Mazda Mazda6 Service Bulletins
1,417 manufacturer communications on file.
- March 13, 2017•Document ID: 10111012Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.; EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
- Mfr Comm. #:
- 09-009-17-3302
- Date Added:
- August 10, 2017
- Manufacturer:
- MAZDA
SummarySome vehicles may exhibit navigation unit that cannot read out SMS (Short Messages Service) or does not operate properly after reading SMS. These concerns may be caused by problems with the Bluetooth Unit software.
Associated Products (9)Associated Documents - March 9, 2017•Document ID: 10111011Service Bulletin/Repair InstructionsEXTERIOR LIGHTING:HEADLIGHTS
- Mfr Comm. #:
- 09-008-17-3324
- Date Added:
- August 10, 2017
- Manufacturer:
- MAZDA
SummaryTake caution when cleaning plastic headlight lenses. Damage can occur when using some cleaners that contain strong acid, alkaline cleanser or organic solvent. Damage caused by using these cleaners is not covered by Mazda's New Vehicle Limited Warranty term.
Associated Products (91)2017 Mazda CX-32017 Mazda CX-52017 Mazda CX-92017 Mazda Mazda22017 Mazda Mazda32017 Mazda Mazda62017 Mazda MX-52016 Mazda CX-32016 Mazda CX-52016 Mazda CX-92016 Mazda Mazda22016 Mazda Mazda32016 Mazda Mazda52016 Mazda Mazda62016 Mazda MX-52015 Mazda CX-52015 Mazda CX-92015 Mazda Mazda22015 Mazda Mazda32015 Mazda Mazda5+ 71 moreAssociated Documents - March 9, 2017•Document ID: 10111010Service Bulletin/Repair InstructionsWHEELS
- Mfr Comm. #:
- 02-002-17-3281a
- Date Added:
- August 10, 2017
- Manufacturer:
- MAZDA
SummarySome vehicles may exhibit an aluminum alloy type wheel(s) having one of the following paint damage conditions shown in the sample photos below.The damage extends to the front surface of the aluminum wheel partly or entirely.
Associated Products (6)Associated Documents - March 7, 2017•Document ID: 10111009Service Bulletin/Repair InstructionsPARKING BRAKE; SERVICE BRAKES, HYDRAULIC
- Mfr Comm. #:
- 04-001-17-3303a
- Date Added:
- August 10, 2017
- Manufacturer:
- MAZDA
SummarySome vehicles may exhibit a squeak type noise from the rear brakes when driving at approximately 6-12mph (10-20km/h) with or without light braking. The noise usually occurs when driving immediately after the parking brake is released. The noise may be caused by poor bake pad adhesive tape contact.
Associated Products (1)Associated Documents - March 6, 2017•Document ID: 10098384Service Bulletin/Repair InstructionsEQUIPMENT ADAPTIVE/MOBILITY
- Mfr Comm. #:
- MT-003-17
- Date Added:
- May 5, 2017
- Manufacturer:
- MAZDA
SummaryWHEN INSTALLING A NAVIGATION SD CARD, CONFIRM THAT THE CARD IS UNLOCKED. ALSO, MAZDA DOES NOT RECOMMEND SWAPPING NAVIGATION SYSTEM SD CARDS FROM ONE VEHICLE TO ANOTHER FOR TESTING. IF SWAPPED, THE SD CARD THAT IS INSTALLED INTO THE OTHER VEHICLE BECOMES LINKED TO THE VIN OF THAT VEHICLE.
Associated Products (16)Associated Documents - March 3, 2017•Document ID: 10111007Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING
- Mfr Comm. #:
- 01-005-17-3305
- Date Added:
- August 10, 2017
- Manufacturer:
- MAZDA
SummarySome vehicles may exhibit oil residue on the engine front cover from seepage around the joint portion (A) between the cylinder block and head. It becomes very noticable with dust adhesion. In some cases, the area of oil residue extends down to around the joint portion (B) between the engine front cover and the oil pan.
Associated Products (12)Associated Documents - March 2, 2017•Document ID: 10111006Service Bulletin/Repair InstructionsSUSPENSION; SUSPENSION:FRONT:SHOCK ABSORBER; SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
- Mfr Comm. #:
- 02-003-17-3300a
- Date Added:
- August 10, 2017
- Manufacturer:
- MAZDA
SummarySome vehicles may exhibit a knocking / squeaking noise from the front shock absorber when driving on rough roads and/or when turning the steering wheel while the vehicle is stopped. The noise may be due to: *upper front strut bearing (A) damage. (CX-5 and Mazda6) *squeak type noise between the front strut bearing and coil spring. (CX-3, CX-5 and Mazda6) *the bump stopper (C) may be contacting the strut bearing when the front shock absorber is compressed, causing a popping noise. (Mazda6 only) *The front lower arm bushing (D) is making a creak type noise in wet road conditions. (CX-5, Mazda6 and CX-9).
Associated Products (10)Associated Documents - March 2, 2017•Document ID: 10111005Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
- Mfr Comm. #:
- 01-002-17-3299a
- Date Added:
- August 10, 2017
- Manufacturer:
- MAZDA
SummaryWhen the engine is started for the first time after parking the vehicle overnight in cold conditions (below 32 degrees Fahrenheit / 0 degrees Celsius), some vehicles may exhibit a rough idle and/or the check engine light on with any of the following DTC(s) stored in memory.?P0300 - Random misfire detected ?P0301 - Cylinder No.1 misfire detected ?P0302 - Cylinder No.2 misfire detected ?P0303 - Cylinder No.3 misfire detected ?P0304 - Cylinder No.4 misfire detected This may be caused by frozen water accumulated in the main silencer, restricting exhaust flow.
Associated Products (14)Associated Documents - March 1, 2017•Document ID: 10111004Service Bulletin/Repair InstructionsAIR BAGS; ELECTRICAL SYSTEM:SOFTWARE; EQUIPMENT:ELECTRICAL
- Mfr Comm. #:
- 08-002-17-3312
- Date Added:
- August 10, 2017
- Manufacturer:
- MAZDA
SummaryWhen monitoring the resistance of the air bag modules and pre-tensioner seat belts, the Mazda Modular Diagnostic System (M-MDS) may display a value of only 1/100th of the actual resistance value. This is caused by improper SAS control unit software. To eliminate this from occurring in the future, the SAS control unit software has been modified.
Associated Products (7)Associated Documents - February 27, 2017•Document ID: 10186323Service Bulletin/Repair InstructionsEQUIPMENT
- Mfr Comm. #:
- SA-037-17
- Date Added:
- February 1, 2021
- Manufacturer:
- MAZDA
SummaryRECALL 0516J UPDATED REPAIR PROCEDURE
Associated Products (9)Associated Documents - February 21, 2017•Document ID: 10186313Service Bulletin/Repair InstructionsENGINE
- Mfr Comm. #:
- 01-004-17
- Date Added:
- February 1, 2021
- Manufacturer:
- MAZDA
SummaryMulti-Model - engine runs rough and check engine light on with DTCS P0201 and P0204 or P0202 and P0203
Associated Products (10)Associated Documents - February 14, 2017•Document ID: 10185820Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- ONP07
- Date Added:
- January 25, 2021
- Manufacturer:
- MAZDA
SummaryOwner Notification program ONP07 Mazda mobile start (MMS) system
Associated Products (9)Associated Documents - February 13, 2017•Document ID: 10186314Service Bulletin/Repair InstructionsSERVICE BRAKES, HYDRAULIC
- Mfr Comm. #:
- 04-001-17
- Date Added:
- February 1, 2021
- Manufacturer:
- MAZDA
SummaryRear brake squeak noise during slow speed driving
Associated Products (1)Associated Documents - February 8, 2017•Document ID: 10185817Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- SA392
- Date Added:
- January 25, 2021
- Manufacturer:
- MAZDA
SummaryStopper plates for air bag module connectors have been established as new service parts
Associated Products (9)Associated Documents - February 8, 2017•Document ID: 10185813Service Bulletin/Repair InstructionsELECTRICAL SYSTEM:SOFTWARE; EQUIPMENT
- Mfr Comm. #:
- SA385
- Date Added:
- January 25, 2021
- Manufacturer:
- MAZDA
SummaryIf you experience issues with the current version of ID's such as missing tools or modules not showing after completing a network test, be advised that we are aware of these issues and are working to resolve them. As a counter measure, it is advised that you un-install ids and re-install version 103.00 and "do not update" until further notice.
Associated Products (9)Associated Documents - January 23, 2017•Document ID: 10185810Service Bulletin/Repair InstructionsELECTRICAL SYSTEM
- Mfr Comm. #:
- RF-17-01
- Date Added:
- January 25, 2021
- Manufacturer:
- MAZDA
SummaryAll models - Stopper plates for air bag module coinnectors
Associated Products (9)Associated Documents - January 20, 2017•Document ID: 10185796Service Bulletin/Repair InstructionsFUEL SYSTEM, GASOLINE; SERVICE BRAKES; AIR BAGS; BACK OVER PREVENTION
- Mfr Comm. #:
- 01-003-17
- Date Added:
- January 25, 2021
- Manufacturer:
- MAZDA
SummaryWhen the engine is started for the first time after parking overnight in cold weather (below freezing), some vehicles may exhibit the check engine light on with DTC P0451 (fuel tank pressure sensor: sensor characteristic malfunction) stored in memory. This concern may be caused by an increase in discharge resistance due to water accumulated and frozen in the canister vent hose.
Associated Products (3)Associated Documents - January 19, 2017•Document ID: 10185792Service Bulletin/Repair InstructionsEQUIPMENT; STRUCTURE
- Mfr Comm. #:
- 00-001-17
- Date Added:
- January 25, 2021
- Manufacturer:
- MAZDA
SummarySpecial Service Tool Shipment - January 2017. In support of the 2014 - 17 Mazda6 and 2016-17 Mazda CX-9, Mazda will ship to all dealers a new Special Service Tool (SST) * The SST will be shipped by Mazda's toool vendor Bosch in the month of January, 2017 * The following SST is the latest addition to the Mazda required tool (MRT).
Associated Products (4)Associated Documents - January 13, 2017•Document ID: 10185795Service Bulletin/Repair InstructionsENGINE AND ENGINE COOLING:EXHAUST SYSTEM; AIR BAGS
- Mfr Comm. #:
- 01-002-17
- Date Added:
- January 25, 2021
- Manufacturer:
- MAZDA
SummaryWhen the engine is started for the first time after parking the vehicle overnight in cold conditions (below 32 degrees Fahrenheit/0 degrees Celsious). Some vehicles may exhibit a rough idle and/or the check engine light on with any of the following DTC(s) stored in memory. *P0300 - Random misfire detected *P0301-Cylinder No.1 misfire detected *P0302 Cylinder No.2 misfire detected *P0303-Cylinder No.3 misfire detected *P0304 Cynlinder No.4 misfire Detected This may be caused by frozen water accumulated in the main silencer, restricting exhaust flow. Customers having this cocern should have their vehicle repaired using the ffollowifng repair procedure.
Associated Products (6)Associated Documents - January 6, 2017•Document ID: 10185798Service Bulletin/Repair InstructionsWHEELS
- Mfr Comm. #:
- 02-002-17
- Date Added:
- January 25, 2021
- Manufacturer:
- MAZDA
SummaryAluminum wheel paint damage (Black spot, flanking, discolored, blackened) Some vehicles may exhibit the bright type aluminum wheel(s) having one of paint damage conditions dhown in the sample photos below. The damage extends to the front surface of the aluminum wheel partly or entirely.
Associated Products (1)Associated Documents