Kia Motors Corporation (Kia) is recalling certain model year 2007-2010 Rondo, model year 2007-2011 Sedona, Sorento and Sportage, model year 2010-2011 Soul, model year 2008-2011 Optima, model year 2010 Forte, model year 2007-2009 Amanti, and model year 2009 Borrego vehicles. Originally, in April 2013, Kia recalled 623,658 model year 2007-2010 Rondo and Sportage, model year 2007-2011 Sorento, model year 2007 Sedona, model year 2010-2011 Soul, and model year 2011 Optima vehicles. In September 2013, Kia informed the agency that it was adding an additional 356,719 vehicles to this campaign. The total number of vehicles being recalled is now 980,377. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake-transmission shift interlock feature preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate.
KIA MOTORS AMERICA, INC. (KIA) IS RECALLING CERTAIN MODEL YEAR 2006-2008 KIA OPTIMA VEHICLES MANUFACTURED FROM SEPTEMBER 29, 2005, THROUGH JANUARY 29, 2008, AND MODEL YEAR 2007 AND 2008 KIA RONDO VEHICLES MANUFACTURED FROM SEPTEMBER 13, 2006, THROUGH MARCH 21, 2008. THE CLOCK SPRING CONTACT ASSEMBLY FOR THE DRIVER'S SIDE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM (SRS) MAY BECOME DAMAGED THROUGH USAGE OVER TIME. IF THE CLOCK SPRING CONTACT ASSEMBLY BECOMES DAMAGED, THE DRIVER'S AIR BAG ELECTRICAL CIRCUIT WILL EXPERIENCE A HIGH RESISTANCE CONDITION POTENTIALLY CAUSING THE DRIVER'S AIR BAG TO NOT DEPLOY.
HUYNDAI-KIA IS RECALLING 139,844 MY 2006-2007- SEDONA, SPORTAGE, SORENTO AND MY RONDO AND AMANTI VEHICLES. THE STOP LAMP SWITCH IN THE AFFECTED VEHICLES MAY MALFUNCTION. A MALFUNCTIONING STOP LAMP SWITCH MAY CAUSE THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE BRAKE PEDAL IS DEPRESSED OR MAY CAUSE THE BRAKE LIGHTS TO REMAIN ILLUMINATED WHEN THE BRAKE PEDAL IS RELEASED. A STOP LAMP SWITCH MALFUNCTION MAY ALSO AFFECT THE OPERATION OF THE BRAKE-TRANSMISSION SHIFT INTERLOCK FEATURE SO THE TRANSMISSION SHIFTER WOULD NOT BE ABLE TO BE SHIFTED OUT OF THE PARK POSITION. IT MAY ALSO CAUSE THE ELECTRONIC STABILITY CONTROL (ESC) MALFUNCTION LIGHT TO ILLUMINATE, AND IT MAY NOT DEACTIVATE THE CRUISE CONTROL WHEN THE BRAKE PEDAL IS DEPRESSED.
The contact owns a 2007 Kia Rondo. The contact stated while driving 25 MPH, the traction control warning light and driver's side air bag warning light illuminated. The contact was able to continue driving. The contact became aware of Kia Independent Recall Campaign Number: SC094 (Clock Spring Assembly Replacement). The vehicle was taken to the local dealer who informed the contact that they could not assist as the VIN was a Canadian VIN. The contact was referred to Kia Canada for recall information. The contact then contacted Kia Canada who informed her that the vehicle was previously serviced under the independent recall. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 140,000.
No injuries · No fire · No crash
NHTSA ID Number: 11476858 Brake lights will not go off.I found white Plastic nylon washer broke into many pieces in floor board mat. It is the Brake pedal pad stop washer. After researching, This is a common issue with these vehicles. This defective component has a high probabilty of causing rear end collisions due to the Brake lights staying on. NHTSA should do a safety recall on these vehicles.
No injuries · No fire · No crash
The contact owns a 2007 Kia Rondo. The contact stated that while operating the vehicle, the brake lights remained illuminated at all time. Additionally, the brake lights also remained illuminated while the vehicle was turned off. The fuse was removed to turn the brake lights off. The cause of the failure was not determined. The manufacturer and local dealer were not notified of the failure. The failure mileage was unknown.
No injuries · No fire · No crash
What component or system failed or malfunctioned, and is it available for inspection upon request? 2.4L Theta engine has developed a knocking sound at 155,600 miles. Oil consumption is excessive. Currently vehicle has Pennzoil Platinum High Mileage 5W20 oil. It has been approximately 5600 miles since last oil and filter change, and vehicle was 2 qts low. Knocking sound is consistent with what others have reported with the later 2.4L Theta II engine. Symptom is consistent with spun rod bearing. It is currently available for inspection, pending me selling the car. How was your safety or the safety of others put at risk? Car is a serious risk of stalling. Has previously stalled before. Has the problem been reproduced or confirmed by a dealer or independent service center? No. Selling dealership is under different ownership and has disavowed prior ownership. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? None.
No injuries · No fire · No crash
THE A/C LINE DRAINES ONTO THE FRONT SUBFRAME. DOING THIS I BELIEVE HAS CAUSED IT TO RUST OVER THE YEARS. NOW IT IS NOT SAFE TO DRIVE FOR FEAR THAT THE ENGINE OR FRONT CONTROL WILL BRING THE CAR TO A HALT. IT MAY CAUSE A SERIOUS ACCIDENT
No injuries · No fire · No crash