MINI · Model Report
Showing safety data for the 2019 model year only.
BMW of North America, LLC (BMW) is recalling certain 2018-2019 BMW X1 sDrive28i, X1 xDrive28i, 2019 X2 xDrive28i, MINI Cooper S Convertible, Countryman, and John Cooper Works Countryman vehicles. The steering gear tie rod may have been assembled incorrectly, which may result in excessive wear of the tie rod end, eventually causing it to break.
BMW of North America, LLC (BMW) is recalling certain 2018 BMW 540d xDrive vehicles. The crankshaft sensor may be equipped with incorrect firmware, preventing the sensor from properly processing input from the crankshaft reluctor ring, possibly resulting in a vehicle stall. On September 12, 2018, BMW expanded the recall to a total of 5,309 vehicles including certain 2018-2019 BMW 540d xDrive, 230i M240i, M240i xDrive, X2 sDrive28i, X2 xDrive28i, X1 sDrive28i, X1 xDrive28i, 330i, 330i xDrive, 340i, 340i xDrive, 330i xDrive Gran Turismo, 530i, 530i xDrive, 540i, 540i xDrive, 530e, 530e xDrive, 640i xDrive Gran Turismo, 330e, 2019 430i Gran Coupe, 430i xDrive Gran Coupe, 440i Gran Coupe, 440i xDrive Gran Coupe, 430i, 430i xDrive, 440i, 440i xDrive, 740i, 740i xDrive, MINI Cooper, Cooper S, JCW, MINI Countryman (Cooper, Cooper All4, Cooper S, Cooper S All4, JCW All4), and MINI Clubman (Cooper, Cooper S, Cooper All4, Cooper S All4, JCW All4) vehicles.
Starter started smoking at start up! And clutch failure at traffic light!!!! No accident occurred because of experienced driver!
No injuries · No fire · No crash
Certain 2019 MINI and BMW models are equipped with older evaporators that are not lined correctly to prevent aluminum corrosion from the new R-1234yf refrigerant, causing premature leaks of the refrigerant into the cabin while driving. Exposure to the refrigerant can cause severe irritations including dizziness, sudden and uncontrollable pain in the eyes and bursts of tears while driving. This has happened to me multiple times, until I stopped using AC completely.
No injuries · No fire · No crash
I’ve been experiencing headaches, dizziness, and sudden tearing episodes while driving and the tearing only happens while driving my MINI. A few of these episodes have occurred on the highway, the painful eye irritation and crazy tearing made it very difficult to keep my eyes open, which has been super dangerous. I forced myself to keep at least one eye open to pull over, and fortunately I'm still alive. I recently found that these symptoms are probably linked to the premature failure (at 10k miles) of the AC system and exposure to the refrigerant leaked from the vent. I noticed AC hissing noise a few days after my warranty expired at only 10k miles, the dealer found super low refrigerant but could not find any leak. They recharged it and said my car was good, but noise came back after 3 months. They were still not able to find the leak, and asked me to replace one part at a time until it's fixed. I called MINI, MINI helped the dealer to find leak from compressor and replaced it. I mentioned a weird odor every time I start my car but they didn't investigate further. The noise came back again after 5 months (at 12k miles). I brought it to another dealer (since I moved) and two independent mechanics (as the previous dealer has been very incompetent), all diagnosed leak from evaporator because of the odor and that the cabin air filter has refrigerant dye all over it upon checking. The previous dealer didn't check the filter at all according to my dash camera, and because of the same odor, the timeline of the repeated failures, I believe the evaporator leak also happened at 10k miles. And one of the independent mechanics who specializes in BMW and MINI mentioned he had seen quite a few such cases in 2018 and 2019 MINIs. I think failure of two major AC components at such low mileage isn't normal, and the unexpected headache, dizziness, and strong eye irritation while driving are super dangerous. The repair cost for the defects should not be customers' responsibility.
No injuries · No fire · No crash
The contact owns a 2019 Mini Cooper S. The contact stated that while driving at an undisclosed speed, the contact noticed that a rock had hit the driver's side of the windshield due to construction work on a local highway. The contact stated that the passenger's side of the windshield was also hit by a rock while driving. The contact stated that the driver's side of the windshield sustained a minor fracture; however, the passenger's side of the windshield was severely damaged. An unknown dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 81,485. The VIN was not available.
No injuries · No fire · No crash
Loss of power steering on startup or at stop light. A message pops up indicating that the Dynamic Stability Control is re-initializing and that steering may become difficult: Drive carefully. The warning message usually appears shortly after the failure. In fact, the steering gets so stiff, that my wife can barely turn corners. The problem comes and goes unexpectedly. This is my wife's car, and it has happened to her on several other occasions. Sometimes we can reset by restarting the car, but that isn't reliable. We put the car out of ECO mode into Sport mode, so that the engine does not stop at stop lights, but the engine sometimes stops anyway. When it happened at a stop light today, we tried several restarts, but the steering remained out. Steering is worse at low speeds. Today, we stopped at a light. My wife was driving. The engine stopped and restarted, and the error message appeared. She had difficulty steering into a parking lot where I swapped places with her. I drove her home. It was difficult for me to steer around corners after today's lock up, but I drove the car to a local BMW-Mini mechanic with whom I had discussed the problem, but it never appeared at his shop. Today, we tried starting at the shop and the difficult steering persisted without an error message. He ran a quick scan indicating that some modules in the steering column were not operating properly. He said the modules were not available for replacement, and that the entire steering column might need to be replaced. Unfortunately, he was booked up until Friday. I drove home and let the car sit in the garage for a couple of hours. I started it while writing this to try to more accurately reproduce the warning messages. However, no messages appeared and the car steered easily. Clearly, sudden loss of power steering poses a danger for my family and others on the road. I've looked on the internet and discovered that others have experienced similar problems with steering in Mini Coopers.
No injuries · No fire · No crash