Hyundai Santa Fe Complaints (2019)

203 consumer complaints on file.

#11529005June 26, 2023
ELECTRICAL SYSTEM, LANE DEPARTURE: BLIND SPOT DETECTION, FORWARD COLLISION AVOIDANCE: WARNINGS
Adaptive Cruise Control Automatic Emergency Braking Blind Spot Warning Forward Collision Warning Lane Departure Warning Lane Keeping Assistance Parking Collision Warning Rear Cross Traffic Warning Every one of these lights are going off in the car. I’ve taken it twice to the Hyundai dealership. Both times they have not been able to figure out what is wrong with it even with the OPD it’s not showing any issues or fault codes a technician has even had the car for one week went through every single sensor, cable, battery, alternator fuses and didn’t come up with any results. He returned the car back to me completely baffled and unable to fix the issue. Please email at[ XXX] For photos and video which I cannot add here on this website through mobile. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11526591June 12, 2023
TRAILER HITCHES
The contact owns a 2019 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 23V181000 (Trailer Hitches) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11521393May 10, 2023
ENGINE
While driving, the engine stalled out/cut off while the car remained on. I had to push the brakes completely to re-engage the start button. The engine turned off and the check engine light came on, but turned back off once the engine restarted. The car never turned off when the start button was pressed, just the engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11521245May 9, 2023
VEHICLE SPEED CONTROL, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The forward collision avoidance system is malfunctioning and shuts down the traction and stability control systems making the vehicle more vulnerable to collisions. Multiple attempts to repair this system have been unsuccessful
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11519819May 1, 2023
TRAILER HITCHES
The contact owns a 2019 Hyundai Santa Fe. The contact stated while driving at approximately 25 MPH. The contact stated that the vehicle caught on fire while they were driving on the street. The contact stated no warning light was illuminated. The fire department was on the scene and filed a report. The husband had extinguished the fire using a fire extinguisher. The contact had received notification of NHTSA Campaign Number: 23V181000 (Trailer Hitches) however, the part to do the repair was unavailable. The contact had taken the vehicle towed to a local dealer, where it had not been diagnosed. The vehicle had not been repaired. The manufacturer had been informed of the failure. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 30,000. VIN tool confirms parts not yet available.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11517467April 17, 2023
POWER TRAIN, ENGINE AND ENGINE COOLING
The contact owns a 2019 Hyundai Santa Fe. The contact stated that on various occasions while driving at various speeds with the automatic START/STOP function activated, the vehicle started losing motive power while the brake pedal was depressed. The contact stated that the failure recurred while driving from a complete stop. The vehicle was able to restart. No warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed that the valve cover gasket needed to be replaced. The vehicle was not repaired. Additionally, the contact stated that the All-Wheel Drive (AWD) warning light was intermittently illuminated. The manufacturer was not made aware of the failure. The failure mileage was 75,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11513700March 24, 2023
ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:IMMOBILIZER/PROXIMITY:KEY/SENDER
These Hyundai's & Kia's are being stolen left & right across the nation....Hyundai needs to fix our vehicle with an alarm system. We haven't heard anything!!! We owe on the car and if it gets stolen or ruined, we still will have to pay on this vehicle. Also, on top of it all, it will be ruined; and from what we see on TV, they can't even get the parts to fix them. Our SUV is not worth anything now due to those stealing these vehicles because of the Tic Toc videos. Those videos should be banned anyway and taken off so no one else can learn to do this horrible theft. If we can ever get another vehicle, it won't be a Hyundai. This has made us very upset that we haven't heard anything from Hyundai nor there seems to be nothing happening regarding this issue. Why isn't the government pressuring this company? We don't see anything being done.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509557February 28, 2023
POWER TRAIN
The contact owns a 2019 Hyundai Santa Fe. The contact stated while driving from a stop signal, the vehicle experienced a delay while accelerating. The contact stated that the vehicle was jerking without warning. The contact stated that on another occasion while driving 60 MPH, the vehicle inadvertently made a sudden stop without warning. The vehicle was taken to the dealer; however, the mechanic was unable to determine the cause of the failure. The manufacturer was not contacted. The failure mileage was 34,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509126February 25, 2023
ENGINE, UNKNOWN OR OTHER
Caught on fire while driving
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11507792February 17, 2023
VISIBILITY/WIPER, VISIBILITY:SUN/MOON ROOF ASSEMBLY
Panoramic sun roof glass exploded and shattered as I was driving down the highway on a 50 degree F cloudy day. There was no known object that struck the roof nor did we hit a bump in the road or anything. The sound was like that of a shotgun blast. I've seen other posts and settlements for earlier Hyundai vehicle makes and models where warranty was extended to cover a defect causing this. But my 2019 Hyundai Santa Fe damage is not being covered under warranty since it is a couple thousand miles over the 60,000 mile warranty. Hyundai service reported there was no object or damage found to indicate it was caused by something impacting the vehicle. My concern is what will prevent the replacement glass from breaking again if the defect causing it to happen is not fixed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11507519February 15, 2023
STRUCTURE:BODY, VISIBILITY:SUN/MOON ROOF ASSEMBLY
I was at a traffic light (stopped) and all of a sudden my sunroof exploded with no rhyme or reason behind it and glass shattered everywhere on top of me. Nothing was thrown at it and no other vehicles were around me to have any debris thrown up onto it. I got out and inspected the sunroof and found that there was no object imbedded on, in, or near the sunroof that would lead me to believe anything hit it. I contacted the Hyundai dealership about this and they will not cover it under warranty. I believe this is a quality control issue with faulty engineering of the sunroof and upon looking at other Hyundai forums, I found that others have reported the same thing occurring to their vehicles of the same make and model and the pictures of their damage look identical to my damage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11507154February 14, 2023
VISIBILITY/WIPER, VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
• What component or system failed or malfunctioned, and is it available for inspection upon request? When ambient temperature is at or below 32 degrees Fahrenheit, sufficient heat is not produced from the vehicles defroster to keep the windshield from icing. Also, sufficient heat is not produced to keep vehicle occupants warm. A Hyundai dealership confirmed the problem and replaced the thermostat, but the problem still persists. • How was your safety or the safety of others put at risk? Visibility through the windshield cannot be maintained. Also, the cabin temperature is insufficient for safe transport of young children. • Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. • Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? It has been inspected and confirmed by a Hyundai dealership. The problem persists and has been an issue since the vehicle was purchased in 2019. The first winter that the vehicle was operated during (2020) was when the problem first presented. • Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? The water temperature gauge on the dash board “bounces” back and forth while driving the vehicle when the ambient temperature is at or below 32 degrees Fahrenheit. This has been reported to Hyundai corporate –Hyundai case # 19328435.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11506553February 10, 2023
ENGINE
Car just stopped working one day. First oil on spark plugs got them changed then the coil packs now oil is on the air filter. Car drivers really hard and doesn't shift properly. Took dealership and they aren't really helping or even trying to diagnose my car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11506143February 7, 2023
ENGINE
I purchased a pre-owned certified 2019 Hyundai Santa Fe from a Hyundai dealership on 10/13/2020 and the vehicle had 21,770 miles. Then on 10/25/2021 (vehicle mileage was 31,950), I was driving my vehicle on the onramp to i-10 West lanes at Gessner Road. As I was accelerating at 40 mph to enter the freeway, my car engine seized and immediately I lost the ability to accelerate since the engine died. I immediately pulled over and had my car towed to the local Hyundai Dealership, HUB Hyundai Mitsubishi West. The Hyundai Dealership Service Manager, Daniel Castillo (832-739-6353), inspected my vehicle and after an inspection of the engine/underside of the vehicle, Hyundai found no damage or impact on the vehicle or the underside of the vehicle besides a missing drain plug. Their analysis concluded that the full result of the mechanical issue with the engine was a result of the missing drain plug which caused the oil to leak from the engine. Hyundai denied the warranty on the engine citing due to the drain plug issue is a direct result of a third party, Brake Check, that recently changed the oil (See attachment). The Brake Check Store #545 (11564 Westheimer Road, Houston TX 77077) had conducted recent oil changes performed on the vehicle on 12/8/2020 when the vehicle had 24,300 miles and on 5/5/2021 when the vehicle had 27,681 miles. I filed a claim (#3419328-1) with Brake Check for the damages however after 5 months of correspondences I was denied since I could not prove they did anything and the drain plug was missing. I also tried to file a claim with my personal auto insurance carrier, Progressive, however I was denied since the claim did not involve an accident. There was no warning lights that ever appeared on my dash prior to the incident. However, when I did go home that evening, I noticed a fresh large oil stain on my driveway were my car had previously be parked. The oil stain just occurred that day (See attached photo)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11503082January 22, 2023
POWER TRAIN
Was driving my 2019 Hyundai Santa Fe and it completely shut off when I was stopped at a red light. Super scary! I could not get the vehicle to start again and had to call police to help. Had my hazard lights on but still felt very unsafe because there was traffic that had to go around my vehicle. Tow guy was able to get it to start again but said the transmission felt jerky. The vehicle was towed back to my home. Then the next day the vehicle was able to start and seemed fine. I had a friend drive it to the dealership while I followed behind in another vehicle. Half way there, it did the exact same thing. Was stopped at a red light and it turned off. The reason felt like a hard shift to the transmission. The engine would start but it would not shift to drive. It had to be pushed out of traffic. A few people stopped their vehicles to help push. After it was pushed to a safe spot, I had it towed to the nearest Hyundai dealership. The dealership service tech thought it just needed a new starter. He installed the starter and some update software and claimed it was fixed. Picked up the car, drove it home and it seemed fine. The next day I needed to use this car to drive my three children to school (one of my kids has special needs). I felt the transmission jerking half way there and by the time we (thankfully) made it to the school parking lot, it did a hard shift and died. That could have been very scary and unsafe if we were stuck in traffic and it died! I had it towed back to the dealership. This time around the service tech said it needs a new transmission. It’s a 2019 vehicle with 40,000 miles. It shouldn’t need a new transmission. I don’t feel safe driving this vehicle, especially with my three children!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11499805January 2, 2023
STEERING
This is the second time my 2019 Hyundai Santa has suddenly veer right out of the lane. The error message was BAC Active. The dashboard turned red and the vehicle shook for a few seconds. I'm scheduled to take it back to the dealer. I have problems with the engine making noise and have been told the noise is normal.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11498724December 23, 2022
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT
•What component or system failed or malfunctioned, and is it available for inspection upon request? When ambient temperature is at or below 32 degrees Fahrenheit, sufficient heat is not produced from the vehicles defroster to keep the windshield from icing. Also, sufficient heat is not produced to keep vehicle occupants warm. A Hyundai dealership confirmed the problem and replaced the thermostat, but the problem still persists. •How was your safety or the safety of others put at risk? Visibility through the windshield cannot be maintained. Also, the cabin temperature is insufficient for safe transport of young children. •Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. •Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? It has been inspected and confirmed by a Hyundai dealership. The problem persists and has been an issue since the vehicle was purchased in 2019. The first winter that the vehicle was operated during (2020) was when the problem first presented. •Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? The water temperature gauge on the dash board “bounces” back and forth while driving the vehicle when the ambient temperature is at or below 32 degrees Fahrenheit. This has been reported to Hyundai corporate –Hyundai case # [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11490525October 24, 2022
ENGINE, ELECTRICAL SYSTEM, POWER TRAIN
2019 Hyundai Santa fe first owner after each use of the Auto Stop/ Start feature is guaranteed that in 24-48 hrs the car will stall at stop lights and take anywhere from 15-20 min to restart. The power to the electronics continues but the engine can't restart from the stop. It appears as of the feature takes the power from the alternator, starter and battery and drains it until the car can be restarted. Once it starts it drives well until the system is engaged again. I have chosen to not use the system and the car has not stall however once the use of the Auto/ Start Stop system is engaged for a day or two it will stall the vehicle from a stop mostly at stop lights after so much time on standby mode while using the Auto Start / Stop system. Dealer can not recreate the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11488565October 9, 2022
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
For the duration of the vehicle's ownership, it has underperformed and operated unpredictably under hard braking, specifically with relation to the vehicle's ABS system. The conditions have caused meto never drive the car in snow, as this weather condition in particular exacerbates the braking issues and makes the car unsafe. Issues with the braking/ABS include: The ABS activating at slow speeds in all conditions, even on dry roads The ABS activating and preventing the vehicle from being emergency stopped in adverse conditions The ABS activating and exponentially extending the braking distance until it disnegages The ABS, once activated, does not stop unless the brake pedal is lifted from its initial activation position The vehicle doesn't appear to have any mechancial braking issues. Everything seems to be related to the ABS system, wheel-speed sensors and/or vehicle-management systems. The overall braking experience in this vehicle with the ABS on is that it simply will not stop within a safe braking distance window. The only way to stop this vehicle is without ABS. There is no other way to safely stop this vehicle with ABS. I have reached out to my Hyundai dealer and Hyndai corporate directly, both times being dismissed without anyone attempting to recreate the braking issues. I have a life's worth of experience driving in snow and multiple ABS activations in a range of vehicles. This is abnormal based on all of the experiential knowledge I possess, as well as a lifelong interest in cars. While I am not an engineer, I possess enough firsthand and academic vehicle experience to recognize the abnormality of this vehicle braking operation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11487972October 5, 2022
ENGINE
The contact owns a 2019 Hyundai Santa Fe. The contact stated that while at a complete stop with the auto engine Start/Stop feature activated, the vehicle would intermittently shut off upon depression of the accelerator pedal with several warning lights illuminated on the instrument panel. The contact would be forced to turn off the vehicle and open the driver’s side door to reset the vehicle; after multiple attempts, the engine would restart and resume normal operation. The contact had taken the vehicle to two separate dealers, Freehold Hyundai (4065 US-9, Freehold, NJ 07728) and Greg May Hyundai (1501 TX-340 Loop, Waco, TX 76712)] on multiple occasions but neither dealer was able to duplicate the failure. The manufacturer was also notified of the failure and provided a case number. The contact was referred back to the dealer for assistance. The vehicle was not repaired. The failure mileage was approximately 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe