Ford Maverick Complaints (2022)

618 consumer complaints on file.

#11511107March 9, 2023
ELECTRICAL SYSTEM, ELECTRICAL SYSTEM:HORN
when starting out driving or cornering at low speeds the horn would randomly honk steadsily and eventually time out.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11510255March 5, 2023
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
Under rapid acceleration requiring over 50% of the engine's power, the computer system detects a "fault" and shuts down the engine. This has occurred five times in the last 4 months while attempting to merge onto freeways, interstates, and local roads. In every instance, the engine shut-down cause oncoming vehicles to rapidly slow down in order to not hit my vehicle and I had to pull off to the side of the road to let the computer system "reset" in order to continue my travels. The problem was brought to the attention of the local Ford dealer twice (will be going back based on recent occurrence of March 5, 2023 ). There were no warning lamps, messages, or other systems prior to the problem occurring. This problem has occurred on December 8, 2022; December 12, 2022; December 23, 2022; March 2, 2023; and March 5, 2023.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509927March 2, 2023
LANE DEPARTURE: ASSIST
On Monday 2/27/2023 I was driving northbound on the Taconic Parkway in New York going with my cruise control and co-pilot360 adaptive lane control engaged. I think I dozed off for about 20 seconds and during this time my co-pilot disarmed and my Maverick drove off the highway. Fortunately I regained control before I hit a sign or trees. I damaged a front rim, but it was a very close call. I am a very good driver normally, but this feature should be investigated. I understand that it is not "autopilot". I have the dash-camera video here: https://youtu.be/z6hpNyx3snc a. Co-pilot shuts off at .020 b. Truck leaves road at .036
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509754March 1, 2023
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
The truck battery connection is faulty causing it to loose complete power to the vehicle after driving and turning off it won’t restart. No power means no hazards, complete blackout on the vehicle. This is reported on YouTube by so many other’s experiencing the same issue. They replaced my battery which was not the issue, the next day I experienced the same dead vehicle issue. Ford also did not tow it, they wanted to charge 626.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509459February 28, 2023
ELECTRICAL SYSTEM
Received notification vehicle is in deep sleep mode though vehicle was driven yesterday.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11509536February 28, 2023
SERVICE BRAKES
While in low speeds there are times the brake pedal stiffens then is unresponsive, then when applying more pressure all of a sudden the brakes would engage causing the car to come to an abrupt stop. Nearly hit the car in front of me during these instances.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11508896February 24, 2023
ENGINE
Problem 1: As a hybrid engine, the engine shudders, shaking the whole vehicle, as i am travelling in a low speed, around 5 mph. I believe this is the cause of engine rpm switching to electric motors. This had occurred multiple times in 3 months of owning the vehicld. Problem 2: brake grab. There has been multiple instances that the brake engages in low speed. This happens when i am not stepping on a gas pedal, like about to park. The brake grab puts the vehicle in a jerk stop. This occurred multiple times in 3 months of owning the vehicle
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11508195February 20, 2023
SERVICE BRAKES
At low speeds <5 mph the brakes will lock/bite and other times they will perform normally. Pedal response is basically unpredictable which could cause an accident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11508240February 20, 2023
ENGINE
On several occasions, most recently on February 13, 2023, my vehicle encountered a stop safely warning light and all power was lost. I could no longer accelerate and was forced to pull over onto the side of the highway. This has happened on four occasions when I was attempting to pass another vehicle. The most recent occurrence happened while passing an eighteen wheel truck on a two lane highway. The truck had to brake heavily behind me because I did not have any power to maintain speed as I moved in front of him. Once stopped, I have been able to shut off the key and the system resets and I am able to resume driving. A check engine light will come on but will disappear in 24 to 48 hours.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11507899February 17, 2023
AIR BAGS
The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 22V594000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11507357February 15, 2023
AIR BAGS
The contact owns a 2022 Ford Maverick. The contact received notification of NHTSA Campaign Number: 22V594000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that he was informed by the dealer the air bags could not be replaced until after the air bags had been deployed. The contact was then informed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11507163February 14, 2023
AIR BAGS
I was hit by another car in between the passenger side front door and the passenger side back door. I was hit with enough force to push me off the road. There was no side airbag deployment.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11506130February 7, 2023
SERVICE BRAKES, ENGINE, SUSPENSION
For now nothing happens but im frustrating about recalls and my dealership is finding the ●braking▪︎ problems, the maker me unsafe also by 02/06/23 check ●ENGINE LIGHT▪︎comes on. And they gave me appointment in 42 hours. And also my maverick has a lot oil comes out front oil filter, that's my dealer unprofessional services.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505935February 6, 2023
SERVICE BRAKES
(there is a brake system malfunction. When braking sometimes the brakes would skip and I could feel the brakes not grabbing the rotors the way they should. the problem has not been reproduced or confirmed by a dealer because the dealership could not figure out what was causing the problem with the brakes. the dealership inspected the brakes. there was no warning lamps or messages of the brake problem.) I first started to hear a intermittent rubbing noise when braking and driving slow a couple months after I purchased the vehicle. I took it the vehicle into the dealership and they could not figure out what was wrong. I was told perhaps i was to aggressive on the brakes. the problem continued so i went to another dealership and they looked at the brakes and could not figure out what was causing the noise. the rotors looked glossy (glazed) So I decided to replace the rotors and brakes at my cost because I was told the truck was out of warranty. one week after the repairs were made, I started to hear the rubbing noise again. I was furious! I couldnt believe this was happening on a brand new vehicle, especially on a ford. So I continued to drive until the rotors got so bad that the steering wheel was shaking when I braked.the rotors were warped. So I decided to take matters into my own hands and replace the brake pads and rotors using the ford manual for the 2022 maverick. This time I decided to only drive eco mode on the highway and normal mode in the city. I also turn off the active braking every time I got in the truck. I was also very careful not to be aggressive on the brakes and not to ride them when slowing down. I kept a close watch on the rotors. after two weeks of driving the rubbing noise started again and the rotors are glazed again. I do not know if its a mechanical issue with the brake calipers/master cylinder or a computer/software issue. I cannot afford to be replacing brakes and rotors every two weeks. I am greatly disappointed in ford motor company .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11505190February 2, 2023
SERVICE BRAKES
Brakes at low speed are malfunctioning and grabbing late with loud thumping noise. Problem has been happening since I took possession of vehicle
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504359January 30, 2023
SERVICE BRAKES, ELECTRICAL SYSTEM, ENGINE
Brakes are too sticky and I'm not able to control the braking even if I am using the eco mode which is supposedly slow enough already. Normally happens when I just started moving the car from park and when I am going to stop and go local traffic. When I took the car to the dealer they said they could not update the software because there is no code for braking problem for this car. This car has been showing check engine light since December 24, 2022 and when the check engine light is on I could not access my OBD port. The chicken didn't light has been going off and on for three times now, took it to the dealer and the dealer was able to find a fault code but could not pinpoint the problem yet. When the check engine light is ON, the car does not seem to have enough power to move.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504494January 30, 2023
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
This is follow-up to NHTSA Complaint 11502916 reported 01/21/23: Maverick Hybrid was at dealer for 5 days. First - Brake issue many of us are experiencing was reportedly resolved (TSB 22-2493) by reprogramming PCM and SOBDM-C; brakes seem better at slow speeds now! Second- As for the two incidents when vehicle motor stopped while driving at speeds 50mph+ and accelerating, dealer put a "Hotline Contact" into Ford motor to seek guidance however all test came up with nothing in terms of determining the cause or resolution. Since the vehicle still runs, I picked up my truck and guess I will continue to drive it until 'Russian Roulette' makes truck break down again. Dealer did mention that the SOBDM is an electrical code for brakes and stalling so maybe the brake job also fixed the engine malfunction but they can't be certain. Regardless, experiencing total engine failure at highway speeds is very frightening! Until I have FORD documentation that the problem is with 100% certainty diagnosed and resolved, I will never travel with a passenger or a pet in my truck again for fear of engine failure at highway speeds could result in a horrible tragedy! I have been very lucky not being rear-ended or even worse with the two engine malfunctions; I pray my luck continues as FORD has no answers for me!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504500January 30, 2023
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
Twice, within a one week period, my hybrid vehicle failed to start. In fact, the key fob failed to unlock vehicle. I changed the battery in one key fob and still wouldn't unlock the vehicle. I had to unlock vehicle manually with the key and vehicle still wouldn't start. Vehicle dash board and all interior lights not working. Both times service was called and vehicle started right up with a jump from a battery pack. No check engine light was displayed either time. I have checked the Ford Maverick owners website and a bad wiring harness appears to be a problem that many hybrid owners have reported that Ford replaced to resolve this problem. I am concerned that this defective wiring harness could be a fire hazard. Also now the vehicle is unreliable and could leave me stranded on the highway or die in heavy traffic or when trying to merge or exit the interstate near my home.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11504517January 30, 2023
SERVICE BRAKES
At low speeds, the brakes are unpredictable. Sometimes they grab hard, other times not. Sometimes there is a loud clunk associated with this low speed braking. I don’t know the cause, but it leaves the driver uncertain how much pressure to apply in braking situations. Snowy conditions are especially hard to navigate. Ford has issued a TSB for the problem which I am in line to have completed. But early feedback indicates that the offered fix only partially resolves the problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11503901January 26, 2023
LATCHES/LOCKS/LINKAGES:HOOD:LATCH
I was working on my vehicle, when I close the hood. Upon closing, I heard something, I go to open, and the hood latch is stuck closed, not sure if that's a safety concern, but it was for me, as I could not access any important components of my vehicle, took it to the dealer, but still something of concern on a new vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Maverick