Porsche Cars North America, Inc. (Porsche) is recalling certain 2021 Porsche Macan, Macan S, Macan GTS, and Macan Turbo vehicles. The screw connection on the shock absorbers of the front and rear axle might not be tightened properly.
The seat occupancy sensor fails and deactivates passenger air bag. A previous recall exists for 2015-2018 but the issue continues to occur in 2021 Macan models: [XXX] Requesting the recall include model years 2015-2021 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
I was driving at a low speed, less than 30 mph, and was approaching a curve in the road. I attempted to slow down by pressing the brake pedal, but the vehicle did not decelerate. Instead, it seemed to accelerate. I panicked and repeatedly pressed the brake pedal several more times, but the vehicle remained out of control. The vehicle left the roadway, went down a steep slope, struck bushes and tree branches, and eventually came to a stop. All four airbags deployed, and I observed smoke that appeared to be associated with the airbag deployment. The front ,side,underside and lower portion of the vehicle sustained impact damage. At no time before the accident did I observe any warning lights or messages indicating a problem with the braking system or any other vehicle system. Based on my experience during the incident, I believe the vehicle experienced a brake malfunction, as the brakes did not respond when I attempted to slow or stop the vehicle.
Water intrusion into the rear of the vehicle flooded due to a manufacturers defect. this area houses the battery and other electrical wiring. The water created a potential electrocution and short of much of the wiring, but the rust contaminated the air quality in the vehicle. Evidence of this corrosion shows persistence for more than a couple of years and the car was inspected twice by the dealer over this time, the most recent a year ago. Since then, I have been diagnosed with several respiratory ailment s along with a lymphoma diagnosis. the cost of the repairs is $7500 and I appealed to the dealer who is repairing the car, the dealer where I purchased the car and Porsche USA corp. all passed on helping me pay for the repairs. there was a lawsuit settlement in 2025 for this very same issue where they exended the warranties for two more years. However, I never received notice to participate in the law suit.
No injuries · No fire · No crash
Vehicle developed a check engine light and camshaft sensor fault at approximately 48,000 miles. Engine began making abnormal ticking noise and later entered reduced power/limp mode condition. Vehicle was initially evaluated by an authorized Porsche dealership, where damage to the camshaft trigger/tone wheel and internal mechanical concerns within the valvetrain were identified through diagnostic evaluation and bore scope inspection. Supporting documentation from the authorized Porsche dealership, including bore scope video and diagnostic findings, has been retained. A Porsche-focused independent repair facility later identified a fractured rocker arm within the valvetrain assembly as the root cause of the failure. The failed rocker arm caused contact damage to the camshaft and related components. Repair facility advised that further movement of the failed component could have resulted in catastrophic engine failure. Failed component has been retained and documented with photographs. Vehicle required major valvetrain and camshaft repair. Concern involves internal engine component failure at relatively low mileage with potential loss of power and severe engine damage.
No injuries · No fire · No crash
The CHIME SPEAKER in the failed with less than vehicle 11,000 miles on the odometer. This extremely low mileage indicates that the failure is due to a manufacturing defect rather than standard wear and tear. I am particularly concerned because this is not merely a convenience issue; it is a significant safety concern. The chime speaker is the primary method of delivering audible alerts for: - Turn Signal Indicators: The lack of an audible "click" prevents confirmation that signals are active, which can lead to driver error or unintentional signaling. - Seatbelt Warnings: Critical reminders for passenger safety are now silenced. - System Fault Alerts: Any immediate mechanical or electrical warnings from the vehicle’s diagnostic systems are currently uncommunicated to the driver. - Lane departure warnings. - Collision alerts - Blind spot alerts - Other advanced driving assist and safety systems. The fault has been reproduced and confirmed by the dealer (Porsche Tysons Corner). The fault is also confirmed by the vehicles onboard diagnostic and warning system. The dealers proposed fix is to replace the entire instrument cluster at a cost of more than $5000 or turn the repair over to an audio shop in hopes that they can replace remove the instrument cluster and replace the chime speaker with a non-OEM part as the OEM lowest replaceable part is the entire instrument cluster. This is safety issue because very few vehicle owners will be will to spend more than $5000 to repair/replace the chime speaker.
No injuries · No fire · No crash