Subaru of America, Inc. (Subaru) is recalling certain 2024 Crosstrek, Impreza, 2023-2024 Forester, and 2023 WRX vehicles. The front driveshaft assemblies' outer race may develop cracks and break.
I am writing to formally report a critical safety defect regarding the driver-side footwell design in my 2023 Subaru Forester Sport, which poses an immediate and severe risk of a crash. A hard plastic lower extension for the HVAC air duct sits dangerously low directly above the brake and accelerator pedals. For drivers with larger or longer feet, this duct extension acts as a physical obstruction that interferes with safe pedal operation in two specific, highly dangerous ways: Delayed Braking: When attempting to transition from the accelerator to the brake pedal, the toe of the driver's shoe frequently catches on the lip of the air duct extension, delaying the ability to depress the brake pedal in time-sensitive or emergency situations. Pedal Entrapment: When the brake pedal is depressed, the driver's foot can become completely wedged between the brake pedal arm and the air duct extension. This traps the foot, making it impossible to smoothly or quickly release the brake. The physical proximity of this hard plastic duct to the primary driving controls is a severe design flaw. The air duct should not protrude into the clearance space required for standard footwear, as it directly compromises the driver's ability to control the vehicle's speed and braking. I have photo and video documentation clearly demonstrating the lack of clearance and exactly how a shoe becomes caught and wedged during normal driving maneuvers. I am requesting that the NHTSA Office of Defects Investigation (ODI) review this hazard immediately, as this spatial interference requires a recall and physical redesign of the lower ductwork to prevent potential collisions, injuries, or fatalities. The component causing the issue is the physical HVAC ductwork extension, and the vehicle is available for inspection upon request. Because this is a physical design flaw rather than an breakdown, there were no warning lamps or dashboard messages. I have photo and video documentation.
No injuries · No fire · No crash
Eyesight collision braking system engaged as I was rolling up my driveway to go into garage. Garage door was rolling up and was about 5 feet off the ground when Anti Collision system engaged and slammed the brakes on. I was going under 1 mph and would not have hit the door. It beeped right before brakes engaged. This is the second time it has engaged when it shouldn't have. The first time was in a right lane, a car about 6 car lengths in front of me was and did turn right as I was driving down the road. It almost caused an accident with the car behind me. The brakes slammed on so hard my back and neck are now sore and it bent my fingernail backwards somehow on the steering wheel.
No injuries · No fire · No crash
Tires are wearing badly on the inside edge only. Suspension and drive train components make noise during normal operation.
No injuries · No fire · No crash
The contact owned a 2023 Subaru Forester. The contact stated that while driving at an undisclosed speed, the vehicle independently accelerated, and the Forward Collision Avoidance system was inoperative, causing the front center of the vehicle to crash into five other vehicles while trying to stop the vehicle. The air bags deployed as needed. No warning lights were illuminated. The vehicle was deemed a total loss at the scene. A Police report was filed. No injuries were sustained, and medical attention was not needed. The manufacturer was not notified of the failure. The failure mileage was approximately 15,000.
Vehicle caught fire after oil change. Oil leaked from engine onto catalytic converter and causes catastrophic engine fire