DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
CERTAIN DELPHI AFTERMARKET FUEL PUMP MODULES / MODULE RESERVOIR ASSEMBLIES (MRA) THAT WERE SOLD FOR USE ON THE ABOVE LISTED VEHICLES. DURING PRODUCTION THE MRAS VENT AND FUEL RETURN TUBES WERE REVERSED. THIS CONDITION CAN RESULT IN THE VEHICLE NOT RUNNING CORRECTLY (IDLE ROUGH AND/OR STALL) DUE TO AN OVERLY RICH FUEL BLEND OR THE VEHICLE'S EVAPORATIVE EMISSION CARBON CANISTER MAY LEAK FUEL.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
SUNFIRE WON'T START A SOMETHING WITH FUEL PUMP
No injuries · No fire · No crash
MY WRECK HAPPENED IN 2006. THE AIR BAG DEPLOYED AND CRUSHED MY FACE I HAD TO HAVE TITANIUM PLATES PUT IN MY FACE CRASHED MY LEGS BROKE MANY BONES.
TL* THE CONTACT OWNS A 1996 PONTIAC SUNFIRE. THE CONTACT STATED THAT WHILE PARKED, THE DRIVER'S SIDE AIR BAG DEPLOYED INADVERTENTLY. THE CONTACT THEN SHIFTED INTO REVERSE AND THE PASSENGER'S SIDE AIR BAG DEPLOYED INADVERTENTLY. THE CONTACT HAD NOT BEEN INVOLVED IN A CRASH. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 209,600. *TR
No injuries · No fire · No crash
NUMEROUS FAILURES WITH MY CAR I AM ONLY LISTING THE ONES WHICH HAVE HAPPENED MORE THAN ONCE 1..TRANSMISSION FAILURE, TRANSMISSION FAILED 3 TIMES FIRST TIME WHILE TRAVELING 35MPH CAR CAME TO A DEAD STOP TIRES LOCKED UP, CAR WOULD NOT EVEN ROLL, CAUSING NEAR ACCIDENT. 2...WINDOW MOTORS FAILED TWICE ON EACH EACH DOOR OF MY 4 DOOR CAR 3...HEADLIGHT SWITCH HAS FAILED 3 TIMES CAUSING DANGEROUS SITUATION AT NIGHT 4...SEVERE WATER LEAK IN TRUNK AREA , WATER GETTING IN THROUGH FENDER WELL OR TRUNK UNDERBODY, CAUSED SO MUCH TO PUDDLE UP A MUSHROOM STARTED GROWING FROM BACK SEAT,... WATER PUDDLED UNDERNEATH CARPET IN SPARE TIRE AREA SO IT WAS NOT VISIBLE TO NAKED EYE, BUT WAS SLOSHING BACK AND FORTH WITH EVERY STOP AND GO OF VEHICLE STILL TO THIS DAY HAVE NOT BEEN ABLE TO PINPOINT EXACT LOCATION WATER IS GETTING IN ALTHOUGH IT FOR SURE IS FROM UNDERBODY 5... OTHER DEFECTS INCLUDE RADIO DISPLAY LIGHTS FAIL ON 2 RADIOS, SEATBELTS AND STEERING WHEEL BECOME TOO HOT IN SUMMER BRAKE PADS WEAR UNEVENLY,,,, FUEL PUMPS GO OUT OFTEN. *TR
No injuries · No fire · No crash
1996 PONTIAC SUNFIRE 2.2L. REAR RIGHT BRAKE LOCKS. CAUSES THE CAR TO SHUDDER AND DIFFICULT TO STOP. THIS ALSO CAUSES THE ABS AND BRAKE LIGHT TO ILLUMINATE ON THE DASH. BRAKES HAVE BEEN REPLACED. POSSIBLE FAILURE TO STOP IS THE GREATEST CONCERN. THIS MAY LEAD TO ACCIDENT. *TR
No injuries · No fire · No crash