Toyota Highlander Complaints

958 consumer complaints on file.

#11756472August 12, 2026
SEATS
The contact owns a 2021 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 26V128000 (Seats). The contact stated that while the vehicle was parked, the contact attempted to lower the second-row seats, and the seat failed to lock into position and failed to recline as intended. The vehicle was taken to a dealer approximately five months later when a remedy became available, and the recall repair was attempted, but the dealer stated that the spring was replaced; however, the spring did not allow for the second-row seat to latch or lock securely. The manufacturer was not notified of the failure. The failure mileage was 58,900.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755981August 10, 2026
POWER TRAIN
I have a 2023 Toyota Highlander XSE with 77,015 miles on it. Last week we noticed that when pushing on the gas pedel to accelerate that the car started making a terrible whinning noise that did not go away. i scheduled a service call with dealership i purchased it from and where i take it for all of its scheduled service and they canfirmed that the transmission was failing and needed to be replaced so the problem has been confirmed by the dealership. In addition i contacted the toyota help line and asked for a Goodwill Warranty Assisstance case to be opened which is now under review. prior to the noise there were no indication of an issue such as warning lights messages or other symptons. To date there was no harm done to me or other individuals
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755975August 10, 2026
SERVICE BRAKES
I had the dealer perform the repair described in Toyota Technical Service Bulletin T-SB-0059-23 (Hybrid Regenerative Brake Transition Feeling Improvement), which reprograms the brake actuator control module. Following this repair, the vehicle continues to exhibit the same lurching behavior at the same frequency as before the update. The TSB did not resolve the underlying condition. This is a safety concern because the unpredictable brake transition affects the driver’s ability to judge stopping distance and vehicle behavior in real time, particularly in traffic or on downgrades. The vehicle now has over 36,000 miles, placing it outside Toyota’s Basic Warranty; however, this is a safety issue that should be addressed by a recall. I am aware of numerous other Highlander Hybrid and Sienna Hybrid owners reporting the same defect, including reports that the same TSB reflash failed to resolve the issue for them as well.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755623August 8, 2026
STRUCTURE:BODY, UNKNOWN OR OTHER
This is a formal report of Recall Non-Compliance regarding Safety Recall 23V-720 (Toyota Recall 23TA12) on my 2021 Highlander Hybrid. An authorized dealership performed the recall on May 6, 2024, utilizing Op Code 23TA12R1 (Inspection & Install Fasteners). The dealership only addressed the lower bumper and failed to properly remedy the upper bumper retention tabs, stating it isn’t part of recall. The upper bumper cover has completely separated from the fenders during normal daily driving. The upper plastic mounting slots are torn out and clips will not hold. The dealership is refusing further repairs, instructing me to file a car insurance claim or pay a body shop myself to correct an un-remedied federal safety defect. The vehicle currently remains an active structural road hazard because the official recall remedy completely failed to secure the bumper assembly from detaching. A TAS case has been opened at the dealer, but federal intervention is requested to ensure recall compliance.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755412August 7, 2026
SEATS
The contact owns a 2023 Toyota Highlander. The contact received notification of NHTSA Campaign Number: 26V128000 (SEATS); however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the second-row seat failed to lock in position as designed. The failure mileage was 39,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755225August 6, 2026
EXTERIOR LIGHTING
The headlights on this vehicle are not properly aimed and or poorly designed causing excessive glare to oncoming traffic. Even during broad daylight I could see the light scattered all around the headlight assembly appearing as though the high beams were shining directly at me. E Also excessively bright sparkly headlights like these are distracting impairing my situational awareness.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754929August 5, 2026
SERVICE BRAKES
2023 Toyota Highlander Hybrid Regenerative Brake Transition loss of brake pad pressure resulting in acceleration of the vehicle under downhill conditions. Have momentarily experienced the loss of braking frequently during braking when going downhill. This results in the vehicle gaining speed during this 1 or 2 second period before braking returns. In one case it allowed our car to get dangerously close to the vehicle ahead of us but fortunately I was able to push the brakes harder to prevent an accident but did require aggressive braking. Luckily no one was behind us which may have resulted in the person following us braking hard or possible hitting us. This was a known issue for previous year Toyota Highlander models and Toyota issued service bulletin T-SB-0059-23 which is stated to only be for model years 2020 - 2022. So, Toyota dealers say they do not have a fix that applies to the 2023 model. It has been indicated that the dealer is unaware if any action is being taken by Toyota to address this issue in the 2023 and later models. We have multiple people driving this vehicle and this sudden loss of braking power is very concerning. The loss of braking force occurs upon the transition from regenerative braking to standard hydraulic breaking. Below are words from the Toyota Technical Service notice concerning the problem. "Highlander Hybrid vehicles may be sensitive to the momentary transition from regenerative braking to hydraulic braking under certain driving conditions, such as while driving downhill, or turning with light brake pedal application. The brake actuator control module can be updated to improve brake feeling for this condition. Follow the Repair Procedure in this bulletin to address this condition."
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754750August 4, 2026
POWER TRAIN
My transmission started to have a noticeable whine at 53k miles. It became noticeably louder during acceleration. It was diagnosed at the Toyota dealership as a failing transmission. My vehicle was a few months out of warranty. I was told to contact Toyota corporate to ask for assistance. I was told since I did not have a service record at the dealership, they would deny my claim. I advised them the transmission was a sealed unit with no dipstick. My vehicle has been meticulously maintained with records. They said sorry, and the conversation ended.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754631August 4, 2026
POWER TRAIN
Vehicle is experiencing a distinct, high-pitched mechanical whine or grind sound from the transmission during acceleration that increases in pitch with vehicle speed. The noise does not happen while cruising or coasting. This symptom aligns directly with Toyota Technical Service Bulletin T-SB-0008-21 ('Whine or Grind Noise From Transmission'). I am concerned about a premature, catastrophic internal bearing or gear assembly failure of the UA80 8-speed transmission while driving at highway speeds, which poses a severe sudden loss of propulsion safety risk.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754021July 31, 2026
POWER TRAIN
High pitched whirring from engine when accelerating. Took to mechanic who diagnosed worn internal transmission bearings that could lead to transmission failure. No warning lights or indicators. Toyota is aware of this issue (see Toyota Technical Service Bulletin T-SB-0008-21) but is doing nothing in response.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753999July 31, 2026
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
I was backing up the vechial accelerated the steering wheel was turning rapid & a grinding noise causing me too hit another vechial about a month before my husband was driving & the vechial accelerated going toward also we had had some issues with back camera not doing a warning signal with a object behind vechial when the accident happened my vechial has braking system that stops you if something is behind you this time it didn’t I called the dealership when accident happed which was May 21 2026 & reported it they said they had accelerations before & advised me to call Toyota engadgment which I did they did a diagnostic test June 5 & to this day I’ve never heard back from them
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11753982July 31, 2026
VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
The contact owns a 2023 Toyota Highlander. The contact stated that while attempting to start the vehicle, the driver’s and passenger’s side mirrors moved downward independently, causing the contact to manually adjust the side mirrors. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed; however, the diagnostic result was unknown. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 28,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753830July 30, 2026
FUEL/PROPULSION SYSTEM
Vehicle has strong gas smell and has gas vapor streaming out from under rear driver side wheel well and gas cap area.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753805July 30, 2026
POWER TRAIN
This vehicle was purchased new in 2021 with 4 original miles. Today it has 58,000 miles and has been maintained, per manufacturer recommendations, a certified Toyota dealership. At around 56,000 miles we noticed a slight whine in first gear. This was attributed to normal noise that we simply had not noticed. by 58,000 miles the while had extended to all gears and become more prominent. Research online shows that this is a known issue with the UH80 transmissions and has been since at least 2017. Toyota has a TSB for it (TSB-0008-21). This was not mentioned at the time of purchase or any of the various maintenance appointments in the last 5 years. This KNOWN issue WILL lead to complete transmission failure. This can happen while parked or in motion and can include the transmission shifting out of an active gear, locking into a gear and being unable to shift to another or park/neutral and there is no way to avoid it. I called Toyota corporate about this because I was not made aware of the TSB until July of 2027 and was advised that, although I was below the 60,000 mile allowance, I had surpassed the 60 month coverage period by two months and would not be granted a warranty exception (Toyota case number: 260710000821). Due to a known defective part on a vehicle that Toyota sold without advisement of said known issue, I am expected to pay $8,000 in repair fee's for a 40,000 dollar car that I have already spent over $20,000 on. The dealership confirmed the issue on 7/28/2026 and are attempting to use my 3rd party warrant which only covers parts. I will still be expected to pay for the labor costs which they expect to land between 2-3k dollars. Toyota is knowingly allowing a defect to persist that puts their customers and anyone else on the road at the time, at risk of serious injury and death. They expect their customers to cover the cost of repairs for an issue that they were aware of at the time of sale
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753720July 30, 2026
FUEL/PROPULSION SYSTEM
On July 25, 2026, while driving my 2021 Toyota Highlander Hybrid at high speeds on the freeway, the vehicle experienced a sudden loss of drive power accompanied by a check engine light and a severe hybrid system error warning. The failure occurred without any prior warning or degradation in performance, forcing an immediate emergency maneuver through traffic to reach the shoulder. The vehicle was towed to Toyota of El Cajon for diagnostic evaluation. The dealership service invoice details the following findings: - Primary Failure: Primary fuel injector failure (direct injection system). - Diagnostic Behavior: The engine experienced severe cylinder misfires under load at freeway speeds when the direct injectors were commanded on. - System Impact: Engine misfires triggered a hard safety shutdown of the hybrid system, immediately cutting motive power to the wheels. - Repair Executed: Replacement of the failed fuel injector assembly Safety Concern: A primary fuel injector failure at highway speeds causes an instantaneous engine misfire under load, which immediately triggers a hard hybrid drive system shutdown. Cutting motive power suddenly in heavy traffic without advance warning creates an extreme hazard for rear-end collisions. I am requesting NHTSA document and investigate this failure mode and its automated system shutdown logic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753668July 30, 2026
POWER TRAIN
The transmission developed hesitations at take off, a whine at low speeds and over time got louder. Diagnosis by the dealer confirmed yet another bad eight speed transmission failure. This vehicle has 41K miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753484July 29, 2026
POWER TRAIN
The contact owns a 2021 Toyota Highlander. The contact stated that while driving 25 MPH, there was an abnormal whining sound coming from the engine. The vehicle was taken to the dealer, where it was diagnosed with transmission failure due to a pinion shaft failure. The dealer determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 62,300.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753168July 27, 2026
UNKNOWN OR OTHER
Transmission is shifting very hard including a clunking noise from first gear.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753127July 27, 2026
AIR BAGS
Was in collision - front impact- vehicle was a total loss, airbags did not deploy for driver or passenger side
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11752111July 22, 2026
AIR BAGS, SEAT BELTS
I WAS IN A HEAD ON COLLISION AND SEAT BELT DIDN'T HOLD ME IN PLACE AND AIRBAG DID NOT DEPLOY. I HIT THE STEERING WHEEL.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0

← Back to Toyota Highlander