Ford Ranger Complaints (2019)

271 consumer complaints on file.

#11773967October 27, 2026
SUSPENSION
My back leaf spring is completely broken from the bolt. This is abnormal and not acceptable , causing dangerous driving conditions. Other similar incidents are reported on online forums.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11770644October 12, 2026
SUSPENSION
While operating my 2019 Ford Ranger under completely normal driving conditions without a heavy payload or trailer, the rear driver-side suspension suffered an instantaneous, catastrophic structural failure. The vehicle emitted a sudden, loud metallic clanking sound as the rear main mono-leaf spring completely sheared in half directly in front of the axle mount assembly. The vehicle instantly lost two inches of ride height, bottoming out heavily onto the rubber axle bump stops and leaving only five inches of total clearance. A physical inspection of the broken component shows a uniform, bright, raw crystalline fracture face across the entire thickness of the steel leaf plate, with absolutely zero internal rust or environmental corrosion inside the metal grain. This physical evidence proves the structural component did not fail due to age or progressive wear, but rather suffered an instantaneous fatigue fracture due to a manufacturing metallurgical defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11769608October 7, 2026
ELECTRICAL SYSTEM
Rear Camera - Back Over Prevention - I took it to the dealer, they said there is no recall for my vehicle. It is currently available for inspection but I will need to get it fixed. Safety risk is elevated due to inability to fully see surroundings/people/children/pets, etc. behind the vehicle. The dealer saw that it is not working but I did not pay them to diagnose or inspect so they did not. There were no warning lamps, messages or other symptoms prior to the failure. The first appearance was today, 10/7/2026 while at the dealer for an oil change.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11767201September 26, 2026
VISIBILITY/WIPER
Defective heat/ac blend box assembly. No heat or, more importantly, windshield defroster. Appears to be a common issue on this vehicle model.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766034September 22, 2026
SUSPENSION
Driver side rear leaf spring cracked at front mount. This happened with low mileage 20k and no towing or off-road driving. In town driving only.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11762203September 4, 2026
POWER TRAIN
My 2019 Ford Ranger with 10 speed transmission has been harsh shifting and will not always find the right gears. It will sometimes Surge forward or at other time not respond to acceleration. It has 100,000 miles. Never used it for towing or hawling heavy items.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761924September 3, 2026
POWER TRAIN
My 2019 Ford Ranger, VIN 1FTER4FH2KLA63893, experienced a major transmission failure at approximately 35,000 miles. I took the vehicle to a Ford dealership for diagnosis and was advised that the transmission required major repair/replacement, with an estimated cost approaching $9,000. I also obtained an independent transmission repair estimate of approximately $6,700–$7,000. Given the extremely low mileage and the repair cost relative to the vehicle’s value, repairing the truck no longer made financial sense. The transmission failure substantially reduced its trade value and is forcing me to replace a vehicle that I otherwise intended to keep. I estimate the resulting loss of equity at approximately $7,000, in addition to the financial impact of prematurely taking on another vehicle and associated financing. After the failure, I learned of ongoing litigation involving Ford’s 10R80 10-speed transmission, including allegations involving 2019 and 2020 Ford Rangers. I am reporting my experience so this failure is formally documented and can be considered in connection with any investigation, litigation, warranty extension, recall, or other potential remedy involving the 10R80 transmission.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756686August 13, 2026
ELECTRICAL SYSTEM, ENGINE, UNKNOWN OR OTHER
The cooling fan clutch control wire is supported by a "wire support hose" between the engine block and the fan clutch. the cooling fan clutch control freely rotates on a raceway on the drive shaft. The purpose of the support hose is to prevent the fan clutch control from freely rotating, but allows the control a limited range of movement as the drive shaft changes speed with engine RPM. The idea is that this hose prevents undue stress on the control wire. Hose is normally a consumable part that may need replaced with age, heat, etc. The hose is not sold as a replacement part and can only be obtained by purchasing a new fan clutch. When the hose fails, the control wraps around the drive shaft causing damage to the fan clutch control and wiring requiring replacement. The circuit on which the fan clutch control sits is integrated with no less than 6 other critical vehicle systems including oil pressure. When the incident occurs, all these systems generate errors that put the vehicle into limp mode until repair can be made. The fan clutch control wiring support hose should be a bracket with a different mechanical linkage solution to support wire while allowing the necessary limited movement. This low-tech hose solution causes outsized damage when it fails, effectively disabling the vehicle which creates a safety concern and undue hardship from an unnecessarily cascading damage effect. Ford acknowledges this defect by redesigning this feature for 6G Rangers but will not proactively correct through manufacturer recall 5G Rangers. If Ford will not correct, I believe the NHTSA should get involved and force Ford's hand at addressing this repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755076August 5, 2026
POWER TRAIN
Auto transmission is failing to shift when taking off from a stop or hesitating to shift to next year causing traffic behind me to get close to rear bumper.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752783July 25, 2026
POWER TRAIN
1st I reported to Ford that when my truck was in park and off, it started rolling down a hill. I jumped in and stopped it. Ford said they see nothing and everything looks fine. Since then I use the emergency break every time. 2nd, you feel the transmission shifting hard. Jerks truck. Also, if you drive around 25 mph, the truck starts jerking like it cant make up its mind what gear to be in.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752638July 24, 2026
SUSPENSION
Weak steel from connection point of rear leaf springs failed, leaving the springs unconnected at front eye of connection point
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747696July 1, 2026
ELECTRICAL SYSTEM, ENGINE
I was driving the vehicle, when I started to fell a " Shuddering " sensation on acceleration. I let off the gas pedal and the Shuddering went away. A few miles down the road the check engine light came on and was flashing. I immediately pulled and shut the vehicle off. After sitting for 10 minutes I restarted the vehicle and the check engine light was no longer on, but the " Shuddering " sensation was still present. I took it to Dupratt Ford in Auburn,Ca. and they diagnosed it as a Cylinder 1 mis-fire. Upon further inspection they found water in the Cylinder 1 spark plug well. After doing some research I found out the Ford issued TSB 23-2011for this exact issue, but did not order a recall to fix the faulty windshield cowl which is the problem. I found thousands of complaints and numerous Ranger owners who have had the exact same issue and had to pay out of pocket to get the issue and damaged fixed. Meanwhile Ford knew about the issue and did absolutely nothing, did not even alert the owners of the issue. I was lucky and did not have to replace the cylinder head, but others have not been so lucky. I had to pay over $1800 to have the mis-fire issue fixed and had to do my own preventative measures to seal the windshield cowl. I contacted Ford and they were only willing to reimburse me $725 dollars of my repair bill which was 100% their fault.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747616July 1, 2026
POWER TRAIN
The Ford 10R60 and 10R80 transmission has become a hazard on the road. Please see TSB 23-2250. My Ranger only has 43,000 miles on it and is dangerous to drive because of the stuttering and lunging of the transmission. Ford is perfectly aware of this situation but won't fix vehicles that are out of the 5 year warranty at no cost to the owner. No transmission should be faulty after only 43,000 miles. I am requesting that you please investigate this situation as I believe it should be a recall. - Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746830June 26, 2026
POWER TRAIN
The transmission has issues not shifting gears and having loss of power when pulling out into intersections that are getting worse with time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745640June 22, 2026
SUSPENSION
I am submitting this complaint regarding my 2019 Ford Ranger because I discovered what I believe to be a serious safety defect involving the rear leaf spring mounting system. My vehicle has approximately 55,000 miles and has been used primarily as a commuter vehicle for driving to and from work in the city. The truck is originally from Virginia and has very minimal rust exposure. While replacing my rear brake pads, I noticed that the area where the rear leaf spring connects to the body/frame of the truck had broken away and was no longer properly attached. This was completely unexpected. A critical suspension component such as the leaf spring mounting point should not fail on a relatively low-mileage vehicle with only 55,000 miles, especially one that has not been subjected to severe corrosion or extreme use. Had I not been performing brake maintenance myself, I likely would not have discovered this defect. I fear that many other Ford Ranger owners may be driving their vehicles unaware that they could be experiencing the same dangerous condition. A failure involving the leaf spring mounting system has the potential to affect vehicle stability, handling, braking, and overall control. This creates a significant safety risk not only for the driver and passengers of the affected vehicle, but also for everyone sharing the roadway. I respectfully urge your agency to investigate this issue and determine whether a broader defect exists involving the rear leaf spring mounting components on 2019 Ford Rangers. If warranted, I ask that Ford be required to issue a recall to inspect and repair affected vehicles before a catastrophic failure results in serious injury or loss of life. Thank you for your attention to this matter and for your efforts to protect the safety of the driving public.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743330June 10, 2026
POWER TRAIN
Hash Shifting and at times kicks into gear hard at a stop light nearly hitting vehicle in front of me
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738570May 18, 2026
TIRES:TREAD/BELT
The contact owns a 2019 Ford Ranger equipped with Dunlop Tires. Tire Line: AT2O, Tire Size : 265/65R17 110HI, DOT number DAAH D31R. The contact stated that while driving 65 MPH, the passenger-side rear tire blew out. The thread separated and was on the roadway. The contact was able to continue to drive. The contact called a tire center, but they failed to respond. The local dealer was not contacted. The manufacturer was not contacted. The tire mileage was unknown. The failure mileage was approximately 97,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736221May 7, 2026
POWER TRAIN
My 2019 Ford Ranger is equipped with the 10R80 10-speed automatic transmission that experiences hard/erratic shifting (as if it can't decide what gear it wants to be in), jerking/lunging especially in 1-2 gear when making a brief stop-and-go (stop sign or a crosswalk). The first couple time it happened, it felt like I got rearended or hit a curb.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11735236May 2, 2026
SERVICE BRAKES, ENGINE
The brakes failed within hours of owning the Certified, WARRANTIED VEHICLE. ALMOST had an accident. Within <5 weeks of owning this warrantied certified vehicle, was stranded on Rine Ridge Indian Reservation and on the highway. Engine jerk so bad feels like I a derby car. Then just stalls. The dont comply with their own 172 point certified inspection. They claim two keys for specified vehicle. They gave me two 1 starts the vehicle the other errors no key in ignition when you insert into ignition. NOW I have to pay bills to get a warrantied certified vehicle repaired plus loaner car because Ford McKie k owing sold an Unsafe vehicle under deceptive pretense. Multiple engine and brake failures which was supposedly certified inspected.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734116April 27, 2026
POWER TRAIN
Mileage is at 86980. I have been having issues for a good 10k miles that are slowly getting worse. Transmission is slamming into reverse from park. Shifting is slow from 1st to 2nd gear. Has begun revving engine but not engaging. I have had the transmission fluid changed 3x and flushed and changed the last time. No leakage or overheating. I do not drive her hard, off road or tow. She always gets warmed up before driving. My mechanic believes it is the PCM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Ranger