Ford Maverick Complaints (2022)

618 consumer complaints on file.

#11743262June 10, 2026
ELECTRICAL SYSTEM, ENGINE, STEERING
While driving at normal speeds. Car completely stopped working. Dashboard flashed to get to safe area. I could not shift the car neutral. Steering became stiff. The lights and infotainment was still on but the car had no power to accelerate. Had this been on the highway I would have been in a collision since my car went to the right very quick. Once car was stopped could not shift to neutral.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11741076May 30, 2026
POWER TRAIN
Transmission started slipping. Not wanting to pull in drive or reverse
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740980May 30, 2026
SERVICE BRAKES
NHTSA #26V104: I purchased this vehicle to rent it out on Turo (a vehicle sharing platform). It was de-listed from Turo on March 18 due to NHTSA #26V104 recall being unresolved. I have been unable to rent my vehicle since then and Ford has not provided a remedy to this recall. I would like to log a complaint that this software fix remedy has taken too long.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740369May 27, 2026
POWER TRAIN
Ford has 25N09 addressing the axles for the 2022 Ford Mavericks built later in the 2021 year, but mine was built in September of 21. I have axle issues as well, and this is the first vehicle I've ever had that's this new and has clunking in the CV axles. Mine clunks loudly, and the truck has 114k on it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739604May 22, 2026
STEERING, SUSPENSION
Front end of vehicle suddenly started to shake violently when accelerating. Issue was reproduced any time when accelerating. No warning was indicated by the vehicle. Car was undrivable above 50 mph. Vehicle had 25K miles. Dealer reproduced issue. Diagnosed it as a catastrophic failure of both CV joints and front bearing(s). Dealer would not release vehicle as it was undrivable due to extreme safety issue. Parts arrived after a week and both CV joints & front bearing(s) were replaced. Online reporting for this vehicle shows this is a repeated issue which the manufacturer has a customer satisfaction bulletin but no recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739007May 20, 2026
UNKNOWN OR OTHER
The chrome tips on the window switch fell off and jammed itself in the switch, in the on position for the passenger window. These exact parts are already on recall for different Ford models but it is the same part number being used.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738075May 15, 2026
ELECTRICAL SYSTEM, POWER TRAIN
Truck has stalled out multiple times, has been left in middle or road due to electrical drainage of battery. Person needed to get jumper cables to move truck.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737736May 14, 2026
SERVICE BRAKES
brake issue when coming to a stop, sometimes the brakes (mainly front) feel like they go free for a rotation. this is a random problem, and the dealer didn't find an issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737585May 13, 2026
STEERING, ELECTRICAL SYSTEM
I was trying to turn and the wheel kept kicking back the other direction. About a week prior to this as I was driving down the road all of a sudden the wheel threw me across a median and into incoming traffic almost causing multiple accidents. I have a video of it but it won’t allow me to upload it. [XXX] However this link should play it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736859May 10, 2026
FUEL/PROPULSION SYSTEM
Fuel leaking from pressurized tank, strong fuel smell. Photo attached shows pattern of fuel leak.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11736807May 9, 2026
ELECTRICAL SYSTEM, POWER TRAIN, SUSPENSION
When we brought it in for first oil change at the dealership ; when we got it back it had a broken axle which they tried to say we just needed new tires , after contacting service manager and he and I go for a ride in it they kept it for several weeks and put over 300 miles on it and got ford engineering involved to determine the cause was broken axle. It has been replaced again since then supposedly by a recall but it feels like it is broken again ! Ford took some shortcuts and used inferior parts, infrastructure etc , we had tremendous problems with the battery to which they said their shouldn’t be any reason for this be happening loss of power loss of electrical display and distribution finally I just had to replace the battery on my own because they refused to accept responsibility 4-6 months later a recall for the batteries was issued. The axles on the truck are not sufficient and they are not taking care of it properly! I would also like to report that they cut so many corners on the Maverick that the tailgate just drops no shock absorber nothing just slams on the bumper very dangerous! & They also chose to leave many open” holes” where mud rocks , leaves etc get into the front quarter panels from the hood area at the corner of windshield . So this wet material gets trapped in there n I’m sure will eventually affect the structural integrity of the panel - maybe rust through! Same thing happens with the tailgate fills with debris from bed , rear wheel wells also have a whole. I just wish ford would go back to how Henry Ford ran the company ! Help NHTSA
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733606April 24, 2026
POWER TRAIN
Vehicle started experiencing loss of power while driving on the highway. After having it towed to the local Ford dealership, we were informed that our transmission was shot and needed to be replaced. The vehicle had 62k miles on and no dash light warning and no ford pass warnings about the issue. It cost us $7k to replace and 4 months without the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732652April 21, 2026
ELECTRICAL SYSTEM
"Powertrain System Fault" was given from App, "service engine soon" on dash along with check engine light and "wrench". Dealership said Hybrid battery needs replaced. Dealership said "We don't know what the battery issue will effect if it does go bad." Corporate says "wear and tear item after 36000 miles or 3 years". I have also had to replace the 12V battery this year. I do not see how both batteries can "go bad" within 4 years of manufacturing... Online says truck could go into limp mode with no warning. Truck is available for inspection upon request. If truck will go into limp mode with no warning, could cause many safety issues. Problem initially occurred 3 days ago. Dealership cleared codes and has not happened again. Vehicle has only been inspected by dealership Only issue with electrical before EV battery was the 12V battery that went bad and had to be replaced. Went to start up the truck one afternoon (had been driving all day before this) and the lights on the dash popped on and the "Service Engine Soon" popped up and beeped. Drove it home that Saturday and did not drive it until dropped it off at dealership Monday morning. There must be something electrically causing problems since I just replaced my 12V battery about 6 months ago and now the EV battery is "bad". I've never heard of a Ford 12V battery not lasting at least 8 years. Multiple people I know have original 12V batteries in vehicles 2018 and older... Batteries should not be considered a "wear and tear item" batteries should be covered under their own warranties. Having basically no warranty on batteries poses a severe health risk with the disposal and creation of the old and new batteries.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732082April 18, 2026
STEERING, ELECTRICAL SYSTEM
When the battery voltage suddenly drops the vehicle loses its power steering making slow speed turns extremely difficult. This poses a serious risk of the inability to control the direction of the vehicle and this makes a crash extremely probable.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11731614April 16, 2026
ELECTRICAL SYSTEM
The contact owns a 2022 Ford Maverick. The contact stated that while her husband was driving 55-65 MPH, the vehicle shut off. The driver was unable to pull over to the side of the road. The driver was able to jumpstart the vehicle and continued driving. The contact stated that the failure recurred while pulling into a parking lot. The dealer was contacted and informed the contact that the vehicle could not be picked up due to safety concerns. The vehicle was towed to the dealer, where it was diagnosed, and determined that a new 12-Volt battery cable overlay was needed, and the current battery cable needed to be disabled. The dealer related the failure to the Ford Customer Satisfaction Program: 22B39 (2022 Maverick HEV No Start Condition), but the contact was informed that the Customer Satisfaction Program had expired. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure but denied assistance. The failure mileage was 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728142March 30, 2026
POWER TRAIN
There is a Ford Customer Satisfaction Program, 25N09 issued September 2025 which covers half shaft replacement for Mavericks manufactured from 12/01/21 through 11/23/22. The upgraded beefier replacement half shafts were not available until late 2024. The program states that if the half shafts on one side fails that that both half shafts are to be replaced. My 2022 Maverick was manufactured 11/21/2021 (the second month of production), a mere 10 days before the initial date of coverage. The half shaft on one side was replaced on 01/10/25 with the upgraded version of the half shaft under warranty. They did not replace the other side. If the beefier replacement half shafts were not available until late 2024 how am I to believe that my Maverick does not have the same under engineered pieces in the other 68,000 2022 Mavericks?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726022March 21, 2026
ELECTRICAL SYSTEM:ADAS:AUTONOMOUS/SELF DRIVING
Per a video posted on LinkedIn on March 20, 2026 by Chris Hackney, a Fountainhead Logistics Class 8 tractor displaying a Texas License plate on the front bumper & equipped with the Kodiak Robotics "Kodiak Driver" autonomous system was pulling three 40' belly dump trailers used to transport frac sand on an unknown public roadway in the West Texas Permian Basin in violation of Texas State law which prohibits triple trailers on public roadways. I can't confirm that the movement of the triple trailers shown in the video actually occurred on a public roadway vs a private lease road in the oil & natural gas fields where Fountainhead Logistics operates. I request NHTSA reach out to Fountainhead Logistics &/or Kodiak Robotics to confirm if such alleged illegal movement was made on a public roadway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725823March 20, 2026
ELECTRICAL SYSTEM
Had a service electrical system soon message, the had total failure while driving on interstate, lost all power and manuvered truck to side of the road, waited 15 minutes, restarted. Now, complete dead battery, replaced battery, still no start. There was a tsb for 2022 mavericks for bad battery cable but not for the time mine was built, but has same bad battery cable connection. Confirmed by dealer and in for replacement now, but my build month and they tsb ended in june 2023
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725172March 18, 2026
ELECTRICAL SYSTEM
My 2022 Ford Maverick Hybrid experienced a complete electrical system failure at approximately 15,933 miles, resulting in a no-start condition. The failure involved the vehicle’s electrical distribution system. An authorized Ford dealership (Autos Vega Ford) diagnosed that voltage was not reaching the Body Control Module (BCM) due to a fault in the battery cable and wiring system. The repair required replacement of the 12V battery, high-voltage battery cables, and wiring components. The failure was confirmed by the dealership (Autos Vega Ford) and required multiple jump starts, but the vehicle would not consistently restart after being turned off. There were no prior warning indicators before the failure. The issue occurred suddenly without warning. This failure created a safety risk because the vehicle could not be started or operated. If this failure occurred in an unsafe or remote location, it could leave occupants stranded and unable to move the vehicle. Service records are available through the authorized dealership (Autos Vega Ford). This appears to be a premature electrical system failure at low mileage involving critical components such as battery cables and wiring. Similar issues involving electrical systems, battery defects, and wiring faults have been reported in Ford Maverick Hybrid vehicles. The vehicle became inoperable without warning and required towing/assistance to reach a repair facility. A sudden no-start condition in a hybrid vehicle can create hazardous situations if it occurs in traffic, at intersections, or in remote areas where assistance is not immediately available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11724131March 13, 2026
POWER TRAIN
My 2022 Ford Maverick (EcoBoost AWD) experienced a sudden transmission failure at approximately 73,000 miles. The dealership diagnosed the issue as coolant contamination entering the transmission due to a failed heat exchanger/transmission cooler. The dealer stated that engine coolant mixed with the transmission fluid, which destroyed the transmission and required replacement of the transmission, replacement of heat exchangers, and flushing of the cooling system. The repair estimate is $11,324.39. Ford acknowledged the issue and provided partial goodwill assistance of $3,079, leaving more than $8,000 out of pocket for the repair. This failure occurred without warning and resulted in complete transmission failure. The dealer indicated that coolant contamination is the cause and referenced Ford service guidance addressing this failure scenario (SSM 53465). I am concerned that a failure of the transmission cooler/heat exchanger can allow coolant to contaminate the transmission and cause catastrophic drivetrain failure at relatively low mileage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Maverick