Toyota Tacoma Complaints

8,484 consumer complaints on file.

#10574408March 24, 2014
SUSPENSION
TL* THE CONTACT OWNS A 1996 TOYOTA TACOMA. THE CONTACT STATED THAT THE FRAME ON THE REAR PASSENGER'S SIDE TIRE BECAME DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 189,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10574588March 24, 2014
STEERING, STRUCTURE:BODY
2005 TOYOTA TACOMA FIRST ISSUE IS THE STEERING, ON SEVERAL OCCASIONS WHILE TURNING THE STEERING HAS "LOCKED UP" , THE STEERING GETS EXTREMITY HARD TO TURN IN THE MIDDLE OF DRIVING. AFTER MY OWN RESEARCH I DISCOVERED THE UNIVERSAL JOINT ON THE STEERING SHAFT WILL LOCK UP OR GET EXTREMELY HARD TO TURN IF NOT GREASED. THE JOINT IS OPEN TO THE ELEMENTS AND HAS NO PROTECTIVE BOOT OVER IT. THERE IS NO MAINTENANCE PROCEDURE FROM TOYOTA FOR THE JOINT. THIS IS EXTREMELY DANGEROUS AND COULD CAUSE A CRASH. IF THE OPERATOR DOES NOT HAVE THE UPPER BODY STRENGTH TO FORCE THE STEERING WHEEL TO TURN WHEN THE JOINT LOCKS UP IT MAY CAUSE AN ACCIDENT. THIS ISSUE IS OFTEN MISDIAGNOSED BY MECHANICS CAUSE EXPENSIVE UNNECESSARY REPAIRS (NEW STEERING RACK). THE SECOND ISSUE IS FRAME RUST. THE FRAMES ARE A POOR DESIGN, HAVE NO PROTECTIVE COATING AND ARE MADE OF INFERIOR METAL. A SIMPLE INTERNET SEARCH FOR "TACOMA FRAME RUST" WILL SHOW PLENTY OF HORROR STORIES OF FRAMES LITERALLY RUSTING AWAY FROM THE BOTTOM OF THE TRUCK. THE OLDEST 2ND GENERATION TACOMAS (2005 PRODUCTION YEAR) ARE NOW 9 YEARS OLD, A FRAME ON A 9 YEAR OLD VEHICLE HAVING RUST ISSUES IS COMPLETELY UNACCEPTABLE. THIS IS A SERIOUS SAFETY HAZARD. ALONG WITH THE FRAMES RUSTING AWAY ALL COMPONENTS ATTACHED TO THE FRAME CAN FAIL. (LEAF SPRINGS, SHOCKS, MOTOR MOUNTS ETC). TOYOTA DID THE RIGHT THING WITH THE 1ST GENERATION TACOMAS THAT HAD THIS ISSUE. THEY ISSUED RECALLS AND BOUGHT BACK TRUCKS. CONSUMERS WERE LED TO BELIEVE THE FRAME RUST ISSUES WERE CORRECTED ON THE SECOND GENERATION TACOMAS BUT THEY WERE NOT. AS OF NOW TOYOTA IS HANDLING FRAME RUST ISSUES ON A CASE BY CASE BASIS. SOME PEOPLE ARE FIGHTING TO GET NEW FRAMES AND SOME PEOPLE ARE LEFT WITH A TRUCK THAT IS RUSTING AWAY WITH NO HELP FROM TOYOTA. FRAMES RUSTING AWAY TO THE POINT THAT A HOLE THE SIZE OF A HAND CAN FIT IS A MAJOR SAFETY ISSUE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10574591March 24, 2014
ENGINE, STEERING
TL* THE CONTACT OWNS A 2002 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING WHEEL SUDDENLY MALFUNCTIONED AND CAUSED THE VEHICLE TO BECOME UNCONTROLLABLE. THE CONTACT DISCOVERED THAT DURING THE INCIDENT THE STEERING RACK HAD FRACTURED. THE VEHICLE WAS REPAIRED BY THE CONTACT. IN A SECOND INCIDENT THE CONTACT INDICATED THAT WHILE DRIVING THE ENGINE SUDDENLY MALFUNCTIONED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT 2 PISTONS HAD COME THROUGH THE ENGINE BLOCK. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 129,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10574601March 24, 2014
VEHICLE SPEED CONTROL, FUEL SYSTEM, GASOLINE, SERVICE BRAKES
ON OCTOBER 2013 I APPROACHED A RED LIGHT (NO CAR IN FRONT OF ME) THE ROAD SURFACE WAS WET AND THE ABS KICKED IN. WHEN I APPLIED THE BRAKE HARD, THE ENGINE STARTED TO ACCELERATE AND I COULDN'T HOLD THE TRUCK BACK. I WENT THROUGH THE RED LIGHT AVOIDING AN ACCIDENT. I CALLED THE TOYOTA DEALER AND WAS TOLD THAT I PROBABLY DID NOT PRESS DOWN ON THE BRAKE HARD ENOUGH. ON JANUARY 2014 THE SAME THING OCCURRED. HERE AGAIN I WAS FORTUNATE THAT ANOTHER VEHICLE WAS NOT IN FRONT OF ME AND THIS TIME I WENT THROUGH A STOP SIGN. I CALLED THE DEALER AND HAD IT CHECKED OUT. THEY FOUND NOTHING WRONG. MARCH 15TH IT HAPPENED AGAIN. ONCE AGAIN I WAS LUCKY THAT NO VEHICLE WAS IN FRONT OF ME, BUT I NOW BRAKE WAY IN ADVANCE OF A LIGHT OR STOP SIGN BECAUSE OF FEAR. THIS TIME WHEN THE ENGINE STARTED TO ACCELERATE I GOT OFF THE BRAKE AND WENT RIGHT BACK ON AND THE ENGINE STOPPED ACCELERATING. I ONCE AGAIN PUT IT IN THE GARAGE AND THEY FOUND NOTHING WRONG. I THINK THAT THE UNINTENTIONAL ACCELERATION IS TRIGGERED WHEN HARD PRESSURE IS APPLIED TO THE BRAKES WHEN THE ABS KICKS IN. I'M NOT A ROOKIE DRIVER. I'VE BEEN DRIVING TACOMAS FOR OVER 30 YEARS. THIS IS MY 4TH ONE. AFTER HAPPENING THREE TIMES, IT IS DEFINITELY A PROBLEM WITH THE TRUCK. THIS IS A POSSIBLE SERIOUS ACCIDENT WAITING TO HAPPEN. WHAT CAN I DO TO GET TOYOTA TO CORRECT THIS PROBLEM? THANK YOU *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10574142March 22, 2014
POWER TRAIN
TOYOTA TACOMA 4X4 ACCESS CAB, 5SP, 2.7 LITER. CLUTCH FAILING AT 40000 MILES. TOYOTA REFUSES TO OFFER ANY ASSISTANCE WITH THE $2200 REPAIR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10574163March 22, 2014
POWER TRAIN
OIL CHANGED AT TOYOTA DEALER, MECHANIC DISCOVERED REAR DIFFERENTIAL LEAK. TOOK THE VEHICLE TO PRIVATE MECHANIC AND DISCOVERED THE REAR DIFFERENTIAL LEAK WAS CAUSED BY RUST TO THE BODY. THE 2004 TACOMA HAD ONLY 27,000 ORIGINAL MILES WHICH WAS BROUGHT NEW. WEB SEARCH DISCOVERED 20 COMPLAINTS AT LEAST ON THE DIFFERENTIAL RUSTING THRU. TALKING TO THE MECHANIC REVEAL THIS CAN BE A CATASTROPHIC EVENT ON A HIGHWAY WITH THE WHEELS LOCKING UP CAUSING FATALITIES. TOYOTA DEALERS CONTACTED PROVIDED NO HELP OR DID NOT RETURN PHONE CALLS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10573790March 20, 2014
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
WAS ADVISED OF SEVERE RUST PROBLEM ON FRAME OF VEHICLE BY INDEPENDENT GARAGE. BROUGHT VEHICLE TO LOCAL TOYOTA DEALER FOR INSPECTION AFTER OPENING A CASE WITH TOYOTA (1308190057). DEALER SERVICE MANAGER WROTE ON INVOICE "ADVISED CUSTOMER THAT HOLE IN FRAME FRT LEFT SIDE CALL #800 NUMBER FOR TOYOTA NO PROGRAMS OR WARRANTY AT THIS TIME. ADVISE CUSTOMER TO FIX FRAME BEFORE DRIVING CANNOT TELL IF THERE ARE ANY OTHER SPOTS IN FRAME THAT WILL RUST THRU. ADVISE CUSTOMER TO FIX FRAME BEFORE DRIVING VEHICLE." THERE IS A GREAT DEAL OF RUST ON THE FRAME AND VARIOUS OTHER PARTS UNDER THE VEHICLE, AS EVIDENCED BY MY INSPECTION AND LARGE RUST STAINS ON MY DRIVEWAY. SENT LETTERS TO TOYOTA REGIONAL OFFICE IN NJ AND TO THE GENERAL MANAGER OF THE LOCAL DEALERSHIP, BOTH OF WHICH WENT UNANSWERED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10573851March 20, 2014
EXTERIOR LIGHTING
TL * THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT STATED THAT THE HEADLIGHT LENS WOULD CONTINUOUSLY OVERHEAT AND BECOME CRACKED. THE CONTACT WAS CONCERNED THAT THE VEHICLE WOULD POSSIBLY CATCH ON FIRE SINCE THE BULB WAS SO CLOSE TO THE LENS. THE VEHICLE WAS NOT TAKEN FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 100,000. UPDATED 3/13/14*CN
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10573863March 20, 2014
EXTERIOR LIGHTING
TL* THE CONTACT OWNS A 2009 TOYOTA TACOMA. THE CONTACT STATED THAT THE LENSES FOR THE DAYTIME RUNNING LAMPS AND THE TURN SIGNALS WERE MELTED. THE CONTACT WAS CONCERNED THAT THE FAILURE COULD LEAD TO A FIRE. THE DEALER WAS CONTACTED AND ADVISED THAT THE ENTIRE LIGHTING ASSEMBLY WOULD REQUIRE REPLACING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT PROVIDED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 40,000. THE CURRENT MILEAGE WAS 100,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10573325March 19, 2014
SUSPENSION, STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
I AM THE ORIGINAL OWNER OF A 2005 TOYOTA TACOMA PICK UP LISTED ABOVE. BACK IN THE FALL OF 2013 I WAS ADVISED BY MY LOCAL MECHANIC THAT MY TRUCK HAD FRAME ROT NEAR THE FRONT PASSENGER SIDE OF THE VEHICLE. I BROUGHT THE TRUCK TO LIA TOYOTA IN COLONIE, NY AND THEY DOCUMENTED THE PROBLEM. SEVERAL MONTHS PAST AND I DID NOT HEAR ANYTHING BACK FROM THEM. I CALLED THE NATL CUSTOMER SERVICE AT 800-331-4331, WHO ADVISED THAT THE PROBLEM WAS DOCUMENTED, CASE #9735757600. I HAVE BEEN BACK AND FORTH WITH THE LOCAL DEALER BUT TO NO AVAIL. I AM NOT GETTING ANY FEEDBACK. I KNOW THAT TOYOTA HAS HAD PROBLEMS WITH FRAME ROT IN THE PAST AND IT WAS SUPPOSEDLY RECTIFIED BUT APPARENTLY NOT. I AM JUST TRYING TO FIGURE OUT WHAT I DO NEXT. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10573341March 19, 2014
SUSPENSION
I HEARD A RATTLING NOISE FROM THE RIGHT REAR OF THE TRUCK WHILE DRIVING ON A BUMPY SIDE ROAD. I INVESTIGATED AND DISCOVERED THE BOTTOM LEAF SPRING HAD BROKEN IN HALF. DOING SOME ONLINE RESEARCH I DISCOVERED THAT THIS IS A VERY COMMON PROBLEM WITH TACOMA'S. I CONTACTED THE DEALER AND IT IS NOT A COVERED ITEM (NO TBS) AND IT WOULD COST OVER $1800. I WENT TO MY LOCAL MECHANIC WHICH SAVED ME $700. DURING THE REPAIR IT WAS DISCOVERED THAT BOTH RIGHT AND LEFT WERE BROKEN. MY MECHANIC INFORMED ME THAT THIS IS A VERY COMMON PROBLEM; THAT TOYOTA LENGTHENED THE SPRINGS TO SOFTEN THE RIDE, AS A RESULT COMPROMISED THE STRENGTH. THE LEAF SPRINGS HAVE ALWAYS SQUEAKED JUST BY GETTING IN AND OUT OF THE TRUCK. THERE IS A STICKER ON THE DOOR FRAME STATING THAT THE LOAD RATING HAS BEEN REDUCED BY 290 LBS FOR THIS VEHICLE, I WONDERED WHY NOW I KNOW, CHEAP SPRINGS! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10573578March 19, 2014
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
TOYOTA HAS BLATANTLY STATED THEY PUT FAULTY FRAMES ON THEIR 2003 TACOMAS AND AS A RESULT OF THIS, THE FRAMES WOULD RUST BECAUSE OF COATING NOT BEING PUT ON PROPERLY. TOYOTA EVEN WON A LAWSUIT FROM THE COMPANY WHO MADE THE FRAMES. NOW, TOYOTA DOES NOT WANT TO MAKE GOOD ON THE RUSTED FRAMES ON THESE TACOMAS. OUR FRAME MAY NOT PASS INSPECTION DUE TO THE RUST AND IF IN THE EVENT, THIS FRAME CAUSES HARM TO MY FAMILY, A LAWSUIT WILL BE FILED BY ME AGAINST TOYOTA. AFTER MANY CONTACTS VIA EMAIL AND PHONE, TOYOTA STATES THAT WE DID NOT CONTACT THEM IN THE TIME FRAME THEY GAVE REGARDING THE FRAME PROBLEM. WELL, YOU ONLY CONTACT A COMPANY ABOUT SOMETHING WHEN THE PROBLEM IS BROUGHT TO YOUR ATTENTION AND IN OUR CASE, WAS TOO LATE. THERE SHOULD NOT HAVE BEEN A TIME FRAME PUT ON THIS AND THERE SHOULD HAVE BEEN A RECALL DONE ON ALL THESE FRAMES. WHEN A PERSON DIES FROM THESE RUSTED FRAMES BREAKING IN HALF WHILE DRIVING, THEN MAYBE SOMEONE WILL DO SOMETHING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10573040March 18, 2014
POWER TRAIN
CLUTCH SLIPS GOING UP HILL. YOU HAVE TO DOWNSHIFT WHEN GOING UP HILL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10573204March 18, 2014
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS ADVISED THAT THE UNDER CARRIAGE WAS EXTREMELY RUSTED. THE MECHANIC STATED THAT THE ENTIRE FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 180,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10572641March 16, 2014
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
I HAD THIS VEHICLE INSPECTED BY TOYOTA AND THEY STATED SURFACE RUST ON FRAME. THIS VEHICLE ONLY HAS 47000 MILES AND THE RUST IS NOT SURFACE RUST, IN MY OPINION, FOR THE MILEAGE. THE VEHICLE WILL CONTINUE TO DETERIORATE IF TOYOTA DOESN'T DO SOMETHING ABOUT REPAIRING OR REPLACING THE FRAME. TOYOTA HAS RECALLED 1995.5 THROUGH 2004 AND HAVE REPAIRED OR REPLACED FRAMES. TOYOTA NEEDS TO CONTINUE THEIR RECALL TO INCLUDE LATER VEHICLES WITH RUSTING PROBLEMS. IF TOYOTA DOES NOT STEP UP TO CORRECT THIS RUSTING PROBLEM IT WILL, IF IT HASN'T ALREADY BECOME A NATIONAL SAFETY PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10572517March 15, 2014
POWER TRAIN
AT FIRST ABOUT 6 MONTHS AGO , CAR STARTED VIBRATING AT LOW SPEED AND DISAPPEAR AT HIGHER SPEED. ON 3/13/14 TRAVELING A ABOUT 30MPH , THERE WAS A SUDDEN VIBRATION (CAR SHAKING VIOLENTLY ) THEN A LOUD BANG UNDERNEATH THE DRIVER SIDE. GLIDED THE CAR ALONG SIDE THE ROAD, DID A VISUAL INSPECTION UNDER THE CAR AND NOTICE THE FRONT PROPELLER SHAFT WAS HANGING THERE. MY TRUCK HAS BEEN EXPOSE TO CARRYING HEAVY LOAD. THE HEAVIEST LOAD THAT THIS TRUCK CARRIED WAS AN UPRIGHT FREEZER THAT I BOUGHT FROM K-MART. IS MY TRUCK INCLUDED IN THAT 2007 FOR DRIVETRAIN PROBLEM??? IF SO WHERE CAN I GET INFO ON THIS? MY PROBLEM IS VERY SIMILAR TO THE 2007 RECALL ON BAD CASTING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10572574March 15, 2014
SUSPENSION, STRUCTURE:BODY
THE FRAME OF THE TRUCK IS RUSTING OUT AT AN ACCELERATED RATE. THE WELDS ARE RUSTING OUT AT HIGH STRESS POINTS (ENGINE MOUNTS AND SUSPENSION AREAS). TOYOTA HAS A HISTORY OF THIS PROBLEM WITH THE TACOMA. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10572580March 15, 2014
POWER TRAIN
I SEEM TO HAVE AN INTERMITTENT CLUTCH ISSUE WITH MY TACOMA. WHEN THE OUTSIDE TEMPERATURES ARE COLD (BELOW FREEZING) AND THE TRUCK HAS BEEN SITTING OVER NIGHT, THE CLUTCH PEDAL IS SLOW TO RETURN. I HAVE BEEN HAVING THIS PROBLEM SINCE WINTER SET IN HERE IN SC. BUT UNTIL 3-14-2014, THIS HAS BECOME A SAFETY CONCERN. I WAS COMING OUT OF MY NEIGHBORHOOD AND CAME UP TO A STOP AT A STOP LIGHT WHICH IS ON A HILL. AS I WAS SITTING THERE A MOPED CAME UP BEHIND ME. DUE TO THE TRUCK AND OUTSIDE TEMPERATURE BEING BELOW FREEZING, THE CLUTCH PEDAL WAS AS USUAL, SLOW TO RETURN. DUE TO THE CLUTCH BEING SLOW TO RETURN AND ME BEING ON A HILL, I WASN'T ABLE TO LAUNCH THE TRUCK FAST ENOUGH AND ALMOST ROLLED OVER THE PERSON ON THE MOPED BEHIND ME. WITH THIS CONDITION, THE TRUCK CAN BE A SAFETY, AND ACCIDENT HAZARD. IT IS A COMMON PROBLEM ON THIS TRUCK AFTER THOROUGH RESEARCH. THE TRUCK HAS ALSO BEEN INTO THE SHOP 4 TIMES FOR REPAIRS, AND 1 TIME TO DOCUMENT THE PROBLEM STILL EXISTS AFTER THE 3 FIRST REPAIRS. I HAVE BEEN DRIVING MANUAL CARS FOR CLOSE TO 10 YEARS NOW, AND I HAVE NEVER HAD A PROBLEM WITH A CLUTCH BEING SLOW TO ENGAGE WHEN ITS COLD OUTSIDE. TOYOTA NEEDS TO FIX THIS PROBLEM BEFORE SOMEBODY GETS HURT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10572500March 14, 2014
SUSPENSION, STRUCTURE:BODY
I TOOK MY TRUCK TO GET IT INSPECTED AND THEY SAID THERE ARE HOLES IN THE FRAME A LARGE AS MY HAND. IT WILL NOT PASS INSPECTION AND CANNOT BE DRIVEN. I HAVE BEEN DRIVING MY 2 LITTLE SONS AROUND IN THIS VEHICLE WHICH HAS BEEN UNSAFE FOR A LONG TIME. THE HOLES ARE BIG ENOUGH TO HAVE STARTED YEARS AGO AS A SMALL HOLE WHICH MAKE THE TRUCK UNDRIVABLE. I HAVE A NICE LOOKING TRUCK THAT CANNOT BE DRIVEN. THE 1ST GENERATION TACOMAS WERE RECALLED FOR THIS SAME REASON. WHAT IS TOYOTA GOING TO DO? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10569016March 13, 2014
STEERING, SUSPENSION
TL* THE CONTACT OWNS A 2003 TOYOTA TACOMA. THE CONTACT STATED THAT THE AXLE, POWER STEERING LINES AND OIL PAN WAS SEVERELY RUSTED. THE CORROSION WAS SO SEVERE THAT IT CAUSED A FRACTURE ON THE POWER STEERING LINE. THE CONTACT TOOK THE VEHICLE TO THE DEALER TO BE REPAIRED. THE DEALER REPLACED THE FRAME AND ADVISED THE CONTACT THAT THE FAILURE WAS CAUSED BY ENVIRONMENTAL FACTORS. THE VEHICLE WAS REPAIRED. THE MANUFACTURE WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. THE CURRENT MILEAGE WAS 118,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tacoma