Tesla Model 3 Complaints (2023)

417 consumer complaints on file.

#11728177March 31, 2026
STRUCTURE:BODY, ELECTRICAL SYSTEM
I am reporting a serious safety incident involving a 2023 Tesla Model 3. On March 29 at approximately 5:00 PM, while driving on the freeway at about 65 mph, the right-side passenger door suddenly opened while the vehicle was in motion. The door had been fully closed and latched prior to driving. There was no impact, obstruction, or warning indicating that the door was not secure. The opening occurred unexpectedly during normal driving conditions, creating a significant safety risk. After the incident, Tesla was contacted and indicated that a diagnostic inspection would require a fee, and they suggested the possibility of prior modification or tampering but did not provide a confirmed cause. The vehicle was purchased from a used car dealership, and the incident raises concerns about a potential mechanical or electronic failure of the door latch system and the safety of the vehicle as sold.This issue poses a serious risk to occupants and other road users, particularly at highway speeds. I am requesting that this incident be reviewed as a potential safety defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726564March 23, 2026
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The Full Self Driving (Supervised) system (FSD(S)) failed by running a red light. Video is available for inspection upon request. My safety was not at risk - this time - because the system waited until there was no cross traffic to resume motion, even though the light was still red. I have not tried to reproduce the problem for a dealer since it happens infrequently. (This is the third time in perhaps 6 months of subscription to TESLA's FSD(S). TESLA has not informed me of any inspections they have performed, even though they have been notified through the channel they provide. There was no indication from the car that it perceived any failure. It stopped only when I applied the brake. Prior symptoms include two previous incidents of stopping for a red traffic light, waiting until there was no cross traffic, then resuming motion while the traffic light was red. This is the first time I thought to save dash cam video.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725899March 20, 2026
STRUCTURE:BODY
Reporting a stress fracture in the front windhsield of my model 3 tesla. Looking online and speaking to attorney its a very common problem. Mine resulted simply from a heat wave it crack down the middle in a c shape emanating from the top edge of the windshield. No contact evidence and no contact or accident occurred. It’s now unsafe to drive my vehicle and tesla will not cover it under warranty. They are refusing to label it as a stress fracture though it clearly is. I’m filing this report so more awareness and pressure can be put on tesla to improve their windshield design. Its very unsafe to drive my car like this and now I’m forced to choose between my safety and affording a $1700 replacement. I have had several friends with the same problem and same response by tesla. My car had not been driven for 3 days and I have very low mileage, 18k. Car is 3 yrs old and in good condition.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725482March 19, 2026
ELECTRICAL SYSTEM
Door cannot be opened during power loss / emergency. I am a Tesla Model 3 owner in California. I discovered that the rear doors do not have a mechanical emergency release. Tesla service confirmed that my vehicle does not include any manual rear emergency door release system. This raises a serious safety concern because, in the event of a crash, fire, or 12V power failure, rear passengers—especially children or elderly occupants—may be unable to exit the vehicle. I request NHTSA to investigate whether the absence of a mechanical rear emergency release complies with FMVSS 206 and whether Tesla’s design poses a safety risk during emergency egress.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11722702March 7, 2026
ELECTRICAL SYSTEM
The rear doors intermittently will not unlock. Even after hitting the unlock button from menu or short or long press of the driver unlock button or from the app unlock button. The driver only unlock feature is disabled. I have video that would not upload. Snapshots of video included.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11721846March 3, 2026
ELECTRICAL SYSTEM, UNKNOWN OR OTHER, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
An incident that occurred while Full Self-Driving (FSD) was engaged. During the drive, the vehicle unexpectedly steered toward the curb while making a right turn. I was actively monitoring the vehicle and immediately took control of the steering, but the vehicle still made contact with the curb. After the incident, the vehicle developed steering misalignment, vibration while driving, and abnormal noise, which suggests possible suspension or wheel damage. Since FSD was engaged at the time, I would appreciate it if Tesla could review the vehicle logs and investigate whether there was any system malfunction or unexpected behavior from the FSD system.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720413February 25, 2026
FORWARD COLLISION AVOIDANCE: WARNINGS, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
In autopilot mode on 1/28/26 the vehicle without any warnings went through a red light causing an accident. A week prior it failed to adjust speed in a 35 mile per hour zone maintaining 71.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11719933February 23, 2026
STRUCTURE:BODY
The rear driver side door became impossible to open due to a trim piece failure - this is a safety hazard for rear seat passengers.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718285February 16, 2026
SUSPENSION
A bolt securing the rear subframe assembly is loose and missing its nut. This condition has caused damage to the rear subframe assembly, which now requires replacement. The vehicle was inspected by a licensed dealer who confirmed on video that no impact damage, scraping, bending, or collision damage is present on any surrounding components. The only affected area is the bolt and nut connection point. The dealer's professional assessment is that this is consistent with a factory assembly defect — either the nut was never installed or was not properly torqued during manufacturing. No routine service or alignment would require access to this fastener. Tesla's service records for this VIN should confirm no prior work has been performed in this area, meaning the fastener has not been touched since the vehicle left the factory. Factory-installed suspension bolts of this type are typically secured with a locking mechanism or thread locker; a properly installed nut does not detach through normal vehicle operation. This constitutes a safety defect. A rear subframe fastener that was not properly secured at the factory could lead to suspension component failure, loss of vehicle control, and a serious accident. Tesla's service center has denied warranty coverage for this repair despite the vehicle being within its warranty period, citing that "a manufacturing defect would have presented itself earlier" and that because I am not the original owner, they "don't know what might have happened." Tesla quoted $2,812.49 to replace the damaged rear subframe assembly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717616February 12, 2026
FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
COMPONENT: Battery and Charging System SUMMARY: 2023 Tesla Model 3 Long Range lost 15% battery capacity (345→300 miles) in 2 months at 9,816 miles. Comparison vehicle shows this is a defect, not normal wear. DESCRIPTION: Vehicle: 2023 Tesla Model 3 Long Range, VIN: [insert VIN], 9,816 miles Defect: Between September 2025 and November 2025, displayed range at 100% charge dropped from 345 miles to 300 miles—a 15% loss in just 2 months. Evidence This Is A Defect: I own a second 2023 Model 3 (base model) with 66,680 miles that only dropped from 272→260 miles (4.4% loss). The Long Range with 7x FEWER miles has 3x MORE degradation, indicating a battery pack defect. Service Refusal: Tesla Service ran “range analysis” but refuses to test battery capacity or check for dead cells. Only provided scripted responses about EPA vs real-world driving, which doesn’t explain why my high-mileage vehicle has healthier batteries. Safety Concern: Rapid cell degradation may indicate failing cells, thermal management defect, or fire risk. Unpredictable range loss creates stranding risk. Request: Investigate 2023 Model 3 LR battery packs for systemic defects. Require Tesla to perform cell-level diagnostics and replace defective packs. Documentation available upon request.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717070February 10, 2026
STRUCTURE:BODY
Tesla has completely removed the rear door manual release latch in my late 2023 Model 3 Performance. This elevates the concern of the ongoing NHTSA Defect Petition DP25002 (opened December 2025), which investigates similar issues with emergency egress controls on Model 3 vehicles, citing them as "hidden, unlabeled, and not intuitive." Again, in my late 2023 Model 3 Performance, these are entirely absent in the design. For some reason, Tesla has doubled down on the defect issue and completely removed the manual door release mechanism.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716718February 9, 2026
ELECTRICAL SYSTEM:ADAS:AUTONOMOUS/SELF DRIVING
The contact owns a 2023 Tesla Model 3. The contact stated that while driving with the Autonomous Self Driving feature activated in rainy weather, the vehicle suddenly turned towards the left onto railroad tracks. The contact regained control of the vehicle and was able to drive off the railroad tracks. The tires and rims were damaged due to the failure. The vehicle was taken for repairs, and the tires and rims were replaced, and an alignment was scheduled to be performed. The manufacturer was informed of the failure, and a case was opened. The failure mileage was approximately 14,469.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716471February 7, 2026
UNKNOWN OR OTHER
There is no manual door release for rear doors in the Tesla model 3 RWD. This can pose a safety issue if the car has no power and passengers need to evacuate the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713633January 27, 2026
UNKNOWN OR OTHER
am reporting an issue involving unexplained cracking of my Tesla windshield with no known impact or debris strike. Last night at approximately 6:20 PM, while in Chapel Hill, NC, I entered my vehicle and noticed a crack on the driver’s side of the windshield. The outside temperature at that time was about 28°F. There was no audible rock strike and I have no recollection of anything hitting the glass. The morning low temperature was approximately 14°F. To my awareness, the passenger-side crack was not present earlier that morning. Approximately 15 minutes ([XXX]EDT) before writing this statement, I was seated in the passenger seat and noticed a second crack on the passenger side. The temperature had risen to about 34°F. Again, there was no strike event that I recall while driving or parked. Both cracks appeared within a short time span during an unusually cold period with temperature changes between 14°F and 34°F. The passenger crack visually resembles an impact point, but I cannot identify any incident that would have caused it. My concern is that these cracks may indicate thermal stress, structural flex, a material defect, or bonding/installation issue. Windshield failure without impact presents a safety hazard due to reduced visibility and potential compromise of structural integrity during a collision. I am requesting that NHTSA document and evaluate this issue for potential safety implications. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711027January 14, 2026
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
There is NO mechanism to unlock the rear passenger doors in case of electrical failure. No Emergency mechanical door opening in case of emergency. Passengers will NOT be able to get out of the LOCKED vehicle during an emergency (i.e. crash, battery fire, submerged in water, etc). This is an EXTREMELY IMMINENT DANGER for small kids who are sitting in car seats, since it will take even longer to release them from their straps in order to get out. The small rear windows are useless for escape. THIS FLAW DESIGN HAS ALREADY CAUSED DEATHS. Changes SHOULD BE MADE to enable emergence mechanical opening of the rear doors.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710903January 14, 2026
STRUCTURE:BODY
The entire bumper assembly fell off my Tesla Model 3 during the heavy rains on December 24. I didn't see it happen. It was just missing. But it may have happened on the freeway, when we drive through a flooded area. There is a history of this happening with this model when there is a lot of rain or you drive through a puddle. They admitted to this defect in 2020, but claim it was fixed. Apparently not. They are now telling me "we are unable to cover the repair under vehicle warranty because the condition was caused by outside factors," i.e., water. This cannot be normal.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707201December 26, 2025
ELECTRICAL SYSTEM
The blinkers do not respond to the change in blinkers when I initiate the blinker (right or left) by using the stalk. There has been numerous times that I fully pull down or push up the blinker stall and it would not engage the blinker but today I am reporting it because now I almost changed the lane after engaging the blinker but it didn’t happen
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707074December 26, 2025
AIR BAGS, ELECTRICAL SYSTEM, STEERING
There's a problem with the airbags, and the steering wheel is hard to turn.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702604December 2, 2025
SERVICE BRAKES
Regen braking sporadically not working when going down mountain or steep roads. Sometimes they work and sometimes they won’t. This is after extensive driving on warm days while battery is between 70-80%. Support could not help me and they don’t have any technicians available. I’ve sent them videos and time stamps and they are ignoring the issue and unable to help due to lack of knowledgable representatives This is a serious safety concern
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11699418November 14, 2025
SUSPENSION, UNKNOWN OR OTHER
Compliance arm bolt securing it to the subframe is fractured. Tesla has dismissed my ongoing concerns of vibration and instability while driving. Stating they performed an in depth inspection of all suspension and subframe components and found nothing of concern during last service appointment. I did my own inspection and found the fractured bolt. Sent photo to service and they are trying to play it off as normal and safe to drive. Contacted several manufacturers and mechanics stating otherwise. Told this will end in catastrophic failure and loss of vehicle control but apparently Tesla wants me to drive it to the service department for next service
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Tesla Model 3