ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.
ON CERTAIN PASSENGER VEHICLES, UNDER AMBIENT TEMPERATURES BELOW -25 DEGREES CELSIUS, MOISTURE CAN FREEZE IN THE FUEL PRESSURE REGULATOR. AS A RESULT, FUEL SYSTEM PRESSURE MAY INCREASE AT THE TIME OF ENGINE START UP, CAUSING FUEL LOSS AT THE FUEL PIPE/FUEL HOSE CONNECTION.
ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CASING CAP THAT IS ATTACHED TO THE VEHICLE FIREWALL CAN CRACK DUE TO EXTENDED EXPOSURE TO FORCES FROM THE ACCELERATOR CABLE AND INSUFFICIENT LONG-TERM DURABILITY OF THE PLASTIC CASING CAP. IF THE CASING CAP BECOMES CRACKED, MOVEMENT OF THE INNER ACCELERATOR CABLE THROUGH THE CAP CAN CAUSE THE INNER ACCELERATOR CABLE TO BECOME FRAYED.
CERTAIN PASSENGER (111 MY 2002 ESTEEM, 777 MY 2002 AERIO, 2,368 MY 2003 AERIO) AND SPORT UTILITY (324 MY 2002 GRAND VITARA, 274 MY 2003 GRAND VITARA, 684 MY 2002 GRAND VITARA XL-7, AND 781 MY 2003 GRAND VITARA XL-7) VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, 'WINDSHIELD MOUNTING." THE WINDSHIELD MAY NOT BE PROPERLY SECURED TO THE VEHICLE BODY DUE TO INSUFFICIENT ADHESION BETWEEN THE PAINT APPLIED DURING THE SECOND-STAGE PAINTING PROCESS AND THE PAINT APPLIED DURING FINAL-STAGE PAINTING.
TL* THE CONTACT OWNED A 2002 SUZUKI GRAND VITARA. THE CONTACT STATED WHILE MAKING A RIGHT TURN ONTO A BRIDGE DURING INCLEMENT WEATHER CONDITIONS FROM A STOP SIGN, CONTROL OF THE VEHICLE WAS LOST CAUSING A CRASH INTO A CEMENT WALL. THE CONTACT COULD NOT GAIN CONTROL OF THE STEERING WHEEL AND HER BODY LUNGED FORWARD ONTO THE STEERING WHEEL AS THE SEAT BELT DID NOT RETRACT. THE AIR BAGS DID NOT DEPLOY. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. A POLICE REPORT WAS FILED (NUMBER 19005490). THE CONTACT WAS TAKEN BY AN AMBULANCE TO THE EMERGENCY ROOM FOR HER MULTIPLE INJURIES. THE CONTACT SUSTAINED A BROKEN STERNUM AND MULTIPLE TEETH, INJURED HER CHEST WALL, BOTH LEFT AND RIGHT KNEES AND NECK. THE CONTACT STATED SHE HAD SUFFERED FROM PNEUMONIA AND WAS SEEKING TREATMENT BY A NEUROLOGIST AND SEEK MEDICAL ATTENTION FOR HER LEFT KNEE. THE VEHICLE WAS NOT DRIVABLE AND WAS TOTALED. THE VEHICLE WAS TOWED TO UNKNOWN LOT. THE VEHICLE WAS NOT DIAGNOSED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 82,000.
TL* THE CONTACT OWNS A 2002 SUZUKI GRAND VITARA. THE CONTACT STATED THAT WHEN AT A STOP WITH HER FOOT ON THE BRAKE PEDAL, THE VEHICLE'S ENGINE WOULD BEGIN TO REV WITH THE RPM LEVELS VIGOROUSLY FLUCTUATING. SHE NOTICED THE PROBLEM ON THREE DIFFERENT OCCASIONS SINCE JUNE 2009. SHE TOOK THE VEHICLE TO THE DEALERSHIP AND THE DEALER STATED THAT THEY COULD NOT FIND A CAUSE FOR THE FAILURES. SHE CALLED THE MANUFACTURER AND WAS INSTRUCTED TO TAKE THE VEHICLE TO THE DEALERSHIP. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT MILEAGE WAS APPROXIMATELY 59,330. THE FAILURE MILEAGE WAS APPROXIMATELY 54,000.
No injuries · No fire · No crash
TL*THE CONTACT OWNS A 2002 SUZUKI GRAND VITARA. UNTIL RECENTLY, THE CONTACT HAS NEVER USED THE TIGER PAW SPARE TIRE THAT CAME WITH THE VEHICLE. WHILE DRIVING 60 MPH ON A BUSY HIGHWAY, A TIRE BLEW OUT WITH A LOUD POP. THE DRIVER WAS ABLE TO MANEUVER THE VEHICLE OFF OF THE ROAD TO SAFETY. THE FENDER WAS DAMAGED DUE TO THE TIRE AND HOW IT DETACHED FROM THE VEHICLE. THE TIRE SIZE WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES EXCEEDED 200,000. UPDATED 01/14/09. *JB
No injuries · No fire · No crash
2002 SUZUKI VITARA WITH TRANSMISSION FAILURE. CONSUMER STATES THAT THE VEHICLE WILL GO INTO REVERSE WITH NO HELP FROM THE DRIVER AND OTHER TIMES IT WILL LOCK UP AND NOT GO INTO REVERSE. SHE ALSO STATES THAT IT HAS CAUSED DAMAGE TO PERSONAL PROPERTY. *KB THE CONSUMER STATED WHEN THE THIRD INCIDENT OCCURRED, THE VEHICLE LOCKED UP AND WOULD NOT GO INTO REVERSE. *JB
MY 2002 SUZUKI GRAND VITARA (LIMITED 4WD) WAS INVOLVED IN A SINGLE CAR ACCIDENT WHEN THE CRUISE CONTROL WAS ENGAGED ON THE HIGHWAY AT 55 MPH. IT WAS A HILLY STRETCH OF HIGHWAY NEAR PITTSVILLE, MO AND THERE WAS A LIGHT DUSTING OF SNOW JUST STARTING TO FALL. THE CRUISE CONTROL MADE THE CAR JUMP INTO A LOWER GEAR WHEN ASCENDING A HILL TO KEEP IT AT 55 MPH. THE RPM'S JUMPED FROM ABOUT 2,000 TO 5,000 WHEN THE CAR SHIFTED INTO 3RD GEAR - WHICH CAUSED THE TIRES TO LOSE TRACTION AND I WRECKED INTO 2 HIGHWAY SIGN POSTS AND SKIDDED SIDEWAYS ABOUT 50 YARDS INTO THE CENTER MEDIAN. IT WAS A MIRACLE THAT I DIDN'T ROLL OVER SEVERAL TIMES. IT COST ME $5,000 IN COLLISION DAMAGE TO FIX THE CAR. THE CRUISE CONTROL DOES THIS ALL THE TIME STILL WHEN EVEN ON MODERATE HILLS TO KEEP UP WITH THE SET MPH. IT IS A DESIGN FLAW IN MY OPINION. I HAVE NEVER HAD A CAR THAT NEEDED TO JUMP UP TO OVER 5,000 RPM'S JUST TO GO 65 MPH AND STAY UP WITH THE SET CRUISE SPEED. THANKS. DWS *TR