Kia Forte Complaints (2020)

78 consumer complaints on file.

#11769976October 8, 2026
ENGINE, FORWARD COLLISION AVOIDANCE: WARNINGS
During a day trip on 9/19/26 my 2020 Kia Forte (purchased new and well maintained) lost power and several of the dash board lights came on including check engine, traction/stability control, and collision alerts. The car entered what I was told is "limp mode". I had the car towed home and after one shop misdiagnosed the problem I had it towed to the Kia dealership where purchased. I was told the engine had code p0017. I was sent a document that the "phaser sheared off p0017 exhaust cam and cvvd gear timing off-recommend long block-cvvd replacement may still have engine damaged after replacement" with a price of $9053.39 attached. Kia service manager is supposed to be seeing about assistance for repair as it is cost prohibitive and I have proof of proper maintenance however I am not receiving info on process unless I reach out. Car has been in Kia possession since 9/24/26.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11769309October 6, 2026
ENGINE
My engine is failing due to excessive oil consumption despite having proof of regular oil changes and maintenance. My car has been inspected, and the dealer has stated this is due to a known manufacture defect. My safety and others are at risk because my car stalls when I decrease speed and I cannot accelerate fast enough to get up to the speed limit creating a risk anytime the speed limit changes or when I am using an on ramp to get onto an interstate or highway. Kia dealer has confirmed the issue and is currently working on an estimate for a new engine. The Kia dealer is the manufacturer of my vehicle. The warning sign before this happened was my car stalled a couple times, then the check engine light came on within 10 miles. I then took it in to get looked at where the Kia dealer diagnosed the issue as the known manufacturer defect with the engine burning oil too quickly. These issues first appeared on August 12, 2026. I have attempted to get Kia corporate to assist with repairs through a Goodwill Request due to the safety issues with driving my vehicle in its current condition, to no fault of my own. Kia denied my Goodwill request. That case number is 26467063.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11765834September 21, 2026
ENGINE
The engine has failed in this vehicle just like it has in other 2.0L kia vehicles 2020-2026. The piston rings have failed and the pistons have all pitted or developed holes in them just like in the recall 25V-099/kia safety recall SC336
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11763097September 9, 2026
UNKNOWN OR OTHER
The infotainment screen is de-laminating.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759556August 25, 2026
AIR BAGS
The contact owns a 2020 Kia Forte. The contact stated that while driving at an undisclosed speed, the air bags warning light illuminated and then went off. The contact stated that while attempting to start the vehicle, the air bag warning light was again illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 109,900.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758838August 23, 2026
ENGINE
Engine burning excessive oil over a quart in 1000 miles. Catalytic converter code P0420 because of the excessive oil burning. Oil was always changed within the specified dealer milage range.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758381August 20, 2026
POWER TRAIN, ENGINE, UNKNOWN OR OTHER
I experienced a check engine light and had the vehicle diagnosed with codes P0017 and P0014. The vehicle was taken to a Kia dealership, where the technician found that the exhaust camshaft was free-spinning without the phaser and that the pin connecting the two had sheared. The dealership replaced the exhaust camshaft and phaser and released the vehicle as repaired and operating normally. Less than 24 hours after pickup, the check engine light returned during normal driving. While returning the vehicle to the dealership as instructed, the engine lost oil pressure and stalled three times. One stall occurred after exiting the highway and left the vehicle disabled in a high-traffic intersection, creating a serious safety hazard. The vehicle was returned to the Kia dealership and remains available for inspection. Subsequent examination reportedly found metal debris in the engine/oil pan and a possible restriction of engine oil flow. The exact cause of the sudden oil-pressure loss has not yet been definitively explained. The failure occurred immediately following a dealership repair involving a physically sheared internal engine component.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749072July 8, 2026
ENGINE, FORWARD COLLISION AVOIDANCE: WARNINGS
2020 Kia Forte, 2.0L 14F engine, 109,000 miles: On July 3.2026 "check engine" light came on. Drove to local auto parts store to have code downloaded, P0017 cam position sensor. Car was performing fine, except for engine light. Drove car to Kia dealership. While driving, warning light for "front collision system came on and car began performing erratically. Left car at dealership for diagnostics. Yesterday received call from dealer, stating that engine needed total replacement due to "lack of oil". Quoted repair cost estimated at approximately $8,000. Car has been regularly serviced, including oil and filter changes per handbook. I have all records for the services. The were no indications of low oil pressure or engine overheating, no warning lights, all gauge readings displayed normal ranges. This same car had a failed transmission replaced approximately 2 years ago, which was covered by an extended warranty related to a recall. There have been 2 engine failure recalls as a result of 2 class action lawsuits for Kia cars with this same engine failure up through the 2019 model years, providing new engines and/or extended warrantees, however, this does not applicable to 2020 and newer models, even though it's the same exact same engine model with the exact issue causing the failure. Engine failure in traffic condions can obviously lead to immediate safety issues. I currently have a call into the Kia customer service/complaint department, but no resolution offerred to date.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746397June 25, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2020 Kia Forte. The contact stated that while driving at an undisclosed speed, the engine seized. There was no warning light illuminated. The failure had occurred while the contact was driving on a major highway. The vehicle was towed to the dealer where it was diagnosed with engine failure. The contact was informed that there was no oil in the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that the failure was not covered under an unknown recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 103,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743305June 10, 2026
STEERING
Steering wheel is turning completely around and made a noise. I noticed my steering wheel is loose it has been like that for time. But yesterday was the first time it turned completely around were I could not control it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741218June 1, 2026
ENGINE
Why is KIA still legally allowed to sell defective, death traps? Why is it ok for the service department and KIA themselves to tell me….its ok to drive unless the engine light is blinking, smoking in a car know to catch fire…..ok? Why is it ok to let them continue to sell cars under active engine fire campaigns, only to “replace it with the same junk engine” an ok remedy. Quit letting these companies take advantage of people because they created a multi billion dollar defective product, they should bite the cost and be bankrupt, I mean it’s 2025 and they are still making combustible cars, the right thing to do? 2020 Kia forte gt t1.6
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739299May 21, 2026
ENGINE
Bought the car 8 months ago from a Kia dealer. It is now pulling the same engine codes, of the infamous recalled Kia engines. After having diagnostics done at a different Kia then I had bought and had oil changed. They told me the engine and turbo was full of metal shavings and the rods were bad. I pad $10,900 for the car $15,000 to fix, they knowingly sold me a totaled car. I’m sure records reflect they took that car as a trade I knowing the engine was bad (they never checked the oil?). There were 90,000 forte sold in the US, best estimate I could find on the gt line was 4-5 thousand. All GT models do not have the turbo engine. So safe to assume that number is way lower. They know this is a manufacturing defect, and this model engine wasn’t recalled because the numbers aren’t not there. I’m sure these 2,500 or less turbo engines were manufactured in the same facility, same workers and process as the other 2020 forte recalls. The car is smoking and I’m being told “it’s ok to drive unless the engine light is flashing” which I’ll assume is before it catches fire, so I have to worry about that while not being under recall? This is a kid, who could catch on fire, would like to not go there
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738152May 15, 2026
POWER TRAIN
The contact leased a 2014 Kia Forte. The contact stated that while driving, the vehicle began to chug. The vehicle was towed to the local dealer, where it was diagnosed as needing a transmission replacement. The vehicle was repaired. The contact eventually purchased the vehicle. After the purchase, the failure recurred. While driving, the vehicle began to chug without warning. The vehicle was taken to the local dealer, where it was diagnosed that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was called, but there was no response. The failure mileage was approximately 200,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736680May 8, 2026
ENGINE
While driving, the vehicle suddenly began knocking severely, smoking, leaking oil, and then shut off unexpectedly without adequate warning. This created a serious safety hazard and near fire risk. The engine assembly failed catastrophically. Dealership inspection documented: connecting rod punctured engine block bearing material found in oil pan broken piston components in oil pan oil leakage underneath engine complete engine seizure/failure The dealership confirmed and documented the failure and replaced the engine assembly. Repair records and failed components should still be available for inspection through the dealership. My safety and the safety of others were placed at risk because the vehicle suddenly lost power while driving. Oil leaked from the damaged engine and the engine compartment began smoking. The engine could have caught fire or caused an accident due to sudden loss of power. There were no adequate warning indicators before failure. No meaningful oil-pressure or low-oil warning appeared until the vehicle was already smoking and severely damaged. This failure closely mirrors known Kia engine defect investigations and Recall Campaign SC209 / NHTSA Recall 21V259000 involving: connecting rod bearing damage piston oil ring defects excessive oil consumption engine seizure engine stall fire risk Although my VIN is not currently included in the recall population, the documented failure symptoms are substantially similar. I also report that another Kia vehicle in my household, a 2017 Kia Sorento, experienced a separate rod-bearing-related engine seizure despite proper maintenance and documented oil changes. The connecting rod blew a hole through the engine block, causing oil leakage and heavy smoke while driving. The vehicle could have caught fire or exploded, placing my life and others at serious risk due to sudden engine failure without adequate warning. Engine replaced under warranty; concerned for safety after 2 similar Kia failures.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732868April 21, 2026
POWER TRAIN
I am reporting a transmission failure in my 2020 Kia Forte with approximately 54,000 miles. The vehicle experienced a sudden and complete transmission failure on March 19, 2026, on the highway from Cleveland to Cincinnati. after being owned for less than seven months. The vehicle is now at a dealership 2.5 hours away, requiring a full transmission replacement. This appears to be a premature failure and not consistent with normal wear and tear for a vehicle with this mileage. I am aware of a Technical Service Bulletin issued by Kia regarding IVT transmission issues in 2019–2021 Kia Forte models, which may be related to this failure. As well as legal investigations and lawsuits regarding said transmission models. Given the safety implications and potential for loss of power while driving, I am submitting this complaint for review.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726147March 22, 2026
UNKNOWN OR OTHER
While driving a 2020 Kia Forte on the expressway at normal speed, the vehicle was operating normally with no prior warning lights or known issues. Suddenly, the brakes began to feel weak, as if they were failing. Immediately after, a popping sound was heard from the vehicle, followed by smoke coming from the side/underneath area. Within moments, the smoke intensified and the vehicle caught fire. The driver pulled over to the side of the road as quickly as possible. The fire spread rapidly, and within approximately 1–2 minutes the vehicle was fully engulfed in flames. There were no prior warning indicators, messages, or symptoms before the incident. The cause of the fire is currently unknown. The vehicle is available for inspection by insurance or manufacturer if needed. The incident created an immediate safety hazard due to loss of braking performance and rapid fire spread while driving at highway speed.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11725711March 19, 2026
TIRES
Two sets of Kumho Solus TA 31's (195/65 R15 91T) experienced rapid tread wear issues. The problem and safety issue has been confirmed by Fred Beans Kia of Mechanicsburg, PA, but with hassles to do so. I believe this matter actually effects consumers nationwide, which leads to additional high replacement costs as a result of product quality. Consumers are effected by not just the manufacturer, but by those who knowingly sell & promote the products, such as dealerships like Fred Beans, while aware of the defects or who should know about the defects yet fail to take adequate measures to properly rectify the situation or warn consumers. Kumho Tire has been involved in many lawsuits, primarily related to tire defects which caused serious injuries & multi-million jury award and even trademark infringement where tires are allegedly being falsely marketed & sold as new. I believe Kumho is engaging in breach of warranty where the product they sell fails to meet promised quality or performance standards, while engaging in false advertising that misleads the consumer. They engage in lies in their marketing. In addition, there is negligence with Kumho where the manufacturer fails to exercise reasonable care during production. In addition, there is strict liability where the manufacturer should be held accountable for producing an inherently dangerous product. This has also been outlined in lawsuits & ongoing legal challenges faced by Kumho Tire over product quality. Dealership service managers even deny there is a problem, claim it's normal, and say they can't do anything, unless pressed or are caught in a lie. It appears dealerships, sellers of tires & Kumho are all involved in a scheme that creates additional high costs for consumers to properly resolve the problems. Especially since it's a hassle for people to file complaints or time consuming & monetarily challenging for most to fight the battle with dealerships like Fred Beans, or tire manufacturers, like Kumho.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717259February 11, 2026
AIR BAGS
The contact owns a 2020 Kia Forte. The contact stated that while driving 70 MPH on a bend in the highway, a deer jumped over the barrier and landed on the top of the contact's front windshield. The contact stated that she was knocked unconscious due to the impact. The driver’s and passenger’s side air bags did not deploy. The contact was strapped in the driver's seat when she regained consciousness. The contact was unsure whether there was a warning light illuminated. The state police were called to the scene of the accident. Days later, after the accident, the contact went to Urgent Care. However, when the contact explained that she was unconscious, the contact was referred to the hospital. The contact went to the hospital, was informed that there were no bone fractures, and was referred to her personal medical provider. The contact sustained a bruise from the seat belt on her left shoulder; glass shards were embedded in the right forearm. The contact stated that from the impact, the torso slammed into the front windshield. The vehicle was towed to a towing yard, and then the insurance company towed the vehicle to a collision center. The insurance company was pending an investigation. The contact had not released the vehicle. The contact was unaware of all the facts of the accident. The manufacturer was not notified of the failure. The failure mileage was approximately 55,000.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11717285February 11, 2026
AIR BAGS
I was driving a vehicle two cars ahead did and illegal turn the car behind it stopped the truck behind them stopped I stopped behind the truck the car behind me did not stop and slammed me into the back of the truck in my airbags did not deploy
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11699296November 13, 2025
ELECTRICAL SYSTEM, ENGINE, FORWARD COLLISION AVOIDANCE: WARNINGS
The crankshaft position sensor keeps going bad and it make the forward collision trigger and it loses power and the dash stops working and causes the car to shut off
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Forte