Nissan · Model Report
Showing safety data for the 2005 model year only.
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
NISSAN IS RECALLING CERTAIN FRONT AND REAR LOWER LINKS, P/NOS. 54501ZQ00A, 54500ZQ00A, 551A1ZQ00A, 551A0ZQ00A , 54501EA00A, 54500EA00A, 551A1EA500, 551A0EA500, 54501ZR00A, AND 54500ZR00A, SOLD BETWEEN NOVEMBER 25, 2009 AND MAY 14, 2010 AS REPLACEMENT PARTS FOR MODEL YEAR 2004 THROUGH 2010 TITAN, ARMADA, AND QX56, AND MODEL YEARS 2005 THROUGH 2010 FRONTIER, XTERRA, AND PATHFINDER VEHICLES. THE LOWER CONTROL LINK ASSEMBLY HAS TWO CYLINDRICAL COLLARS FORMING THE INBOARD ATTACHMENT POINTS TO THE CHASSIS. DUE TO AN IMPROPER WELDING PROCESS SOME COLLARS MAY CONTAIN WELDS THAT DO NOT MEET STRENGTH SPECIFICATIONS.
NISSAN IS RECALLING 242,720 MY 2005-2009 PATHFINDER, FRONTIER AND XTERRA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. IN THOSE AREAS OF THE COUNTRY WHICH USE HEAVY CONCENTRATIONS OF ROAD SALT IN THE WINTER, A MIXTURE OF SNOW/WATER AND SALT CAN ENTER INTO THE FRONT CRASH ZONE SENSOR (CZS) HOUSING. IF THIS OCCURS, THE CZS MAY INTERNALLY RUST RESULTING IN A SIGNAL INTERRUPTION. IF THIS HAPPENS, THE RED AIR BAG WARNING LIGHT WILL ILLUMINATE TO ALERT THE VEHICLE OPERATOR.
CERTAIN HOPKINS AFTERMARKET TRAILER BRAKE CONTROL CONNECTION HARNESSES SOLD FOR USE ON CERTAIN MODELS OF NISSAN VEHICLES WHICH ARE LISTED ABOVE. THE INTERNAL PART NUMBERS WITHIN HOPKINS ARE: 1010476025, 1040376025, 1110476025, 1170376025, 1290376025, 1010476035, 1040376035, 1110476035, 1170376035, AND 1290376035. A WIRE MAY HAVE BEEN PLACED IN AN INCORRECT POSITION IN THE ELECTRICAL CONNECTOR HOUSING. THIS RESULTS IN AN INCORRECT ROUTING OF WIRES BETWEEN THE TRAILER BRAKE CONTROLLER AND THE TOWING VEHICLE WIRING SYSTEM.
I am reporting a serious safety defect with my 2005 Nissan Pathfinder (VIN: [XXX] ). My vehicle has an open recall for the airbag emblem (NHTSA #23E-012 / PC948), which is scheduled for inspection. However, I am writing today because I am also experiencing a repeated and dangerous malfunction that is unrelated to that recall: Total loss of dashboard lights and instruments while driving No throttle response even though the engine remains running Temporary function restored only by turning the vehicle off and restarting it on the roas This behavior matches known electrical failures in this model year, often related to the IPDM, ignition switch, or ECM communication. These are not cosmetic or maintenance issues—they are life-threatening. My vehicle has done this multiple times, including at highway speeds. When I contacted South Colorado Springs Nissan, I was told they would only inspect the airbag emblem and would not evaluate this issue unless I paid for diagnostics. I find this unacceptable given Nissan’s history with these failures and the high likelihood this is a known and unresolved defect. I am requesting: That this issue be escalated within Nissan North America That Nissan consider this under a goodwill safety repair, if not covered by existing recall or campaign That the vehicle be diagnosed immediately, and Nissan be held accountable for any known defects I am also reporting this to NHTSA as a safety concern. Please confirm receipt of this email and provide next steps. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
No injuries · No fire · No crash
The contact owns a 2005 Nissan Pathfinder. The contact stated while driving at an undisclosed speed, the air bag warning light illuminated. The contact took the vehicle to the dealer and was informed the front passenger’s side air bag was defective and needed to be replaced. The air bag was not replaced due to the cost. The manufacturer was not made aware of the failure. The approximate failure mileage was 175,000.
No injuries · No fire · No crash
The contact owns a 2005 Nissan Pathfinder. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to immediately restart. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. The dynamic control warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to Voluntary Recall Campaign: PC068. The manufacturer was not notified of the failure. The failure mileage was 170,000.
No injuries · No fire · No crash
The component that is malfunctioning is the emblem on the airbags. Nissan has known of this issue for a while. In the event of a crash, when the airbags deploy, the emblem will also explode with the airbags and send shrapnel from it flying towards the driver and nearby passengers. If the crash wouldn't kill the driver, then this issue could as it could hit the driver in a vital part. They are taking too long to fix this issue, as it is such a vital problem that can cost people their lives.
No injuries · No fire · No crash
The contact owns a 2005 Nissan Pathfinder. The contact received recall notification of NHTSA Campaign Number: 23E012000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
No injuries · No fire · No crash