Ford Transit Complaints (2021)

23 consumer complaints on file.

#11741881June 3, 2026
SEAT BELTS
The passenger side seat belt locks up at unusual times. Passenger can’t reach anything because they are locked in their seat. The seatbelt has locked up numerous times however the mechanic can’t repeat the problem in the shop. Yes is has been reported and investigated by TASCA Ford, 1300 Pontiac Ave., Cranston, RI. No indications before the seatbelt locks up.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730872April 13, 2026
VISIBILITY:WINDSHIELD
The contact owns a 2021 Ford Transit. The contact stated that while parked and having an oil change sticker applied to the top of the driver's side windshield, the glass detached half an inch and water had since entered the vehicle through the crack. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 92,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710947January 14, 2026
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
Odometer Fraud. The contact purchased a 2021 Ford Transit. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 33,000; and at the time of registration, it was discovered that the mileage was 320,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703045December 4, 2025
AIR BAGS
The contact owned a 2021 Ford Transit. The contact stated that while driving the 2021 Thor Gemini at 65 MPH in the wind, the wind veered the vehicle off the road. The vehicle rolled over and down an embankment when it came to a stop. No warning lights were illuminated. The side curtain air bag and front passenger-side air bags deployed. However, the driver-side air bags did not deploy. A police report was filed. The contact and his wife were taken to the hospital via ambulance. The contact sustained a concussion, while the contact's wife was severely injured in the right eye due to the air bag and sustained a concussion. The vehicle was towed to Ricky's Towing, a local towing yard. The insurance company was contacted and deemed the vehicle a total loss. The manufacturer was not notified of the failure. The failure mileage was approximately 25,000.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11701195November 24, 2025
TIRES
The contact owns a 2021 Ford Transit 250 equipped with Sentury Lionheart Tires, Tire Line: Lionclaw, Tire Size: 235/65/R16, DOT Number: [XXX] . The tires were replacement tires. The contact stated while driving approximately 40 MPH, there was an abnormally loud sound coming from the front end of the vehicle, and the vehicle started shuddering and vibrating. After stopping to inspect the vehicle, the contact noticed a blowout of the front driver's side tire. Upon inspection, it was discovered that the front passenger’s side tire was cracked by the side wall. The cause of the failure was not yet determined. The manufacturer and local tire dealer were notified of the failures. No further information was available. The failure mileage was 20,000. The VIN was unavailable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11683666August 28, 2025
POWER TRAIN
The contact owns a 2021 Ford Transit. The contact stated that while driving 65 MPH in the middle lane, the vehicle lost motive power with the “WRENCH” warning light illuminated. The contact pulled over, turned off, and was able to restart the vehicle and continued driving. Two days later, the “WRENCH” light illuminated again. The vehicle was taken to a local dealer, where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not yet repaired. Subsequently, the vehicle was taken to a transmission center, and it was determined that the transmission needed to be replaced. The manufacturer was contacted, opened a case, and requested the vehicle maintenance records. The failure mileage was approximately 79,469.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11679769August 11, 2025
WHEELS
Issue is with Hankook tires. Mileage on original OEM tires on my campervan from Ford. 44,600 miles. Good tread, air pressure checked daily on trips. Date code of manufacture of tires: 41st week, 2020. Took ownership of campervan on Dec 6th, 2021. Travel west on I-696 at 70 mph. Driver’s left front tire exploded. I did not hit anything in the road way. In the second lane from right side of freeway. Was able to safely move to the shoulder of the freeway. Tread completely came off the tire. Broke bumper, damages sensors, bent floor pan, and cracked driver side step. Insurance claim filed with Progressive Insurance, and will be inspected on Aug 22nd. Tires will be replaced on Aug 12th at Discount Tire with Toyo Celsius tires. Tire is not available for inspection but multiple photos are available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663753May 29, 2025
ELECTRICAL SYSTEM
Vehicle Make/Model/Year: Ford Transit Passenger Van, 2021 VIN: [XXX] 1. Component/System That Failed: The automatic sliding door on the passenger side of the van has malfunctioned repeatedly. The door does not open properly, often stopping at approximately 6 inches, and frequently fails to close fully. In multiple instances, the door has opened while the vehicle was in motion, which presents a serious safety hazard. The affected component is still available and can be inspected upon request. 2. Safety Risk Description: This malfunction puts occupants’ safety at serious risk. If the door opens while driving, passengers (especially children or individuals with limited mobility) are vulnerable to falling out. Additionally, in an emergency situation, Emergency Medical Services (EMS) or other first responders would not be able to easily access the van through the sliding door, delaying urgent medical treatment or evacuation. This could result in preventable injuries or fatalities. 3. Repair History and Reproduction of the Problem: This issue has already been addressed by a Ford-certified dealership approximately six months ago; however, the problem has recurred without warning. The dealership had previously claimed to have fixed the issue, but it is now presenting the same symptoms, suggesting the repair was either temporary or the root problem was not resolved. The problem can be reproduced and is ongoing. 4. Inspections: The vehicle has been inspected and serviced by an authorized Ford dealership, but the repair has not held. To my knowledge, the vehicle has not yet been inspected by the manufacturer, police, or insurance representatives, but I am willing to make the vehicle available for any required inspection. 5. Warning Signs or Messages: There were no warning lamps, messages, or indicators prior to the recurrence of this malfunction. The door began to malfunction again without any notice, making it even more dangerous for driving. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11660954May 14, 2025
POWER TRAIN
The vehicle constantly has issues shifting gears. This could lead to a potential accident. This is a common problem with this vehicle. Please recall the transmission
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651982April 1, 2025
VISIBILITY/WIPER, ELECTRICAL SYSTEM
NHTSA has already made a recall for some Ford transit models with this issue. See Campaign #25V168000 Summary Ford motor company (ford) is recalling certain 2022-2023 transit vehicles previously repaired incorrectly under recall number 22v-791. The heating, ventilation, and air-conditioning (hvac) system's controls, including those for defog and defrost, may become inoperative. Safety Risk Loss of the ability to control the defrost or defog function decreases the driver's visibility under certain driving conditions, increasing the risk of a crash. We have had this same issue with a 2021 Ford Transit thats not included in the recall. Total loss of all HVAC controls found to be caused by a faulty control module.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633134December 30, 2024
VISIBILITY/WIPER
Sun visors become exceptionally stiff and cannot no be dropped to protect from glaring sun. This creates a driving distraction. The visors reach a point where they are so tightly frozen that an effort to lower them causes the sun visor mount to sheer off. Now I have no working sun visors. Ford says it's not a reported issue, but that's not true at all. See this string from Ford Transit USA Forum. [XXX] There are many other reports of the problem. Ford dealers say it's not a warranty or recall issue. Some people have had the sun visors replaced, but the defect shows up again. There is definitely a design and manufacturing issue that creates a very serious safety issue. Try driving into the sun without a visor! It's blinding and extremely dangerous. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622895October 31, 2024
TIRES:TREAD/BELT
The belts were shifting/separating from the trade of my tire. I noticed an increasing vibration in the steering which lead me to take it to a tire shop to check it out. Fortunately I had read about this issue on a forum and caught the problem before a catastrophic failure, I took the van to a Ford dealership to replace the two front tyres, and the remaining four tyres are on order in due to be replaced in the next few days. Unfortunately, I did not think to keep the tire or take any photographs. But he wasn’t noticeable bulge in the tire. The tire was manufactured in the 44th week of 2000. The van was delivered to Forest River and built out as an RV in 2002.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11617421October 1, 2024
SUSPENSION
The contact's business owns a 2021 Ford Transit. The contact stated while an employee was driving at approximately 30 MPH, the rear passenger’s side tire detached from the axle and landed into a front yard. The vehicle was stopped immediately. The vehicle was taken to an independent mechanic where it was diagnosed that the hub bolts sheared off and needed to be replaced. The vehicle was currently being repaired. The manufacturer was notified of the failure. The failure mileage was 160,215.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597214June 27, 2024
POWER TRAIN
On my 2021 Transit 250, Ford has warrantied 2 front drive axles, the 1st was at 42.4k and second was at 50k. Service writer and tech could not explain why this is occurring. Called Ford customer service line, no tsb or ssm out there, no recall(same as dealer advised). I am aware this is not an isolated incident to me as have found online other instances. If front axle seizes due to lack of fluid due to this issue sudden loss of power or control would be possible. To my understanding and dealers understanding there is no warring light for low diff oil. tried to upload service writeup but would not take
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11589210May 16, 2024
WHEELS
Vehicle delivered with 5-hole spare wheel. Vehicle requires 6-hole wheel. Discovered discrepancy when a tire separated and required a spare to replace it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11554309November 9, 2023
POWER TRAIN, WHEELS, SUSPENSION
Noise in the rear of the vehicle during low speed tight turns (parking lot speed). Vehicle has had axle bearing/hub replaced along with 7585W oil. The problem never went away even after this repair and has become worse. The dealership has had my vehicle for over 2 weeks and cannot find the problem. My concerns are: The dealership cannot diagnose the problem and if the problem is related to the drive line it could lead to a failure at highway speeds which could be catastrophic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11553288November 2, 2023
STRUCTURE, LATCHES/LOCKS/LINKAGES:DOORS:LATCH
The contact owns a 2021 Ford Transit. The contact stated that while attempting to enter the rear of the vehicle, he became aware that the rear door would not latch closed. After a visual inspection, the contact observed a gap between the door and frame of the vehicle, as well as the rear door protruding outward. The door-ajar warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the lock and unlock rod. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 10,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11537364August 9, 2023
UNKNOWN OR OTHER, POWER TRAIN:AXLE ASSEMBLY, WHEELS:HUB
Per Mr. [XXX]: My daughter and members of our church’s high school youth group were on their way to a summer missions project in western Virginia/eastern Tennessee in an Enterprise rental van when the [DRIVERS' SIDE] rear tire started to separate from the vehicle as they were driving south on [XXX] near Staunton! Fortunately, the dad who was driving was able to safely steer the van to the side of the road, where the kids and their suitcases were re-distributed among the other vehicles in the caravan. They called Enterprise, but they had no vehicles to spare, so they told the driver to leave the van by the side of the road and they would dispatch a wrecker to pick it up. Have you seen this happen before with Ford Transit axles? But for the driver’s alertness, this could have been a headline-making event! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11498337December 20, 2022
UNKNOWN OR OTHER
I received a letter fromKIA that said a fire can occur in the area of the tow hitch harness module while driving or while the vehicle is parked with the ignition off.Debris and moisture contamination on the tow hitch harness module printed circuit board ( PCB) which may cause an electrical short circuit , increasing the risk of a fire. A fire increases the risk of injury.I received a letter from KIA America Headquarters that a Recall Number 22V703 applies to my 2017 KIA Sportage which is equipped with a Genuine KIA tow hitch harness accessory. It said KIA has identified my vehicle as one that has the above defect. This letter was dated 11/11/22 but I received it in my mail today 12/20/22. It also said KIA will send me a letter when a remedy is found. In the mean time I should park my vehicle outdoors and away from other vehicles or structures until They have this recall performed. KIA also said in this letter they will send me another letter when a recall remedy is available.I need a vehicle to take me, my wife and family to doctor appointments, the hospital and other medically necessary places. This is not an acceptable nor reasonable request from KIA. It is causing unreasonable and untimely risk to us and we are asking you for help with this issue. The least KIA should provide is another vehicle to drive until they resolve this safety risk. Thank you for your help.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11476539July 29, 2022
WHEELS
Broken Valve Stem - While on vacation the warning light came on telling me I only had 15 pounds of pressure in my right inside rear tire (has dual tires.) I pumped it and took it to a tire store in Twin Falls Idaho. They could not find a leak and sent me on my way. When home in California I took it to La Mesa RV who found the broken valve stem. They said they had seen quite a few on this vehicle and recommended replacing all. They gave me the name of several close by tire shops. The one I picked recommended changing all the stems out because they had seen a number of failures with the 2021 Transits. I did this but now don't have a TPMS since I didn't want to get another one that was likely to fail. Ford should do a recall and put in long stem valve stems that don't brake and also making adding air easier than the OEM ones. I am picking safety over having a TPMS. I wish I could have both. Picture will show removed stems with the one that broke off.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Transit