Nissan Frontier Complaints (2002)

124 consumer complaints on file.

#10781378October 12, 2015
STRUCTURE:BODY, FUEL/PROPULSION SYSTEM, STEERING
THE FRAME ON THESE VEHICLES ARE UNSAFE DUE TO PERSISTENT CORROSION WHICH ALSO CARRIES THROUGHOUT OTHER PARTS UNDER THE VEHICLE LIKE THEIR STEERING. IN MY CASE, THE RUST IS SETTLING IN AND CAUSING THE FRAME TO DETERIORATE DESPITE IT ONLY HAVE 69K MILES. THE CONCERN IS OBVIOUSLY HAVING THE VEHICLE CRUMBLE DURING USE. HERE ARE JUST A FEW OTHER COMPLAINTS LISTED ON THE INTERNET BY OTHER OWNERS. HTTP://WWW.NISSANFORUMS.COM/PATHFINDER/117181-RUSTED-FRAME.HTML HTTP://NISSANPROBLEM.COM/2002-NISSAN-FRONTIER-STRUCTURE-FRAME-AND-MEMBERS-UNDERBODY-SHIELDS-PROBLEMS-DEFECTS/ HTTP://WWW.CONSUMERAFFAIRS.COM/AUTOMOTIVE/NISSAN_FRONTIER.HTML
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10760765September 1, 2015
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. WHILE DRIVING 68 MPH, THE VEHICLE MADE AN ABNORMAL NOISE THEN DECELERATED WITHOUT WARNING. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE DID NOT RESPOND. THE CONTACT STATED THAT THE VEHICLE WAS TURNED OFF AND THEN BACK ON AND THE VEHICLE FUNCTIONED NORMALLY. SEVERAL MILES INTO THE DRIVING THE VEHICLE, THE ACCELERATOR PEDAL SEIZED, CAUSING THE VEHICLE TO ACCELERATE WITHOUT THE ACCELERATOR PEDAL BEING DEPRESSED. THE CONTACT WAS INFORMED THAT THE VEHICLE'S SPEED SENSOR FAILED. THE CONTACT WAS INFORMED BY THE DEALER AND MANUFACTURER THAT THE PART WAS NO LONGER AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10703705April 4, 2015
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
WAS COMING TO A STOP AT A TRAFFIC LIGHT IN S.C., WHEN ALL OF A SUDDEN THE MOTOR STARTED TO RACE. I IMMEDIATELY TURNED THE MOTOR OFF. TURNED IT BACK ON, AND HAD NO MORE PROBLEMS. THIS WAS VERY FRIGHTENING. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10664317December 15, 2014
STEERING
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 75 MPH, THE STEERING WHEEL WAS DIFFICULT TO TURN. THE CONTACT WAS CONCERNED THAT THE FAILURE WOULD RESULT IN A CRASH. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 10V554000 (STEERING) IN FEBRUARY OF 2013, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 225,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10650003October 25, 2014
FUEL SYSTEM, GASOLINE
IN 2014 THE FUEL SENDING UNIT ATTACHED TO THE FUEL TANK HAD A 3-4 INCH GAP. EXCESSIVE FUEL SMELL (HEALTH, ENVIRONMENTAL AND FIRE HAZARD). A SIMILAR REPORT WAS MADE IN: RECEIPT DATE: MAY 24, 2004 > NHTSA CAMPAIGN NUMBER: 04V230000 > COMPONENT(S): FUEL SYSTEM, GASOLINE THESE INCIDENTS MAY BE CONNECTED AND STILL OCCURRING I HAVE PHOTOS AND DOCUMENTATION FROM THE REPAIR MADE BY A NISSAN DEALER AVAILABLE UPON REQUEST. FUEL CAN LEAK FROM THE GAP AND IF IN AN ACCIDENT CAUSE A FIRE, SERIOUS BODILY INJURY OR DEATH. I CONTACTED NISSAN NORTH AMERICA AND CASE # [XXX] WAS GENERATED. NO FURTHER ACTION ON THEIR PART HAS BEEN MADE TO INVESTIGATE THIS INCIDENT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10641983October 7, 2014
STEERING
I GOT A RECALL FOR THE STEERING COLUMN. I WAS TOLD THERE WOULD BE NO COST TO ME FOR LABOR AND PARTS. I TOOK MY VEHICLE TO THE DEALER AND THEY WANTED TO CHARGE ME $208 TO REMOVE SOME RUSTED BOLTS THAT HAD TO BE REMOVED TO GET TO RECALLED PART.. I GOT IN TOUCH WITH NISSAN CORP. THEY REVIEWED THE INFORMATION AND SENT ME A LETTER STATING "IT FALLS OUTSIDE THE PARAMETERS OF THE NEW VEHICLE LIMITED WARRANTY". MY COMPLAINT IS, WHY SHOULD I HAVE TO PAY ANYTHING FOR A RECALLED PART. IF THE PART WAS NOT FAULTY I WOULDN'T BE REMOVING THOSE BOLTS ANYWAY. I THINK NISSAN CORP. SHOULD INCUR ANY COST ASSOCIATED WITH REPLACING THE RECALL ON THE "COMPLETE STEERING COLUMN RECALL". *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10641063October 3, 2014
STEERING:COLUMN
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING WHEEL SEIZED AND MADE A CRACKING SOUND. THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 10V554000 (STEERING), BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE STEERING COLUMN WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10606300July 2, 2014
FUEL SYSTEM, GASOLINE
2002 NISSAN FRONTIER. CONSUMER WRITES IN REGARDS TO VEHICLE LEAKING GAS. *SMD THE CONSUMER STATED WHEN HE LOOKED UNDER THE VEHICLE, THERE WAS AN EXPLOSION AND HE HAD TO BE RUSHED TO THE BURN CENTER, FOR SECOND DEGREE BURNS ON HIS LEFT AND RIGHT ARMS. *JB
Crash:
No
Fire:
Yes
Injuries:
1
Deaths:
0
#10491989January 9, 2013
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, HE NOTICED AN OVERPOWERING WAVE OF A GASOLINE ODOR INSIDE THE VEHICLE. THE VEHICLE THEN STALLED WHILE THE CONTACT WAS ATTEMPTING TO ACCELERATE UPHILL. THE VEHICLE WAS LATER TOWED TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HIM THAT THE FUEL TANK WAS SEVERELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THE VEHICLE WOULD HAVE TO TAKEN TO AN AUTHORIZED DEALER FOR REPAIRS. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10474235September 7, 2012
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT THE VEHICLE BEGAN TO ACCELERATE INDEPENDENTLY WHILE SITTING AT A TRAFFIC STOP WITH THE BRAKES APPLIED. THE CONTACT WAS ABLE TO SHIFT INTO PARK AND TURNED THE IGNITION OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT TO CALL A LOCAL DEALER. THE FAILURE MILEAGE WAS 165,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10465425July 12, 2012
STRUCTURE:BODY
WHILE HAVING MINOR COSMETIC REPAIRS DONE, OUR [REPUTABLE] BODY SHOP REPAIRMAN POINTED OUT THAT THE FRONT RADIATOR SUPPORT FRAME IS COMPLETELY RUSTED THROUGH. EVERYTHING ELSE ON THIS TRUCK IS SOLID. I AM METICULOUS ABOUT IT. THERE IS OBVIOUSLY SOME SORT OF DEFECT ON THIS AREA FOR IT TO BE 90% DETERIORATED! THE SLIGHTEST TOUCH CAUSES IT TO CRUMBLE...IN THE PAST, EVEN TOYOTA HAS STOOD BEHIND THEIR VEHICLES WITH CORROSION ISSUES...I WOULD CERTAINLY HOPE NISSAN COULD LOOK INTO THIS THE SAME WAY...ITS A REAL SHAME THAT I CAN ONLY SEE ANOTHER YEAR MAYBE BEFORE MY RADIATOR FALLS OUT AND CAUSES SOMETHING MUCH WORSE... *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10438840December 7, 2011
ELECTRICAL SYSTEM:WIRING, ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE WARNING INDICATOR CONTINUOUSLY ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. ON A SEPARATE OCCASION THE VEHICLE JERKED VIOLENTLY WITH A REDUCTION IN THE ENGINE POWER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE KNOCK SENSOR, MASS AIR FLOW SENSOR AND FOUR OXYGEN SENSORS WERE REPLACED. THE FAILURE CONTINUED TO OCCUR AFTER THE REPAIR WAS PERFORMED. THE VEHICLE WAS TAKEN BACK TO THE INDEPENDENT MECHANIC FOR THE SECOND TIME AND THE WIRING HARNESS WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM AND THEY INFORMED THE CONTACT THAT THE WIRING HARNESS CONNECTORS EXHIBITED CORROSION AS A RESULT OF NOT BEING WEATHERPROOF DURING PRODUCTION. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 04/10/12*LJ THE CONSUMER STATED HE SPENT CLOSE TO $2000 REPAIRING THE VEHICLE. THE CHECK ENGINE LIGHT CONTINUED TO ILLUMINATE, AFTER REPLACING THE O2 SENSORS FOUR TIMES. ALSO, THE WIRING HARNESS HAD TO BE REPLACED BECAUSE WHEN THE VEHICLE WAS MANUFACTURED IT WAS NOT WEATHER PROOF WHICH CAUSED CORROSION IN THE WIRES, WHICH SENT INCORRECT SIGNALS TO THE VEHICLE'S COMPUTER. THE CONSUMER NO LONGER OWNS THE VEHICLE. UPDATED 05/31/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10438580December 5, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THAT THE VIN DID NOT QUALIFY FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 04V230000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 139,893.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10435724November 15, 2011
FUEL SYSTEM, GASOLINE
A VERY STRONG AND VERY OVERPOWERING GAS SMELL CAME INSIDE THE VEHICLE WHILE I WAS DRIVING IT AT NIGHT. I HAD MY 5-YEAR OLD STRAPPED IN HIS CAR SEAT IN THE BACK. I WAS STUCK IN TRAFFIC ON I-95 AND DIDN'T HAVE MANY OPTIONS BUT TO CONTINUE TO DRIVE HOME. THE "SERVICE ENGINE SOON" LIGHT CAME ON AS WELL. THE NEXT DAY, I TOOK THE VEHICLE IN FOR SERVICING AT MY NISSAN DEALERSHIP MECHANIC, AND I HAVE SPECIFIC TEXT FROM THE WORK INVOICE THAT STATES THE FOLLOWING WORD-FOR-WORD: "CANNISTER COMING APART. RIGHT VALVE STUCK INSIDE - REPLACED - GAS LEAKING DOWN SIDE. REPLACED GAS TANK - RUSTED." THE WORK INVOICE ALSO DETAILS THAT THE DEALERSHIP MECHANIC REPLACED THE FOLLOWING COMPONENTS: (1) CANISTER ASSY E (2) VALVE ASSY - CO (3) FUEL TANK (4) RING-O FUEL GAG. THIS VEHICLE HAS NEVER BEEN IN ANY ACCIDENTS AND I FULLY MAINTAIN IT ACCORDING TO THE MANUFACTURER'S SCHEDULE. I HAVE BEEN A RESPONSIBLE AND GENTLE OWNER. I FEEL THIS WAS EXTREMELY UNSAFE -- TO HAVE GASOLINE LEAKING OUT DUE TO A RUSTED GAS TANK IS [IN MY OPINION] AN UNACCEPTABLE DEFECT -- THE GAS TANK SHOULD HAVE BEEN MADE [IN MY OPINION] OUT OF A NON-RUSTING MATERIAL. I HAVE COMPLAINED TO NISSAN USA AND THEY OFFERED ME (ON THE PHONE THE REPRESENTATIVE SAID IT WAS AS "GOODWILL") A $250 NISSAN DEBIT CARD FOR FUTURE REPAIRS ON THIS VEHICLE. BUT THE TOTAL COST THAT I HAD TO PAY FOR THIS LEAKING GASOLINE ISSUE WAS $1,254.83. I AM WILLING TO PROVIDE NHTSA WITH MY RECEIPT THAT SHOWS THE TEXT INDICATING THE DETAILS OF THIS DEFECT AND THAT I HAD TO PAY $1,254.83 TO RECTIFY IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10433378November 1, 2011
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
2002 NISSAN FRONTIER PICK UP. CONSUMER WRITES IN REGARDS TO A SERIOUS CORROSION PROBLEM IN THE UNDER BODY; ESPECIALLY THE DRIVE SHAFT. *TGW AN INSPECTION REVEALED MAJOR RUST IN THE UNDER BODY. THE CONSUMER STATED TWO YEARS AFTER PURCHASING THE VEHICLE, A METAL GUARD COVERING THE CATALYTIC CONVERTER RUSTED OFF. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10428035September 30, 2011
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT HE NOTICED THAT THE FUEL TANK WAS LEAKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED HIM THAT THERE WAS SEVERE RUSTING AND SMALL PIN HOLES IN THE GASKET. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THE COMPONENT WAS NO LONGER WAS BEING MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10425736September 16, 2011
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT THE EXHAUST MANIFOLD WAS FRACTURED AND SENDING CO2 THROUGH THE VENTS WHILE DRIVING 25 MPH AND ABOVE. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THE DEALER REPLACED THE PASSENGER SIDE EXHAUST MANIFOLD. AFTER THE REPAIRS, THE DRIVER SIDE EXHAUST MANIFOLD FRACTURED AND THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER. THE DEALER ADVISED THAT IT WAS COMMON FOR THE MANIFOLD TO FRACTURE IN THE PARTICULAR YEAR, MAKE AND MODEL. THE CONTACT DID NOT REPLACE THE DRIVER SIDE EXHAUST MANIFOLD. THE FAILURE MILEAGE WAS 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10412698July 13, 2011
STEERING:COLUMN
2002 NISSAN FRONTIER. CONSUMER STATES STEERING PROBLEMS *TGW THE CONSUMER STATED THE NEAREST DEALER IS 80 MILES AWAY AND WOULD LIKE TO HAVE HIS MECHANIC PERFORM THE RECALL WORK. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10410707July 6, 2011
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THAT THE INTERIOR HEATER WAS ACTIVATED AND WOULD BLOW EXTREMELY HOT AIR WHEN DIRECTED TO THE FOOT VENT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED TO SIMPLY CHANGE THE HEATER SETTINGS. THE CONTACT WAS CONCERNED BECAUSE THE HEAT WOULD BURN HIS FEET. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 150,000. UPDATED 10/05/11
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10407676June 21, 2011
SUSPENSION, STEERING:COLUMN
TL* THE CONTACT OWNS A 2002 NISSAN FRONTIER. THE CONTACT STATED THE VEHICLE WAS REPAIRED FOR THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 10V554000 (STEERING:COLUMN). AFTER RECEIVING THE VEHICLE FROM THE AUTHORIZED DEALER, THE CONTACT NOTICED THAT THE STEERING WHEEL WAS POSITIONED OUT OF ALIGNMENT. WHENEVER THE STEERING WHEEL WAS POSITIONED TO DRIVE STRAIGHT, THE VEHICLE WOULD STEER TOWARDS THE RIGHT. THE MANUFACTURER AND AUTHORIZED DEALER WERE NOTIFIED, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 93,898. UPDATED 8/29/11 *CN THE DEALER INFORMED THE CONSUMER THE ALIGNMENT WAS PROBABLY OFF. UPDATED 10/03/11
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Nissan Frontier