Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Toyota Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, Lexus RX350, 2023-2024 NX250, and NX350 vehicles that may have been incorrectly repaired under previous NHTSA recall number 23V-480. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Corolla Cross vehicles that were previously inspected at a dealership under recall 23V-384. The instrument panel may have been produced without the required perforation, which could result in the front-passenger air bag not deploying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023 Corolla, Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Tacoma, 2023 Lexus RX350, RX350 Hybrid, RX500 Hybrid, 2023-2024 Lexus NX250, NX350, and NX350 Hybrid vehicles. An electrical connection inside the steering column's spiral cable assembly may be insufficiently welded, causing the connection to separate and deactivate the driver's air bag. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2023 Corolla Cross vehicles. The instrument panel may have been produced without the required perforation, which could result in the front-passenger air bag not deploying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safey Standard number 208, "Occupant Crash Protection."
UNKNOWN ALL THE LIGHTS AND BEEPS BECOME ON WHILE DRIVING THE CAR
No injuries · No fire · No crash
The contact owns a 2024 Toyota Corolla Cross. The contact stated that twice while driving at various speeds and slowing down to make a turn, the brake pedal was depressed but the vehicle failed to slow down as intended and the steering wheel locked up. During the first failure, while the contact’s husband was driving, the vehicle lost power. The vehicle was driven to a gas station and then restarted. The vehicle was then taken to the residence. The contact stated that during the second failure, while the contact was driving at an undisclosed speed, the brake pedal was depressed and the vehicle failed to slow down, and the steering wheel locked up. The vehicle ran over a sidewalk with cinderblocks and stopped sideways in the middle of two lanes. The contact attempted to move the vehicle, but the vehicle lost power. The vehicle was restarted and then moved to the side of the road safely. The contact stated that the seat belt failed to tighten. The contact sustained neck, shoulder, back, and head injuries with dizziness. Medical attention was needed. A Police report was filed, but the information was not available. The vehicle was then towed to a tow yard. The vehicle had not been diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 50,000.
I turned on the car after it had been sitting in the hot sun for about 4 hours (after a 180 mile trip). When I turned on the vehicle, about a minute into driving (on a gravel driveway), the car started blaring multiple lights and the steering wheel locked. Notifications were “System Failure" & "Electric Power Steering Malfunction - please contact dealer.” The steering wheel completely locked/uncontrollable - 3 others tried to help me. I was going ~5 mph when it happened. I was able to put the car into park & turned it off for 10min. On restart, the car acted normal again. If this happened while driving at a high speed I believe it would result in serious injury or death. This is the second episode. The first time it happened (XXX), Toyota did a full inspection/scan of the car but couldn't reproduce the issue despite confirming it was documented in the car's system log. This time, I emailed toyota same day. The car has now been at dealer for 4 days. They haven’t been able to reproduce the issue despite acknowledging both times that the events are documented in the car's log. The dealer recommended replacing the ECU. Unfortunately, toyota corporate claims they "cannot replace it without reproducing the issue" which is ridiculous given that the issue is inherently unpredictable (which is what makes it terrifying) yet irrefutably present. I am concerned I will die due to a malfunctioning steering wheel before toyota corporate will take it seriously. I do not feel safe driving the car now that this has inexplicably happened 2x. Multiple people online reported a similar issue [XXX]; the sounds occurring during the linked video are similar to my event. The main difference is that my car never once said low battery; no engine problems, never have had a dead battery. I was even able to drive 180 miles home that night (praying the whole time cause I had no other choice in a rural area). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
The contact owns a 2026 Toyota Corolla Cross. The contact received notification of NHTSA Campaign Number: 25V869000 (Hybrid Propulsion System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was taken to the dealer, who inspected the inverter and determined that the inverter needed to be replaced; however, the part to do the recall repair was not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 1,679.
No injuries · No fire · No crash
I had left work less than 2 miles away. I was sitting at red light. The light turn green I took my foot off brake my screen went black and power failed. I put it in park and it restart. Power came back on. I turn off A button and drove 22 miles home with no known issues. No warning lights had came on. I found this to be a dangerous situation in traffic. 2 weeks ago I had taken my car for oil change, tire rotation and had a brake flush to dealership in Spanish fort Daphne, AL. I currently have 37,688 miles on car.
No injuries · No fire · No crash