Ford Maverick Complaints (2022)

618 consumer complaints on file.

#11723780March 12, 2026
STRUCTURE:BODY
Driver side door limiter welds broke loose. Ford said they had to replace the entire door and it was not covered by warranty. The dealer said that this happened to a bunch of Ford Escapes, but they did not have a recall for the Maverick yet.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723464March 11, 2026
STEERING
What component or system failed or malfunctioned, and is it available for inspection upon request? turning the steering wheel makes clicking sounds from under the dash like a card in a bike tire spokes. How was your safety or the safety of others put at risk? a problem from a steering wheel/column making strange noises in a new/newer vehicle, how is anyone to know if it will lock up or not work properly while driving? this could cause life threatening loss if malfunctioning. Has the problem been reproduced or confirmed by a dealer or independent service center? yes, taking to local ford dealer, they have repeated and confirmed the issue as an issue with the rack and pinion motor resulting in $1100 repair bill. truck has 31k miles, but just couple months over the 3 yr 3k mile factory warranty. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? randall ford dealer in fort smith, arkansas Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? no, none
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723267March 10, 2026
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
Just picked up vehicle after having a new battery installed. Was getting pop up on dashboard every few seconds that electrical saving mode was active. Then all of a sudden the truck shut off while driving about 45 mph on a busy road. Dash said switch to neutral to start vehicle which i tried but nothing happened. Truck coasted to a stop and would not start or even shift into neutral to push it off of the road. The dashboard was flashing pretty much every warning possible including stop safety, shift system failure, parking brake , battery saver active etc. The truck continued to not start or shift. Tow truck was called and it was towed home.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11723301March 10, 2026
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
My 2022 ford Maverick is constantly sometimes several times a day and sometimes several times a week , but since 6 weeks after purchase I have been getting powertrain fault , engine fault and hybrid battery fault alerts from my ford pass my check engine light comes on my s service wrench light comes on also and my vehicle has reduced power. As well as my battery is constantly needing to be jumped. The dealership says my Battery is fine although I’ve already replaced it twice at my exspence. I’ve had to pay for diagnostics and pcm updates supposedly to fix these problems but no resolve. My vehicle goes into reduced power while driving 75 mph up the interstate and will not excellerate causeing the vehicle to coast to a stop. After sitting a while it can be started and driven. Today I received all three faults at 10:20 am so I went to my ford.com and done a health check and it says my vehicle is healthy with no engine or power train faults. But my ford pass alerts , my dashboard warning lights , and the performance of my vehicle says otherwise. I have been put in many situations on high speed roads and my vehicle will not accelerate. Often times it is necessary to jump my battery for I can move my vehicle. These issues are a constant safety hazard to all the drivers on the road when a vehicle suddenly loses power at high speeds. After 4 years of fighting with ford for a resolve I need help. I have seen numerous recalls issued addressing these very issues but they are not issued for my vin although the data on the recall states the recall pertains to vehicles made at the hermacillo Mexico plant . Which mine was on Dec 2021. I feel like my vin somehow is being overlooked and I’m not recieving the recall for the repairs. I also believe that due to the electrical issue my truck can not retain the obd codes. I have taken my vehicle to several dealerships all telling me different resolve which I pay for and no resolve. Please help
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11721686March 3, 2026
ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
The contact owns a 2022 Ford Maverick. The contact stated that while driving at an undisclosed speed, the trailer brakes became inoperable. There was no warning light illuminated. The contact was informed by another driver that the trailer brake lights were not illuminated while the vehicle was stopped. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 44,700. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720345February 25, 2026
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
When driving at normal speed, my truck completely shut down with no warning. The instrument panel went dark and the engine shut off. I do not believe I was able to steer, though I think the brakes allowed me to slow the vehicle to a stop. I was near an intersection, so I was lucky to not have been hit from the rear or run in to traffic in front of me. The vehicle was unresponsive and would not turn back on. I was stuck blocking 1 lane of traffic for an hour because the vehicle could not be steered or taken out of gear to push it to the side of the road. I inspected the battery connection and nothing seemed out of place or degraded while trying to get the car out of the road. Highway Patrol also looked, but only was able to offer a tow truck as a solution. My truck has been at the dealer service for almost 2 days awaiting inspection at this point so I have no additional information on what caused this dangerous situation. There had been no indication prior, the truck had started and run normally and all scheduled services had been carried out by the dealer up to this point.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718278February 16, 2026
SERVICE BRAKES, EXTERIOR LIGHTING, ELECTRICAL SYSTEM
I have a 2022 Ford Maverick XL Hybrid and the system that failed is the rear lighting system, specifically the tail lamps, brake lamps, and rear turn signals. This appears to be related to the Body Control Module (BCM) software, which was the subject of Ford Recall 24S27 affecting many 2022–2024 Ford Mavericks. The failure began on my vehicle with the left rear tail lamp assembly (running light, brake light, and turn signal), and within approximately two minutes the right rear tail lamp assembly also stopped functioning. Since that time, the entire rear lighting system has been inoperative while driving. This issue creates an extremely serious safety hazard. While driving, my vehicle has no functioning rear running lights, brake lights, or turn signals. This means other drivers cannot see when I am braking, signaling a turn, or even driving at night. This significantly increases the risk of rear-end collisions or other traffic accidents, especially in low visibility conditions. I was unaware of the issue until visually noticing it when unlocking the vehicle, and there were no dashboard alerts to warn me prior to that either. Loveland Ford in Loveland, Colorado inspected the vehicle and confirmed that the rear lighting system is not functioning. However, instead of addressing the known Recall 24S27 Body Control Module software issue, they stated that LED bulbs were installed where halogen bulbs should be and issued an $816 estimate to replace the bulbs. I have never performed any aftermarket modifications, and the vehicle has only been serviced by Ford dealerships. The vehicle has been inspected by Loveland Ford, an authorized Ford dealership. Ford customer service confirmed that Recall 24S27 exists for this exact issue in many 2022–2024 Ford Mavericks but stated there is no record of my VIN receiving the recall remedy, which could mean the recall was never accomplished. No warning lamps, dashboard messages, or other alerts appeared prior to the failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11717927February 13, 2026
POWER TRAIN
Experienced excessive wobbling/shaking during acceleration. Ford replaced both axles at 38K miles. 30K miles later I am experiencing same issue. Replacing axles this frequent is abnormal and is an indicator that parts being used are not meeting the requirements needed for this vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716908February 10, 2026
EXTERIOR LIGHTING
The rear brake lights intermittently do not work, but at the same time the middle third light brake light works fine. also the turn signals work fine. People will rear end me if they don’t see my brake lights. I am a retired, master mechanic, and my son is also a mechanic. We have both looked into this problem and it possibly could be either a module or the turn signal switch. I had no warning of this problem coming on other than someone telling me my rear brake lights stopped working when they were following me. This is a very dangerous situation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714442January 30, 2026
UNKNOWN OR OTHER
This is a complaint of Sheridan Ford in Wilmington DE specifically refusing to complete the recall without my paying out of pocket. Manufacturer Recall Number24S59 NHTSA Recall Number24V684 was left incomplete because they demanded I pay for a "diagnostic" fee on a known safety issue - this dealership is taking advantage of a saftey recall that is required to force customers to pay
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11714415January 30, 2026
ELECTRICAL SYSTEM
In cold weather -6F The cover over the positive terminal used to jump start the vehicle is impossible to remove. This causes a situation where the vehicle can not be jump started or render assistance to another that needs jump started. The issue stems from the fact that the plastic cover over the positive terminal is unable to bend when it is cold and can not be "unclipped".
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712577January 21, 2026
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
I received the 2022 Hybrid Ford Maverck XLT on March 2023, and had first 12V battery replacement on August 2023 as it was dysfunctional leading to car stalling. On 01/11/2026, the truck suddenly got stalled during drive due to the dysfunction (8.0V) again of the 12V battery, which triggered several error codes. The 12V battery was replaced again on 01/12/2026. I drove the truck home and found later that system alert with "Electrical Power Saver Active". The truck stalled again on 01/13/2026 at traffic light near school zone. The police had the truck towed to Tire Express per SOP. The truck was then diagnosed at local Ford dealer as: "multiple accessory / entertainment modules have software level that may be contributing to 12V battery drain / degredation". Obviously, this is the truck defect can may pose catastrophic risk to driver and surrounding drivers. I searched Google and found more 2022 Maverick with such serious issue! My total cost of repair and towing from this defect is $1145.11. Thank God that my family was safe during the sudden stalling while driving. I know there is no such recall but Ford should be responsible for the recall to avoid future risks and paying off my cost. Please consider this as a recall! Thank you!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712273January 20, 2026
POWER TRAIN, SUSPENSION, LANE DEPARTURE: ASSIST
Clunking in the front end around 20,000 miles. Brought to multiple dealers and they all said no problem found yet clearly hear clunking both sides front going over bumps or steering back and forth quickly. Finally I just replaced them and noise gone. Second thing is headliner is completely ruined from moisture intrusion and can visibly be seen but dealer states no leaks present yet my headliner is water stained looking like those wet tiles in a school. Third is my transmission. It is very erratic when shifting and sometimes flares when downshifting. Dealers state no problems exist. Operates as designed, yet I have driven other mavericks and they do not have the same issues as myself. I have changed the fluid with genuine ford ulv transmission fluid from dealer at about 50k miles. I change my oil every 3k, changed my differentials and transfer case all with genuine fluid. I am an AAS Automotive Technology graduate and currently ASE certified and have worked in multiple dealerships replacing transmissions, engines, almost anything since I have started. I need to gather my records as I have kept receipts and records as I do all my own maintenance and repairs. I have replaced the downstream oxygen sensor twice. Yesterday morning I got a frozen throttle body and limp mode and if I did not have my scan tool I would have been stranded as it would not let me drive due to the stuck closed codes. All codes since I owned the vehicle with 3 miles on it are stored in my ford app and on my scan tool with vin. I have tried calling ford, email, different dealerships and they deny me or want me to pay out of pocket when I have warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710852January 14, 2026
STRUCTURE:BODY
When it rains water gets into the passenger-side footwell and beneath the carpeting during rain events.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710775January 13, 2026
POWER TRAIN, VEHICLE SPEED CONTROL
As I was traveling on freeway at 65 mph cruise control disengaged. After I was notified to service engine soon and check engine light came on. Throttle was unresponsive forcing me to cross 4 lanes of the 5 freeway. Pulled over and shut off vehicle checked fluids. Nothing out of spec.restarted vehicle and would not get out of limp mode.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709634January 8, 2026
ELECTRICAL SYSTEM
After a little over 3 years, my truck has had issues maintaining its 12v battery putting me at risk of being stranded. The battery was replaced once under warranty. Now that I am out of warranty, the replacement battery is now going bad.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709160January 6, 2026
UNKNOWN OR OTHER
The vehicle experiences water intrusion into the passenger-side footwell and under-carpet area during rain events. The suspected failure involves the body sealing system, potentially including the windshield cowl area, firewall seams, HVAC intake/cowl drainage, or related body panel seals. The vehicle and all affected components are fully intact and available for inspection upon request. The carpet has been lifted to document standing water and mold growth but has not been replaced or permanently altered. This defect presents multiple safety risks, including: Visible Black Mold contamination inside the passenger compartment, airbag, and throughout HVAC system, creating a health hazard for occupants. Potential electrical system damage due to repeated water exposure. Possible impact on airbag and restraint system wiring, which is located beneath the passenger-side dash and carpet. Increased risk of window fogging and reduced visibility during wet conditions. The vehicle is currently unsafe to occupy during or after rain due to these conditions. The problem is consistently reproducible whenever the vehicle is exposed to rain. The issue has occurred repeatedly over the course of ownership. A Ford dealership has acknowledged the presence of water intrusion but has not performed a full diagnostic inspection, instead requiring a paid inspection fee, claiming they are "fully booked until further notice" and stating they are “unaware” of similar issues, despite widespread owner reports.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706879December 23, 2025
FUEL/PROPULSION SYSTEM
Fuel tank failure at 18,000 miles and less than 3 years of ownership. I noticed that the vehicle had a strong gasoline smell when I was around it. When looking under the truck, I could see that there was a fuel leak coming from the fill pipe inlet into the fuel tank itself. Took the vehicle under warranty to the ford dealer, and was told that the hose clamp was loose connecting the fill pipe into the fuel tank itself. Was sent on my way with the vehicle, and noticed a smell of gasoline and fuel not even two months later. Took it back to the dealer and was told that they were unable to replicate it. Once the weather got cold again, took the vehicle back after noticing a much larger leak and smelling fuel, and am now being told by ford that the fuel tank does in fact need to be replaced as the tank is leaking from the fill pipe inlet. I am no longer under warranty and was quoted $1100 for this repair. Not only do I find this to be a safety concern as leaking gasoline is extremely dangerous and flammable (plus there are vapors in the air in my garage) but felt that my dealership did not do their due diligence to resolve this issue properly, and now I am on the hook for an $1100 repair that should’ve been taken care of when the vehicle was under warranty. No warning lamps were lit alerting me to this problem, I noticed it by smelling gasoline in my garage near the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705727December 17, 2025
SERVICE BRAKES, ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL
My 2022 hybrid Maverick suddenly lost power as I was driving at 45 MPH. There was no warning lights; the entire dashboard went black. I lost all power including lights, speedometer, and power steering. Additionally, and more concerning, I lost all brake functionality so I could not stop the vehicle, even pressing the brake very hard. The parking brake switch also did not work due to the power loss. The brake pedal would not budge until suddenly after the vehicle completely lost all momentum. In the process blew through a stop sign and I could've easily been killed, or worse, killed other people as I had no control of the vehicle as it coasted. Thankfully nobody and nothing else was harmed as I was the only one on the road, it was just traumatic. The vehicle was towed to the dealer and preliminarily inspected. They decided they want to address a technical safety bulletin for a "no start condition", though the conditions did not match this situation exactly. But they also stated the hybrid/powertrain warranties did not apply, so I rejected the repair due to high cost. It is uncertain if the repair they want to do would fix the issue. It is currently available for inspection upon request, though Ford may try to buy it back soon. It has not been inspected by police or insurance. The only light I can think of was a month before I saw a brief "Charging System Service Soon" warning, but it was only on momentarily (did not persist). I am unsure if this is related.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704005December 9, 2025
ELECTRICAL SYSTEM
Battery in the passenger compartment is charging at 15.2 volts constantly. Ford dealer claims this is not a problem, but the battery life has been shortened, and the battery model number states it should be charged between 13.8 and 14.2 volts. The battery is located under the rear seat, inside the passenger compartment. From my limited understanding of battery technology, over-charging can produce hydrogen into the passenger compartment. My vehicle is now on the third battery, and has only 73,511 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Maverick