a second time while driving. The vehicle was taken to the dealer who diagnosed that no issues were found; however, the failure persisted. The manufacturer was notified of the failure but did not provide any assistance. The vehicle was not repaired. The failure mileage was approximately 5,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11449798February 1, 2022
WHEELS
While driving down the highway my front passenger wheel completely disconnected from the ball joint. There was nothing indicating that the wheel was even loose; no wobbling or shaking or grinding. Luckily the wheel itself slid under the frame of the vehicle and I was able to maneuver the truck off of the highway; a very serious crash could have occurred. Since that incident I have been witness to two other Toyota trucks suffering from the same sudden issue. One was a Toyota Forerunner of a similar year where its wheel had completely fallen off at the ball joint. Another was a 2004 or earlier model Toyota Tacoma. I was merely driving past these vehicles as they were off to the side of the road and saw that their respective front passenger-side wheels had fallen off in the exact same manner as mine had, with the wheels being dragged under the body / frames of the vehicles. I don't know if this amounts to some sort of defect in these model Toyotas but I find it highly suspicious that the front wheels are suddenly falling off of these vehicles while they are being driven.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma