Freightliner · Model Report
Showing safety data for the 2020 model year only.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The longitudinal frame members may be missing reinforcement fasteners, reducing vehicle stability and decreasing the structural integrity of the third-row seats.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2023 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The partition wall may be missing bolts, allowing the wall to detach during a crash.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The connection between the propeller shaft bearing and crossmember may loosen, reducing vehicle control.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The instrument cluster may fail to display any information when the vehicle is started.
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter VS30 and Freightliner Sprinter VS30 vehicles. The heating, ventilation, and air conditioning (HVAC) blower motor circuit may be inadequate, which can allow the wiring harness to overheat.
The Cooling fan behind the radiator also known as the clutch fan fell off the water pump. I realized it before it fell on the highway during rush hour and caused a major accident and engine failure. This is a very common problem and is all over the internet. In most cases it will take out the radiator, fan assembly, belts and hoses as reported by many on the internet when you google “MB sprinter clutch fan falls off”.
No injuries · No fire · No crash
On May 22, 2023 around 19:00 after driving my vehicle for nearly 90 minutes the vehicle no longer responded to the gas pedal being depressed by increasing acceleration. The vehicle would not go over 2,500 RPMs even with the gas pedal fully depressed. No warning were shown on the driver display or in the messaging system. The manual gear shifting did not work to raise or lower the gears while the vehicle was in this state. The vehicle display showed the vehicle in "D" for Drive and I could not change it to any other value such as D1, D2, etc.. The vehicle had almost no power and would not accelerate except for very slowly taking over 1.5 minutes to reach 55 mph. This is a SEVERELY dangerous situation as without warning my vehicle stopped responding to driver input in a reasonable fashion and thus if I was attempting to turn onto a busy road or cross a road my vehicle would not have enough acceleration to do so and could cause an accident resulting in serious death or injury. No warnings or alerts were shown on driver console. Parking assistance was turned off. Lane departure was turned off. I cycled on/off the cruise control to no avail. I evened turned the engine off and on and the problem still persisted. It wasn't until I was able to safely pull off later and power off the vehicle and wait 5 minutes that the problem went away. It is incomprehensible to me why we allow car manufacturers to override user input and commands with faulty and buggy computer software. If I press the gas pedal it should respond!
No injuries · No fire · No crash
Engine destroyed by oil and water accumulation in intercooler that was pulled through the turbo and entered cylinder 6. Bent connecting rod on Cylinder 6, Bent and torn turbo vanes. Sudden loss of power while operating. Mercedes is replacing the entire motor. No Symptoms before the event, check engine light after first restart.
No injuries · No fire · No crash
Driving in center lane of three lane interstate highway in the evening so it was dark. I had cruise control set at 55 mph. Nothing to my right and at least 100 yards of nothing in front of me. A white sedan speeds by in the left lane staying entirely in their left lane. My vehicle slammed on the brakes for some unknown reason almost causing the vehicle behind me to collide with me. A red triangle appeared on dash display for 2 seconds or so (not long enough to know what the computer thought happened ). No explanation given. No messages in drive computer. Absolutely awful. This could have caused a major accident and it was all done by a computer with no explanation. I want a dealer to download the log from my car for 17:52-17:53 on 1/14/23 and issue a complete and detailed report. There’s a severe safety issue and it must be fixed.
No injuries · No fire · No crash
I am experiencing cold start hesitation and unresponsive throttle at high elevation. The vehicle takes up to 20-30 seconds to accelerate, and puts me in a dangerous situation (in a highway intersection, for example). Once the engine temperature is warm, this issue goes away.
No injuries · No fire · No crash