Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2003-2008 Corolla, 2005-2008 Corolla Matrix, and Pontiac Vibe vehicles equipped with a front passenger air bag assembly replaced under a prior recall. The air bag may not unfold as designed during inflation under high temperature conditions, possibly resulting in the air bag not inflating properly.
On January 9, 2018, Toyota Motor Engineering & Manufacturing (Toyota) notified NHTSA that they are recalling 14,585 model year 2010-2012 Yaris vehicles ever registered in the states of Alaska, Arizona, Arkansas, Colorado, Connecticut, Delaware, District of Columbia, Idaho, Illinois, Indiana, Iowa, Kansas, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, Montana, Nebraska, Nevada, New Hampshire, New Jersey, New Mexico, New York, North Carolina, North Dakota, Ohio, Oklahoma, Oregon, Pennsylvania, Rhode Island, South Dakota, Tennessee, Utah, Vermont, Virginia, Washington, West Virginia, Wisconsin, and Wyoming. As of January 30, 2018, Toyota is additionally recalling 3,347 model year 2010 Pontiac Vibe vehicles located in states listed above. Also included in this recall filing is 98,194 model year 2003-2008 Toyota Corolla Matrix vehicles, located throughout the U.S., that previously received a Âlike-for-like interim air bag inflator replacement. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.
Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.
Vehicle keeps stalling while driving if stopped at a light or stop sign or if mrps drop to low engine shuts off lights flicker and no check engine light has come on.
No injuries · No fire · No crash
The contact owns a 2007 Toyota Matrix. The contact stated while driving approximately 45 MPH, the vehicle stalled. The contact stated that several unknown warning lights started flashing and the RPM gauge fluctuated from a low RPM to high RPM. The contact stated that he pulled over and attempted to restart the vehicle. The contact stated that the vehicle failed to restart. The contact had a voltmeter and checked the battery and noticed that the battery was low on charge. The contact had recently installed a new battery. The contact jump started the vehicle and was able to shift into drive (D) however, the vehicle was hesitating and not responsive while depressing the accelerator pedal. The contact stated that the failure was intermittent but had become a recurring failure. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed or repaired. The manufacturer had been informed of the failure. The contact had requested vehicle history from the manufacturer and determined that the Electronic Control Unit had been replaced in 2011 under NHTSA Campaign Number: 10V384000 (Engine and Engine Cooling). The failure mileage was approximately 131,000.
No injuries · No fire · No crash
The contact owns a 2007 Toyota Corolla Matrix. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a transmission center and the contact was informed that the vehicle had experienced the failure listed in NHTSA Campaign Number: 10V384000 (Engine and Engine Cooling). The vehicle was taken to the dealer and it was confirmed that the VIN was not included. The manufacturer was contacted and the contact was referred to the NHTSA for assistance. The failure mileage was 143,000.
No injuries · No fire · No crash
I have been waiting over 2 years for this passenger side airbag recall to be remedied. I was told a remedy was available about a year and a half ago, but despite many calls and service appointments where I left the car with Toyota (they even kept my car for nearly 9 hours once), they always tell me they don't have the part available and that they will call me when it becomes available (they still haven't). I tried multiple Toyota service centers in my area with the same results. The airbag was already recalled previously and the remedy was to replace it with an airbag part that was also recalled, so in actuality it has probably been over 5 years since the original recall and after all this time my car still has an airbag inflator that may cause fire, injury or death. I paid for a car so I could use all of the available seating, and for most of my time owning it and for the foreseeable future I'm being told by Toyota not to use the front passenger seat. Totally unacceptable, regardless of parts shortage this shouldn't be a problem to bear solely by the vehicle owner, I have never been offered a loaner or anything to make up for the money I wasted on a car I can't use as advertised.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2007 TOYOTA COROLLA MATRIX. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, THE VEHICLE STALLED WHILE ATTEMPTING TO ACCELERATE AND APPROXIMATELY 20 SECONDS LATER, THE ENGINE SUDDENLY OPERATED AS NORMAL AND THE DRIVER WAS ABLE TO DRIVE NORMALLY. THE FAILURE HAD OCCURRED ON SEVERAL OCCASIONS. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER HOFFMAN TOYOTA LOCATED AT 36 ALBANY TURNPIKE, WEST SIMSBURY, CT 06092 AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V384000 (ENGINE AND ENGINE COOLING). THE CONTACT INDICATED THE VEHICLE HAD EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 81,000.
No injuries · No fire · No crash