Saturn SC1 Complaints (1993)

58 consumer complaints on file.

#10402460May 23, 2011
SEATS
1993 SATURN SC2 FRONT SEAT BACK RECLINER MECHANISM FAILED CAUSING SEAT BACK TO RECLINE SUDDENLY AND ALMOST INJURING PASSENGER IN THE CAR. SEAT WILL NO LONGER STAY FORWARD WHICH RESULTS IN SEAT GOING BACK A SOON AS YOU PRESS GAS PEDAL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10308353February 10, 2010
SEATS
DRIVER'S SEAT BACK RECLINER MECHANISM FAILED CAUSING SEAT BACK TO RECLINE SUDDENLY AND LOSS OF CONTROL OF VEHICLE. DISASSEMBLY OF THE SEAT AND INSPECTION OF THE RECLINER MECHANISM REVEALED A DESIGN DEFECT WHICH MAKES SUDDEN FAILURE OF THIS MECHANISM HIGHLY LIKELY. FOR THE RECLINER TO HOLD THE SEAT BACK IN POSITION, TWO INTERNAL OPERATING LEVERS MUST REMAIN ALIGNED IN THE SAME PLANE. THESE ARE HELD IN ALIGNMENT BY A VERY THIN METAL PLATE (ABOUT 1MM THICK). THIS PLATE WAS BENT CAUSING THE INTERNAL OPERATING LEVERS TO MISALIGN AND THE SEAT BACK TO COLLAPSE. DUE TO THE THINNESS AND LACK OF STRENGTH OF THE ALIGNMENT PLATE, THIS FAILURE IS EXTREMELY LIKELY. YOUR DATABASE SHOWS AT LEAST TWO OTHER SIMILAR FAILURES IN 1993 SATURNS. ALSO NOTE NHTSA ORDERED A RECALL FOR THIS PROBLEM IN 1994 SATURNS. THE FAILED SEAT BACK RECLINER MECHANISM IS AVAILABLE FOR INSPECTION BY NHTSA PERSONNEL. THIS IS NOT A NORMAL WEAR AND TEAR ISSUE, SINCE THIS SEEMS TO BE A COMMON PROBLEM WITH OTHER 1993 SATURNS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10107214January 11, 2005
ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
CONSUMER WAS DRIVING AT APPROXIMATELY 25 MPH AND SUDDENLY THE LIGHTS WENT DIM AND SMOKE BEGAN COMING FROM THE FRONT OF THE VEHICLE. THE SERVICE MANAGER TOLD CONSUMER THAT THERE WAS A FIRE COMING FROM THE ENGINE COMPARTMENT, AND THE WIRE THAT CONNECTED TO THE ALTERNATOR MELTED. *AK
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10094725September 30, 2004
LATCHES/LOCKS/LINKAGES:TRUNK LID:LOCK, SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
CONSUMER COMPLAINED ABOUT MULTIPLE FAILURES. THE TRUNK FAILED TO CLOSE ON ITS OWN. WHILE DRIVING THE TRUNK WOULD OPEN AND WOULD NOT CLOSE, AND WILL NOT LOCK. ALSO, CONSUMER APPLIED THE BRAKES AND PEDAL WENT TO THE FLOOR. THE BRAKES GRABBED SLOWLY AND CAUSED LOSS OF BRAKING POWER. CONSUMER TOOK VEHICLE TO DEALER FOR INSPECTION. CAUSE HAD NOT BEEN DETERMINED. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10088736August 28, 2004
STRUCTURE:BODY:DOOR, SEAT BELTS:FRONT:RETRACTOR
DUE TO PLASTIC DOOR SKIN (OUTER PANELING ) OPENING THE DOOR IN A LOW SPEED CAR ACCIDENT IN ADDITION TO PASSIVE SEAT BELT FALURE (INTERMITTENTLY WORKED)I WAS EJECTED FROM CAR AND LEFT PARALYZED. AUTOMATIC DOOR LOCKING WAS REJECTED BY SATURN DUE TO COST LEAVING SAFETY OUT OF CONCERN. *JB
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10072379May 11, 2004
SEATS
VEHICLE WAS STOPPED WHEN REAR ENDED BY VEHICLE TRAVELING APPROX. 25 MPH. SEAT BACK COLLAPSED ON DRIVER'S SIDE TO 45 DEGREE ANGLE.BODY SHOP UNABLE TO REPAIR TO ORIGINAL CONDITION WITHOUT REPLACEMENT.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10048423February 19, 2004
EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH
THE HAZARD LIGHTS STOPPED FLASHING WITHOUT ANY WARNING. PLEASE DESCRIBE FURTHER. *PH THE TURN SIGNALS WERE ALSO INOPERATIVE. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10042161November 5, 2003
ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES
THE BATTERY CABLE FAILED WHICH CAUSED THE CONSUMER TO REPLACE THE BATTERY EVERY YEAR. A RECALL WAS ISSUED, HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THE RECALL. *AK THE SATURN DEALER REFUSED TO FIX THE BATTERY CABLE. RECALL# 93V094000. *SCC *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10042165November 5, 2003
ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
GENERATOR FAILED PREMATURELY, CAUSING VEHICLE TO STALL WHILE DRIVING. *AK THE VEHICLE WAS NOT INCLUDED IN THE RECALL. RECALL# 93V132000 *SCC THE CONSUMER STATED THE ALTERNATOR FAILED THREE TIMES. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10009178February 24, 2003
SEATS:FRONT ASSEMBLY:RECLINER
THE DRIVER SEAT BACK DID NOT STAY UP. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#8022597November 12, 2002
POWER TRAIN:MANUAL TRANSMISSION:COLUMN SHIFT ASSEMBLY
CONSUMER STATES THIS IS THIRD TIME HAS CHANGE AUTOMATIC TRANSMISION . DEALER HAS BEEN NOTIFIED. AND PROBLEM IS REOCUURING. MR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#762391May 29, 2002
SEAT BELTS
I AM CURIOUS AS TO WHETHER WE ARE THE ONLY ONES WHO HAVE EXPERIENCED THIS SEAT BELT FAILURE. BECAUSE OF CONSTRUCTION, THEY HAVE STOPPED RUNNING ACROSS THE TOP OF THE DOOR, AND THEY ARE EXPENSIVE TO REPLACE.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#8001451January 3, 2002
SEATS
DRIVER SIDE SEAT BROKE, FRAME OF SEAT IS STICKING OUT, UPPER PART OF SEAT IS FLOPPING BACK AND FORTH. *JG *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#752023September 10, 2001
ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
ALTERNATOR MOUNTING POINT ON ENGINE BLOCK BROKE, RELEASING ALTERNATOR. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#561900July 5, 2001
SEATS:FRONT ASSEMBLY:RECLINER
CONSUMER STATES THE DRIVER'S SEAT COLLAPSED BACKWARD WHILE GETTING INTO VEHICLE, DEALER REPLACED THE SEAT BACK ADJUSTER MECHANISM AND LESS THAN ONE WEEK LATER, THE SEAT COLLAPSED AGAIN, CONSUMER RETURNED TO DEALER AND WAS TOLD THAT SOME EARLY MODELS HAD SEAT PROBLEMS, AND THE DEALER ADJUSTED OR BENT THE SEAT TO A MORE UPRIGHT POSITION, SOON AFTERWARDS, THE SEAT COLLAPSED AGAIN.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#886762April 25, 2001
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
DRIVER AND PASSENGER DOORS WILL NOT OPEN FROM INSIDE OF VEHICLE. CONSUMER IS TAKING IT TO A PRIVATE MECHANIC ON APRIL 26TH. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#560371March 19, 2001
TIRES, WHEELS:RIM
WHILE EXITING THE TURNPIKE THE RIGHT FRONT TIRE AND RIM CAME OFF DAMAGING THE RIGHT FRONT FENDER (OHIO TRAFFIC CRASH REPORT). NLM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#883278March 16, 2001
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR, ELECTRICAL SYSTEM, STRUCTURE:BODY:DOOR, INTERIOR LIGHTING
WHILE DRIVING CARBON MONOXIDE FUMES WOULD BE ENTERING VEHICLE THROUGH FLOORBOARD. WOULD HAVE STATIC ELECTRIC CHARGE TO LEFT KNEE. DOORS WERE EXCESSIVELY HEAVY TO OPEN OR CLOSE. DOOR LOCKS FAILED TO BE OPERATED PROPERLY. PANEL LIGHTS WOULD COME ON OR GO OFF BY THEMSELVES. TAKING VEHICLE TO DEALERSHIP TO HAVE MECHANIC CHECK IT OUT. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#876643December 18, 2000
SEATS:FRONT ASSEMBLY:RECLINER
WHILE DRIVING AT 5-10 MPH ANOTHER VEHICLE TRAVELING AT 35 MPH REAR ENDED CONSUMER'S VEHICLE. DRIVER'S SEATBACK FELL INTO A CHILD BOOSTER SEAT WHICH WAS PLACED BEHIND ON DRIVER'S SIDE. SEAT FELL ON TOP OF CHILD'S LEG AND BROKE LEG. PLEASE PROVIDE FURTHER INFORMATION. *AK
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#871992October 2, 2000
SEATS:FRONT ASSEMBLY:RECLINER
WHILE DRIVING DRIVER'S SEATBACK MOVED UNEXPECTEDLY WHICH MAY CAUSE A LOSS OF VEHICLE CONTROL AND A CRASH. DEALER WAS NOT WILLING TO HELP CONSUMER. DEALER SAID NEEDED TO REPLACE BOTH SIDES OF THE SEAT RECLINER. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Saturn SC1