Mazda Mazda6 Service Bulletins
1,417 manufacturer communications on file.
- June 19, 2013•Document ID: 10097389Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:12V/24V/48V BATTERY
- Mfr Comm. #:
- 01-016-13-2799
- Date Added:
- April 14, 2017
- Manufacturer:
- MAZDA
SummaryTHIS SERVICE INFORMATION PROVIDES BASIC Q85/T110 BATTERY HANDLING PROCEDURES. COMPLETE SERVICE INFORMATION CAN BE FOUND IN MS3 ONLINE OR WORKSHOP MANUAL (SECTION 01-17). NOTE: THE GR8 BATTERY MANAGEMENT SYSTEM Q85/T110 SOFTWARE IS URRENTLY UNDER DEVELOPMENT. USE THE GR8 BATTERY MANAGEMENT SYSTEM, MANUAL MODE BATTERY CHARGING PROCEDURE IN THIS BULLETIN TO CHARGE THE Q85/T110 BATTERY AT THIS TIME. THIS BULLETIN WILL BE REVISED WHEN THE NEW SOFTWARE IS AVAILABLE.
Associated Products (1)Associated Documents - June 19, 2013•Document ID: 10052813Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:12V/24V/48V BATTERY
- Mfr Comm. #:
- SB-01-016-13
- Date Added:
- September 18, 2013
- Manufacturer:
- MAZDA
SummaryMAZDA: INFORMATION PROVIDED REGARDING THE HANDLING PROCEDURES OF THE HELOOP BATTERY AND SOFTWARE UNDER DEVELOPMENT. MODEL 2014 MAZDA6. *PE
Associated Products (1)Associated Documents - June 14, 2013•Document ID: 10097392Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- 01-015-13-2796
- Date Added:
- April 14, 2017
- Manufacturer:
- MAZDA
SummarySOME VEHICLES MAY EXPERIENCE A MIL ILLUMINATION WITH DTC P2135 STORED IN MEMORY OR DTCS P0123 AND/OR P0222 STORED AFTER THE THROTTLE BODY HAS BEEN REPLACED. DTC P2135: THROTTLE POSITION SENSOR NO.1 / NO. 2 VOLTAGE CORRELATION DTC P0123: THROTTLE POSITION SENSOR NO.1 CIRCUIT HIGH INPUT DTC P0222: THROTTLE POSITION SENSOR NO.2 CIRCUIT LOW INPUT DTCS P0123 AND/OR P0222 MAY BE STORED IMMEDIATELY (OR SOME TIME LATER) AFTER INSTALLING A NEW THROTTLE BODY WITH EITHER PART NUMBER AJ57-13-640D OR AJT1-13-640. THIS IS DUE TO AN ABNORMAL ELECTRICAL NOISE WITHIN THE ENGINE HARNESS OF CERTAIN VEHICLES. THIS CONDITION CAN BE PREVENTED OR CORRECTED BY INSTALLING A SHORT CORD (WITH DIODE) AS DESCRIBED IN THIS SERVICE BULLETIN. NOTE: A SHORT CORD (WITH DIODE) SHOULD ONLY BE USED TO CORRECT DTCS P0123 AND/OR P0222 THAT WERE SET AFTER THE THROTTLE BODY WAS REPLACED. VEHICLES THAT HAVE STORED DTCS P0123 AND/OR P0222 WITHOUT A THROTTLE BODY REPLACEMENT SHOULD BE DIAGNOSED AND REPAIRED ACCORDING TO THE WORKSHOP MANUAL, NOT THIS SERVICE BULLETIN.
Associated Products (2)Associated Documents - June 14, 2013•Document ID: 10097391Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- 01-014-13-2798
- Date Added:
- April 14, 2017
- Manufacturer:
- MAZDA
SummarySOME VEHICLES MAY EXPERIENCE A MAZDA RADAR CRUISE CONTROL (MRCC) WARNING LIGHT ON WITH DTC C1A67:92 (RADAR SENSOR SENSITIVITY LOWERED). FOW, MRCC RADAR BLOCKED MESSAGE WILL BE DISPLAYED IN THE INSTRUMENT CLUSTER MULTI-INFORMATION DISPLAY.
Associated Products (1)Associated Documents - June 14, 2013•Document ID: 10097390Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- 09-019-13-2805
- Date Added:
- April 14, 2017
- Manufacturer:
- MAZDA
SummaryTO IMPROVE HANDLING OF CUSTOMER CONCERNS WITH HANDS-FREE (BLUETOOTH) VEHICLE SYSTEMS, MAZDA LAUNCHED A NEW SERVICE PROCEDURE AND PART EXCHANGE PROGRAM EFFECTIVE FEB. 08, 2010 ON APPLICABLE VEHICLES. DUE TO THE COMPLEXITY OF SOFTWARE AND HARDWARE AVAILABLE ON VARIOUS CELLULAR PHONES AND CELL PHONE PROVIDER NETWORKS, IT IS ESSENTIAL FOR CUSTOMERS TO CONTACT THE MAZDA HANDS-FREE SYSTEM CUSTOMER CARE NUMBER AT (800) 430-0153 OR, FOR CUSTOMERS REQUIRING ADDITIONAL RESOURCES, PLEASE DIRECT THEM TO WWW.MAZDAUSA.COM/BLUETOOTH. REPRESENTATIVES OF THE CUSTOMER CARE CENTER ARE KNOWLEDGEABLE ON VERIFYING APPROVED PHONES AND PROPERLY PAIRING (PROGRAMMING) SPECIFIC PHONES TO THE VEHICLES BLUETOOTH SYSTEM. THEY ARE ALSO BEST EQUIPPED TO RESOLVE A MAJORITY OF THE PAIRING ISSUES AND OTHER BLUETOOTH RELATED CONCERNS WHEN COMMUNICATING DIRECTLY WITH MAZDA CUSTOMERS.
Associated Products (37)2014 Mazda CX-52013 Mazda CX-52013 Mazda CX-92013 Mazda Mazda32013 Mazda Mazda52013 Mazda Mazda62013 Mazda MX-52012 Mazda CX-72012 Mazda CX-92012 Mazda Mazda32012 Mazda Mazda52012 Mazda Mazda62012 Mazda MX-52011 Mazda CX-72011 Mazda CX-92011 Mazda Mazda32011 Mazda Mazda52011 Mazda Mazda62011 Mazda MX-52011 Mazda RX-8+ 17 moreAssociated Documents - June 14, 2013•Document ID: 10059438Service Bulletin/Repair InstructionsVEHICLE SPEED CONTROL:CRUISE CONTROL
- Mfr Comm. #:
- 01-014-13
- Date Added:
- March 16, 2016
- Manufacturer:
- MAZDA
SummarySUMMARY TO BE PROVIDED ON A FUTURE DATE.
Associated Products (1)Associated Documents - June 14, 2013•Document ID: 10052628Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- SB-01-015-13
- Date Added:
- August 26, 2013
- Manufacturer:
- MAZDA
SummaryMAZDA: AFTER THROTTLE BODY HAD BEEN REPLACED, ON CERTAIN VEHICLES, THE MIL WILL ILLUMINATE DUE TO AN ELECTRICAL NOISE, WITHIN THE ENGINE HARNESS THAT IS ABNORMAL. MODEL 2003-2004 MAZDA6. *PE
Associated Products (2)Associated Documents - June 4, 2013•Document ID: 10097394Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- 09-018-13-2803
- Date Added:
- April 14, 2017
- Manufacturer:
- MAZDA
SummarySOME CUSTOMERS MAY COMPLAIN THAT THE AMBIENT TEMPERATURE DISPLAY IS NOT ACCURATE, OR IT TAKES TOO LONG FOR THE DISPLAY TO SHOW ACTUAL TEMPERATURE. WHEN YOU ENCOUNTER A CUSTOMER WITH THIS CONCERN, FIRST VERIFY THE CONDITION WHEN THE CUSTOMER NOTICED THIS SYMPTOM. IF THE CONDITION IS SIMILAR TO THE FOLLOWING CONTROL LOGIC OF AMBIENT TEMPERATURE OR DIFFERENCE BETWEEN THE TEMPERATURE DISPLAY AND OTHERS, ADVISE THE CUSTOMER THAT THIS IS A NORMAL CHARACTERISTIC OF THE VEHICLE AND NOT A MALFUNCTION. IF THE CONDITION DOES NOT MEET THE FOLLOWING AND THE SENSOR MALFUNCTION IS SUSPECTED, MAKE SURE TO INSPECT THE SENSOR ACCORDING TO MS3 ONLINE OR WORKSHOP MANUAL (SECTION 09-22 AMBIENT TEMPERATURE SENSOR INSPECTION).
Associated Products (55)2014 Mazda CX-52014 Mazda Mazda62013 Mazda CX-52013 Mazda CX-92013 Mazda Mazda22013 Mazda Mazda32013 Mazda Mazda52013 Mazda Mazda62013 Mazda MX-52012 Mazda CX-72012 Mazda CX-92012 Mazda Mazda22012 Mazda Mazda32012 Mazda Mazda52012 Mazda Mazda62012 Mazda MX-52011 Mazda CX-72011 Mazda CX-92011 Mazda Mazda22011 Mazda Mazda3+ 35 moreAssociated Documents - June 4, 2013•Document ID: 10097393Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- 02-006-13-2804
- Date Added:
- April 14, 2017
- Manufacturer:
- MAZDA
SummaryBEGINNING WITH THE NEWER MODELS (CX-5 AND MAZDA6), GRIP TYPE FRONT AND REAR STABILIZER BUSHINGS (A) HAVE BEEN INCORPORATED FOR NOISE PREVENTION PURPOSES. IF ANY TYPE OF GREASE OR LUBRICATION IS APPLIED TO THE BUSHINGS, IT MAY CREATE NOISE DUE TO BUSHING SLIPPAGE (CX-5 FRONT BUSHINGS SHOWN BELOW).
Associated Products (3)Associated Documents - June 4, 2013•Document ID: 10059475Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- 02-006-13
- Date Added:
- March 16, 2016
- Manufacturer:
- MAZDA
SummarySUMMARY TO BE PROVIDED ON A FUTURE DATE.
Associated Products (3)Associated Documents - May 24, 2013•Document ID: 10097383Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- 05-004-13-2800
- Date Added:
- April 14, 2017
- Manufacturer:
- MAZDA
SummarySOME CUSTOMERS MAY COMPLAIN OF A CHECK ENGINE LIGHT AND A/T WARNING LIGHT ON WHEN STARTING THE ENGINE. AT THE SAME TIME, AN ENGINE INSPECTION REQUIRED MESSAGE IS DISPLAYED ON THE LCD. DTC P0722:00 IS STORED IN THE TRANSMISSION CONTROL MODULE (TCM) MEMORY. DTC P0722:00 (OPEN CIRCUIT IN OUTPUT SPEED SHAFT CIRCUIT)THE TCM CONTROL LOGIC HAS BEEN CHANGED TO ELIMINATE THIS CONCERN.
Associated Products (6)Associated Documents - May 24, 2013•Document ID: 10059501Service Bulletin/Repair InstructionsELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
- Mfr Comm. #:
- 05-004-13
- Date Added:
- March 16, 2016
- Manufacturer:
- MAZDA
SummarySUMMARY TO BE PROVIDED ON A FUTURE DATE.
Associated Products (5)Associated Documents - May 7, 2013•Document ID: 10097385Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
- Mfr Comm. #:
- 09-015-13-2797
- Date Added:
- April 14, 2017
- Manufacturer:
- MAZDA
SummaryTHE NAVIGATION SYSTEM SUPPORT FOR DIAGNOSTICS, PARTS AUTHORIZATION, AND PARTS EXCHANGE REQUIRE CONTACTING THE PROPER SOURCE.TOMTOM NAVIGATION HELP DESK AT 866-486-6866 FROM 7AM-11PM (M-F) AND 9AM-8PM (SAT) EASTERN STAN-DARD TIME.NOTE:ONE OF THE FIRST STEPS FOR TROUBLESHOOTING THE NAVIGATION SYSTEM IS FOR THE CUSTOMER TO CALL TOMTOM. IF THE TOMTOM CALL CENTER CANNOT SOLVE THE CUSTOMERS PROBLEM, THEY WILL PROVIDE A CASE NUMBER TO THE CUSTOMER THAT CAN BE REFERRED TO IF NEEDED. SERVICE ADVISORS SHOULD GET THIS CASE NUMBER FROM THE CUSTOMER IF THE VEHICLE COMES INTO THE DEALER FOR FURTHER DIAGNOSIS SO THE TECHNICIAN CAN HAVE IT WHEN CALLING TOMTOM.
Associated Products (5)Associated Documents - May 7, 2013•Document ID: 10060489Service Bulletin/Repair InstructionsEQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
- Mfr Comm. #:
- 09-015-13
- Date Added:
- March 31, 2016
- Manufacturer:
- MAZDA
SummarySUMMARY TO BE PROVIDED ON A FUTURE DATE.
Associated Products (5)Associated Documents - May 3, 2013•Document ID: 10097387Service Bulletin/Repair InstructionsVISIBILITY:SUN/MOON ROOF ASSEMBLY
- Mfr Comm. #:
- 09-014-13-2790
- Date Added:
- April 14, 2017
- Manufacturer:
- MAZDA
SummarySOME CUSTOMERS MAY EXPERIENCE A WATER LEAK FROM THE SUNROOF AFTER WASHING THE VEHICLE WITH A HIGH-PRESSURE CAR WASH SYSTEM. HIGH PRESSURE WATER FROM THE CAR WASH MAY DRIP FROM THE DRIP RAIL AND LEAK INTO THE CABIN.
Associated Products (10)Associated Documents - April 17, 2013•Document ID: 10097375Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- 00-001-13-2748A
- Date Added:
- April 14, 2017
- Manufacturer:
- MAZDA
SummaryMAZDA HAS DEVELOPED FACTORY RECOMMENDED SCHEDULED MAINTENANCE SERVICES THAT SUPPORT ALL MAJOR VEHICLE SYSTEMS. MAZDA RECOMMENDS DEALERS FOLLOW THE SCHEDULED MAINTENANCE TABLES AS CITED IN THE VEHICLE-SPECIFIC WORKSHOP MANUAL OR OWNERS MANUAL. SERVICES PERFORMED OUTSIDE OF MAZDAS FACTORY SCHEDULED MAINTENANCE ARE NOT RECOMMENDED. THESE SERVICES ARE UNNECESSARY AND CREATE UNNEEDED EXPENSES FOR YOUR CUSTOMERS.
Associated Products (110)2014 Mazda CX-52014 Mazda Mazda32014 Mazda Mazda62013 Mazda CX-52013 Mazda CX-92013 Mazda Mazda22013 Mazda Mazda32013 Mazda Mazda52013 Mazda Mazda62013 Mazda MX-52012 Mazda CX-72012 Mazda CX-92012 Mazda Mazda22012 Mazda Mazda32012 Mazda Mazda52012 Mazda Mazda62012 Mazda MX-52011 Mazda CX-72011 Mazda CX-92011 Mazda Mazda2+ 90 moreAssociated Documents - April 17, 2013•Document ID: 10097374Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- 01-010-13-2775B
- Date Added:
- April 14, 2017
- Manufacturer:
- MAZDA
SummaryON CERTAIN SUBJECT VEHICLES, THE MALFUNCTION INDICATOR LIGHT (MIL) MAY ILLUMINATE WITH DTC P0126:00 (THERMOSTAT STUCK OPEN) STORED IN THE POWERTRAIN CONTROL MODULE (PCM) MEMORY. THE THERMOSTAT FUNCTIONS NORMALLY, BUT THE THERMOSTAT STUCK OPEN CONDITION IS MISTAKENLY DETECTED DUE TO INAPPROPRIATE PCM SOFTWARE.THIS CONCERN WILL OCCUR UNDER THE FOLLOWING CONDITIONS: WHEN DRIVING ON HIGHWAYS/FREEWAYS IMMEDIATELY AFTER A COLD STARTWHEN THE AMBIENT TEMPERATURE IS 14 TO 32 DEGREES F (-10 TO 0 DEGREES C) WHEN OPERATING THE HVAC SYSTEM IN THE MAXIMUM AIRFLOW MODE
Associated Products (3)Associated Documents - April 17, 2013•Document ID: 10059434Service Bulletin/Repair InstructionsPOWER TRAIN:AUTOMATIC TRANSMISSION
- Mfr Comm. #:
- 01-010-13
- Date Added:
- March 16, 2016
- Manufacturer:
- MAZDA
SummarySUMMARY TO BE PROVIDED ON A FUTURE DATE.
Associated Products (3)Associated Documents - April 10, 2013•Document ID: 10097377Service Bulletin/Repair InstructionsSTEERING: STEERING WHEEL/HANDLE BAR
- Mfr Comm. #:
- 02-004-13-2770A
- Date Added:
- April 14, 2017
- Manufacturer:
- MAZDA
SummarySOME CUSTOMERS MAY COMPLAIN THAT THE STEERING WHEEL IS OFF CENTER MORE THAN 3° EVEN WHEN DRIVING STRAIGHT ON A FLAT ROAD.
Associated Products (72)2014 Mazda CX-52013 Mazda CX-52013 Mazda CX-92013 Mazda Mazda22013 Mazda Mazda32013 Mazda Mazda52013 Mazda Mazda62013 Mazda MX-52012 Mazda CX-72012 Mazda CX-92012 Mazda Mazda22012 Mazda Mazda32012 Mazda Mazda52012 Mazda Mazda62012 Mazda MX-52011 Mazda CX-72011 Mazda CX-92011 Mazda Mazda22011 Mazda Mazda32011 Mazda Mazda5+ 52 moreAssociated Documents - April 2, 2013•Document ID: 10097379Service Bulletin/Repair InstructionsEQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
- Mfr Comm. #:
- 01-010-13-2775A
- Date Added:
- April 14, 2017
- Manufacturer:
- MAZDA
SummaryON CERTAIN SUBJECT VEHICLES, THE MALFUNCTION INDICATOR LIGHT (MIL) MAY ILLUMINATE WITH DTC P0126:00 (THERMOSTAT STUCK OPEN) STORED IN THE POWERTRAIN CONTROL MODULE (PCM) MEMORY. THE THERMOSTAT FUNCTIONS NORMALLY, BUT THE THERMOSTAT STUCK OPEN CONDITION IS MISTAKENLY DETECTED DUE TO INAPPROPRIATE PCM SOFTWARE.THIS CONCERN WILL OCCUR UNDER THE FOLLOWING CONDITIONS: WHEN DRIVING ON HIGHWAYS/FREEWAYS IMMEDIATELY AFTER A COLD STARTWHEN THE AMBIENT TEMPERATURE IS 14 TO 32 DEGREES F (-10 TO 0 DEGREES C) WHEN OPERATING THE HVAC SYSTEM IN THE MAXIMUM AIRFLOW MODE
Associated Products (3)Associated Documents