Mercury Sable Complaints (2002)

440 consumer complaints on file.

#10451707March 14, 2012
ENGINE AND ENGINE COOLING
ENGINE SUDDENLY BEGAN RACING, (AS IF THE ACCELERATOR WAS STUCK) WHILE PULLING INTO A PARKING SPACE AT THE MALL. WAS ABLE TO STOP THE CAR BY FIRMLY APPLYING THE BRAKES. CHECKED AND VERIFIED THAT THE FLOOR MAT WAS NOT INTERFERING WITH THE ACCELERATOR PEDAL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10451167March 12, 2012
VEHICLE SPEED CONTROL
CRUISE CONTROL CABLE BROKE OR CAME LOOSE CAUSING THROTTLE RETURN SPRING TO FALL OFF. I COULD NOT STOP CAR NO MATTER HOW HARD I PUSHED THE BRAKE PEDAL. THE ENGINE RAN AT FULL SPEED. THE CRUISE CONTROL WAS NOT ON. I WAS ABLE TO QUICKLY PUT CAR IN NEUTRAL AND TURN OFF THE ENGINE. I STARTED THE ENGINE AGAIN AND IT REVVED UP TO FULL SPEED IMMEDIATELY. IT WAS VERY DIFFICULT TO MOVE THE CAR OFF THE MAIN ROAD WITHOUT STARTING THE ENGINE. WE WERE FORTUNATE THERE WERE NO CARS IN FRONT OF US WHEN THIS HAPPENED. WE WERE ABOUT 50 YARDS FROM HAVING TO MAKE A SHARP LEFT TURN TO GO ONTO THE MAIN HIGHWAY AND TRAFFIC. WE NEVER WOULD HAVE BEEN ABLE TO MAKE THE TURN WITHOUT CRASHING OR THE CAR TURNING OVER. MY WIFE AND I HAD JUST PICKED UP TWO OF OUR DOGS AT THE VET AND WERE RETURNING HOME. THE CAR WAS TOWED TO THE NEAREST FORD GARAGE IN THE NEXT TOWN. I BELIEVE FORD HAS A BIGGER PROBLEM THAN THEY ARE ADMITTING. THE MERCURY'S SHOULD BE INCLUDED IN THEIR PROBLEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10445730January 29, 2012
SUSPENSION
I WAS BACKING OUT OF MY GARAGE WHEN I IMMEDIATELY BECAME AWARE THE VEHICLE WAS NOT MOVING NORMALLY, THE FRONT DRIVERS SIDE TIRE WAS COMPLETELY FLAT. WHEN I WAS CHANGING THE TIRE I NOTICED THE SPRING HAD BROKEN AND PUNCTURED AND RUINED THE TIRE. THIS EVIDENTLY HAPPENED WHILE THE CAR WAS PARKED IN THE GARAGE AS I HEARD NO NOISE FROM THE BREAKING SPRING OR ESCAPING AIR. I FEEL FORTUNATE THIS HAPPENED IN THE GARAGE AND NOT AT HIGHWAY SPEEDS. *TT
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10445667January 28, 2012
SUSPENSION
THE FOLLOWING ADDRESSES AN ISSUE I ENCOUNTERED WITH MY VEHICLE, A 2002 MERCURY SABLE. ON JANUARY 12TH, 2012, I WAS DRIVING ON A TWO WAY ROAD DURING A HEAVY SNOWSTORM. I WAS TRAVELING ABOUT 35 MILES PER HOUR, WHICH WAS BELOW THE SPEED LIMIT, DUE TO THE ROAD CONDITIONS. AT THIS TIME, I HEARD A LOUD NOISE AND EXPERIENCED A LOSS OF CONTROL OVER MY VEHICLE. AFTER PULLING OVER, I INVESTIGATED THE NOISE AND DISCOVERED THAT THE FRONT RIGHT TIRE WAS COMPLETELY SHREDDED AND PARTIALLY OFF THE RIM. I TOWED THE CAR TO A REPAIR SHOP AND LEARNED THAT THE SUSPENSION SPRING BROKE AND PUNCTURED THE TIRE AND DAMAGED THE STRUT. THIS IS ALSO A YEAR AND A HALF AFTER I HAD A SIMILAR PROBLEM WITH THE FRONT LEFT SPRING. NEITHER THE STRUT NOR THE TIRES WERE DAMAGED DURING THIS EVENT AT THAT TIME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10443456January 11, 2012
SUSPENSION
DRIVER BACKING OUT OF PARKING SPACE WHEN HEARD METALLIC GRINDING SOUND FOLLOWED BY A BANG. THEN WE HEARD THE SOUND OF METAL ON PAVEMENT. WHEN GOT OUT OF CAR THE DRIVERS SIDE OF THE CAR WAS SITTING SO LOW THAT I COULD NOT GET A JACK UNDER IT. THE DRIVER FRONT TIRE WAS COMPLETELY SHREDDED ON THE INSIDE OF THE WHEEL WELL. IT IS COSTING US $700 TO REPAIR. AS PER ODI RESUME EA 08-18 DOCUMENT UNDER REASON FOR CLOSING THE FOLLOWING SENTENCE APPEARS, "THE COIL SPRINGS IN THE SUBJECT VEHICLES ARE DEFECTIVE." EVEN IF THERE IS NO REAL DANGER TO TRAFFIC SAFETY IT IS STILL AND ISSUE THAT FORD SHOULD BE REQUIRED TO ADDRESS, WE AS THE DRIVING PUBLIC SHOULD NOT HAVE TO PAY HUNDREDS OF DOLLARS TO REPAIR IT. ALSO IF FORD WANTS TO KEEP THEIR CUSTOMERS THEY SHOULD ADDRESS PROBLEMS SUCH AS THIS. WE ARE THINKING OF LOOKING TO TOYOTA OR HONDA FOR OUR NEXT CAR AFTER DRIVING FORDS SINCE 1997. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10441784December 30, 2011
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT THE VEHICLE WAS EQUIPPED WITH ADJUSTABLE PEDALS THAT WOULD INTERMITTENTLY BECOME STUCK. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000. THE VIN WAS UNAVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10440458December 19, 2011
SUSPENSION
TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE NOTICED THAT THE FRONT DRIVER'S SIDE TIRE WAS FLAT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP AND THE CONTACT WAS INFORMED THAT THE FRONT DRIVER'S SIDE COIL SPRING FRACTURED AND PUNCTURED THE TIRE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 123,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10439752December 13, 2011
SUSPENSION
TL* THE CONTACT OWNS A 2002 MERCURY SABLE GS. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THERE WAS A LOUD BANG AND THE FRONT PASSENGER TIRE BLEW. THE CONTACT ALMOST LOST CONTROL OF THE VEHICLE AS SHE MERGED ONTO THE SHOULDER AND ROLLED INTO A DITCH. THERE WERE NO INJURIES AND THE VEHICLE WAS NOT DAMAGED. THE TIRE WAS REMOVED AND THE SPARE WAS INSTALLED. THE VEHICLE WAS THEN TAKEN BACK TO THE DEALER WHERE THE TIRE WAS ORIGINALLY PURCHASED AND AFTER INSPECTION, THE TECHNICIAN ADVISED THAT THE COIL SPRING CAUSED THE TIRE DAMAGE. THE DEALER WAS NOTIFIED OF THE COIL SPRING FAILURE AND ADVISED THAT THERE WERE NO RECALLS FOR THE VEHICLE. THE MANUFACTURER WAS CONTACTED WHO CONFIRMED THAT THERE WERE NO RECALLS AND OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 113,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10425753September 16, 2011
SUSPENSION
TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT THE VEHICLE WAS NOT BALANCED AND DROPPED TO THE FLOOR ABNORMALLY. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIAN ADVISED THAT THE FRONT COIL SPRING WAS FRACTURED AND CAUSED DAMAGE TO THE BRAKE PAD AND BLOWER. THE FRONT COIL SPRING, BRAKE PAD AND BLOWER WERE REPLACED. AFTER THE REPAIR THE FRONT COIL SPRING FRACTURED A SECOND TIME. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 59,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10412612July 12, 2011
ENGINE AND ENGINE COOLING:ENGINE
2002 MERCURY SABLE LS. CONSUMER STATES PROBLEMS WITH FUEL INJECTOR AND DAMAGED VALVE *TGW THE CONSUMER STATED WHEN THE CHECK ENGINE LIGHT ILLUMINATED, THE VEHICLE DEVELOPED AN ENGINE MISS. THE PROBLEM WAS DIAGNOSED AS A FAULTY #5 FUEL INJECTOR. CODES PO305 AND PO316. THE COST OF THE REPAIR WAS $800 PLUS DOLLARS. WHEN THE CONSUMER RETRIEVED THE VEHICLE, HE WAS INFORMED THERE WAS SOME CARBON DEPOSITS PRESENT AND THE VEHICLE MIGHT RUN A LITTLE ROUGH UNTIL THE CARBON BURNED OFF. ONE WEEK LATER, THE CHECK ENGINE LIGHT ILLUMINATED AGAIN. IT WAS THE SAME TWO CODES FROM A PREVIOUS REPAIR. THE DEALER INFORMED THE CONSUMER OF A DAMAGED VALVE AND THE COST WOULD BE ANYWHERE FROM $1600-$2000. THE CONSUMER FILED A COMPLAINT WITH THE ATTORNEY GENERALS OFFICE AND WAS REFUNDED HIS MONEY FROM THE PREVIOUS REPAIR. *JB THE CONSUMER STATED THE PROBLEM WITH HIS VEHICLE REMAINS UNRESOLVED. THE ENGINE HAS AN INTERNAL DEFECT. UPDATED 10/17/11*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10409346June 29, 2011
VISIBILITY:SUN/MOON ROOF ASSEMBLY
TL* THE CONTACT OWNS A WEBASTO HOLLANDIA 600 SUNROOF. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V124000(VISIBILITY:SUN ROOF ASSEMBLY). ONCE SHE CONTACTED THE MANUFACTURER, THEY ADVISED HER THAT THE PARTS WERE ON BACKORDER AND WERE UNABLE TO PROVIDED AN ESTIMATED TIME OF AVAILABILITY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 123,000. IT WAS SAID TO TAKE TWO WEESKS UNTIL PARTS WERE IN. NEVER RECIEVED PHONE CALL. IT HAS BEEN CLOSE TO TWO MONTHS. UPDATED 09/01/2011 *LN
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10408693June 23, 2011
SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT STATED THAT THE FRONT COIL SPRING FRACTURED AND PUNCTURED THE TIRE. THE DEALER ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER:04V332000 (SUSPENSION:FRONT:SPRINGS:COIL SPRINGS). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 70,000. THE VEHICLE WAS AWAITING REPAIRS. UPDATED 08/31/11*LJ
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10404193June 2, 2011
SUSPENSION:FRONT
TL*THE CONTACT OWNS 2002 MERCURY SABLE. THE CONTACT STATED WHILE DRIVING, SHE HEARD A LOUD NOISE, AND NOTICED THE PASSENGER FRONT TIRE WAS FLAT DUE TO THE COIL SPRING WHICH BROKE IN HALF AND PUNCTURED THE PASSENGER FRONT TIRE. THE FAILURE OCCURRED WHILE DRIVING AT A LOW SPEED INTO THE DRIVEWAY. THE VEHICLE WAS TAKEN TO THE LOCAL MECHANIC WHO REPLACED THE FRONT COIL SPRINGS, THE STABILIZER LINK, AND TIRE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WOULD NOT ASSIST WITH THE REPAIR, BECAUSE THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 04V332000 SUSPENSION: FRONT: SPRINGS: COIL SPRINGS. THE FAILURE AND THE CURRENT MILES WERE 104,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10402802May 26, 2011
SUSPENSION:FRONT
MY WIFE ENTERED OUR 2002 MERCURY SABLE WAGON TO GO TO WORK TODAY. AS SHE SAT DOWN IN THE CAR, THE LEFT FRONT TIRE EXPLODED. WHEN WE REMOVED THE TIRE TO SEE WHAT HAPPENED, IT WAS APPARENT THAT THE COIL SPRING IN THE SUSPENSION HAD BROKEN AND A SHARP POINT ON THE SPRING PUNCTURED THE TIRE. THE CAR WAS STATIONARY WHEN THIS OCCURRED, THANKFULLY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10401118May 16, 2011
SUSPENSION:FRONT
TL*THE CONTACT OWNS A 2002 MERCURY SABLE. WHILE DRIVING APPROXIMATELY 5 MPH THE CONTACT STATED THAT IT BECAME DIFFICULT TO CONTROL THE STEERING WHEEL AND THEN NOTICED THE PASSENGERS FRONT TIRE BLEW OUT. THE CONTACT INSPECTED THE VEHICLE AND ALSO NOTICED THE FRONT COIL SPRING HAD BROKEN. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED PREVIOUSLY THAT THE REAR COIL SPRINGS HAD ALSO BROKEN. THE APPROXIMATE FAILURE MILEAGE WAS 44,372.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10401540May 11, 2011
SUSPENSION
ON MAY 25, 2010, THE LEFT REAR STRUT AND SPRING BROKE, AND PUNCTURED MY TIRE. ONE YEAR LATER, ALMOST TO THE DATE, THE LEFT FRONT STRUT AND SPRING BROKE AND PUNCTURED THAT TIRE ALSO. LUCKILY FOR THE SECOND INCIDENT, THE CAR WAS PARKED. I WOULD HATE TO THINK WHAT MIGHT HAVE HAPPENED HAD I BEEN DRIVING THE CAR AT THE TIME. THE ROD WAS RIGHT INSIDE THE TIRE, AND I'M SURE IT WOULD HAVE CREATED AN ACCIDENT! FORD/MERCURY HAS NO RECALL ON MY VIN, ALTHOUGH THERE ARE RECALLS ON THE FORD TAURUS, WHICH IS BASICALLY THE SAME CAR. IT IS ALSO NOT PART OF THE FORD CUSTOMER SATISFACTION GUARANTEE AS SOME OF THE TAURUS' ARE. I THINK FORD/MERCURY SHOULD HAVE TAKEN THE APPROPRIATE ACTION TO HAVE THESE REPAIRED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10399044May 3, 2011
SERVICE BRAKES, HYDRAULIC, WHEELS, SUSPENSION
LEFT FRONT SPRING BROKE GOUGING AN 8 INCH TEAR IN TIRE SIDE WALL CAUSING A BLOWOUT AND DAMAGE TO ANTI-LOCK BRAKE SYSTEM. TRANSMISSION MOUNT WAS ALSO DAMAGED. IF THIS HAD HAPPENED AT HIGHWAY SPEEDS, LOSS OF STEERING CONTROL AND BRAKING COULD HAVE CAUSED SERIOUS INJURIES. FORD DENIES ANY RESPONSIBILITY. I WAS TOLD THAT FORD HAD ADMITTED FREQUENT SPRING FAILURE ON ITS 1999 TO 2001 TAURUS/SABLE VEHICLES AND INSTALLED GUARDS TO PROTECT THE TIRES FROM BLOWOUT. THIS IS SECOND SPRING FAILURE IN 2 YEARS. THE FIRST TIME WAS THE RIGHT REAR SPRING BROKE DAMAGING STRUT AND GOUGING TIRE BUT NOT CAUSING DEFLATION. TWO SPRING FAILURES ON THE SAME VEHICLE IN 2 YEARS INDICATE THAT IT IS NOT AN ISOLATED INCIDENT. THIS IS TIME BOMB WAITING FOR SOMEONE TO GET SERIOUSLY INJURED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10398823May 3, 2011
SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
TL* THE CONTACT OWNS A 2002 MERCURY SABLE. WHILE DRIVING APPROXIMATELY 5 MPH IN REVERSE, THE CONTACT SMELLED BURNING RUBBER AND STATED THAT THE TIRE WAS RUBBING AGAINST THE VEHICLE. THE CONTACT INSPECTED THE EXTERIOR OF THE VEHICLE AND DISCOVERED THAT THE FRONT PASSENGER SIDE COIL SPRING WAS FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND THE ENTIRE FRONT END ASSEMBLY WAS REPLACED. THE CONTACT STATED THAT THE REAR SPRINGS AND SHOCKS WERE ALSO REPLACED APPROXIMATELY TWO YEARS PRIOR TO THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10398187April 28, 2011
SUSPENSION:FRONT
WE WERE PULLING OUT OF A PARKING SPACE, HEARD A "WHOOSH" AND FOUND THE FRONT RIGHT TIRE HAD DEFLATED. CALLED AAA TO HAVE IT PUMPED UP OR THE SPARE PUT ON. WHEN THE DRIVER ATTEMPTED TO TAKE THE TIRE OFF, IT WAS STUCK. THE COIL SPRING HAD COME LOOSE AND PUNCTURED THE TIRE. THE COIL WAS STICKING THROUGH THE TIRE LIKE A MEAT HOOK. WE HAD TO CUT THE REST OF THE RUBBER ON THE TIRE TO RELEASE IT. WE HAD THE VEHICLE TOWED AND ARE AWAITING THE REPAIR ESTIMATE. DOING RESEARCH, IT APPEARS THIS IS A LONG-STANDING PROBLEM ON FORD VEHICLES, SPECIFICALLY THE MERCURY SABLE AND TAURUS. RECALLS ON 1999-2001 MODELS WERE NOT EXTENDED BEYOND THOSE YEARS, DESPITE SIMILAR PROBLEMS. WE FEEL WE WERE VERY LUCKY IN THIS INSTANCE, AS THE PREVIOUS DAY, WE HAD A 230 MILE BUSINESS TRIP. IT COULD HAVE BEEN A DISASTER AT 72MPH. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10397117April 22, 2011
SUSPENSION:FRONT:SPRINGS:COIL SPRINGS
TL* THE CONTACT OWNS A 2002 MERCURY SABLE. THE CONTACT WAS DRIVING 15 MPH WHEN THE FRONT COIL SPRING FRACTURED AND PUNCTURED THE FRONT TIRE. THE VEHICLE WAS REPAIRED BY AN AUTOMOTIVE SHOP. IN ADDITION, THE REAR SPRINGS WERE ALSO FRACTURED AND ALL FOUR STRUTS AND SPRINGS WERE REPLACED AS WELL AS THE SWAY BAR. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 140,000. UPDATED 06/24/11 *BF UPDATED 06/30/11.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mercury Sable